Vous êtes sur la page 1sur 3

Tips SAMSUNG SLIM 21 'horizontal transistors heat Revision 01 - September 2010

A friend technician for help with Samsung slim 21 "UOC TDA12156 - HOT transistor TT2222. Info planes did not exist a year already 4 times its HOT faulty transistor. When we replace the HOT and try on, apparently not one minute HOT already very hot. Our conjecture problem because HOT under the drive.

Then we were off again HOT and started doing some checking steps: Measure the voltage B +, normal results around 125V Measure the voltage supplied horizontal around 8v driver, this question mark?

Measure elko on the horizontal driver with ESR-meter, the results are still good. Our suspicions fall on horizontal driver problem caused less stress causing under-drive. We track the source voltage supplied from secondary tranfo switching. After we probe-probe results not see any damage parts. Then we learned the circuit more carefully (knowingly not have schematic).

Apparently suply circuit for horizontal-driver Samsung slim 21 "there is a bit special compared to other models. Here found there are 2 kinds of voltage supplied: Secondary voltage from 12V SMPS controlled by on-off mikrokontrol. This voltage fall only about 8v to tranfo horizontal-only driver and used to start any moment. After working flyback, the voltage change disuply (takeover) from the flyback voltage 17V (from the measurement results which we did).

See also Achirnya source of the problem. The voltage of the flyback drops due to "diode" that serves as a switch from horizontal driver fyback to tranfo slightly damaged, causing the voltage drops take-over.

The figure below merupalkan encountered similar circuits on one model of JVC. At the time of standby in which the horizontal section H drive has not worked from the get suply 11V SMPS secondary After working a horizontal section, H drive gets 45V suply of Flyback

Po

Vous aimerez peut-être aussi