Académique Documents
Professionnel Documents
Culture Documents
PixieHollow.com
Things you need: 3 paper plates, A twig or stick that is at least 12 in length (approximately 1/4 diameter), Glue stick, Tape, and Scissors
Instructions
1.
Cut each piece using the outer area as a guide. DO NOT cut along the thin inner line yet, including the eye holes on the mask.
2.
Use a glue stick to glue each piece to the flat center of a paper plate.
3.
Once all the pieces have been glued down, cut each piece out along the thin inner line. Make sure to cut out the eye holes on the mask.
4.
Glue the antenna behind the left and right side of the mask.
5.
Attach a thin stick to the back side of the mask by securing it with tape.
H1h
Disney
Printable Crafts
PixieHollow.com
Cut along the inner line after this piece has been glued on a paper plate.
H2h
Disney
Printable Crafts
PixieHollow.com
Cut along the inner line after this piece has been glued on a paper plate.
H3h
Disney
Printable Crafts
PixieHollow.com
Cut along the inner line after this piece has been glued on a paper plate.
H4h
Disney