Vous êtes sur la page 1sur 10

USDM Rom / wiring only Possible fault codes Yellow Tabs IC sprayer system Optional Red Tabs wiring

changes for ECU swap Evo 7 ECU JDM Pin


1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 No. 1 Injector No. 3 Injector Fuel Pressure Solenoid Idle Speed Control (ISC) Motor Coil (A1) ISC Motor Coil (B1) EGR Solenoid A/C compressor relay Evaporate Emission Purge Solenoid Ignition Power Transistor (for cyl 1&4) Turbo Wastegate Solenoid 12V Switched Power Supply Chassis Ground No. 2 Injector No. 4 Injector ISC Motor Coil (A2)

Evo 4

Connector 59 /C121
No.1 injector No.3 injector Fuel pressure control valve Idle Speed Control (ISC) Motor Coil (A1) ISC Motor Coil (B1) Secondary air control solenoid valve Fuel pump relay 1 Ignition Power Transistor (for cyl 1&4) Turbo Wastegate Solenoid 12V Switched Power Supply Chassis Ground No.2 injector No.4 injector ISC Motor Coil (A2)

18 19 20 21 22 23 24 25 26

ISC Motor Coil (B2) Volume Air Flow Sensor Reset Signal Radiator Fan Motor Relay (PWM Output) Fuel Pump Relay 2 Ignition Power Transistor (for cyl 2&3) A/C load signal 12V Switched Power Supply Chassis Ground

ISC Motor Coil (B2) Volume Air Flow Sensor Reset Signal Radiator fan motor relay (HI) Radiator fan motor relay (Lo) A/C compressor relay Ignition Power Transistor (for cyl 2&3) 12V Switched Power Supply Chassis Ground

Pin
31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46

Connector 60/C119
Condensor Fan Relay (Hi) Generator G Terminal Condensor Fan Relay (Lo) Intercooler Sprayer activation light Check Engine Light (Service Engine Soon) Power Steering Pressure Switch (Input) Engine control relay Fuel Pump Relay 3 (Additional pressure for higher loads) Sensor Ground (IAT, Cam and Crank Angle Sensors) Alternator FR terminal Clutch Position Switch (Input) Intercooler Sprayer switch (Auto) A/C pressure switch Fuel Tank Level (Input) USDM Alternator G terminal

Check Engine Light (Service Engine Soon) Power Steering Pressure Switch (Input) Engine control relay Fuel pump relay No.2 (Additional pressure for higher loads) Exhaust temperature warning lamp Alternator FR terminal

A/C pressure switch

Pin
51 52 53 54 55 56 Imobilizer ECU (Anti-Theft)

Connector 61/C117
Secondary Air System solenoid O2 Sensor Heater (rear) EVAP Vent Solenoid Valve USDM / IC spray relay JDM Diagnostic OBDII Pin 1

Diagnostic OBDII Pin 1

57 58 59 60 61 62

IC spray relay USDM Tachometer signal O2 Sensor Heater (front) Fuel Tank Differential Pressure Sensor USDM Diagnostic OBDII Pin 7 - K Line

Tachometer signal

Diagnostic OBDII Pin 7 - K Line

Pin
71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 Starter Signal Intake Air Temp Sensor Signal Manifold Differential Pressure Sensor USDM Sub Fuel Level Sensor USDM O2 Sensor (rear) O2 Sensor (front) Fuel Temperature Sensor USDM Knock Sensor ECU Init signal Backup Power Supply (12v Constant Power) 5V Sensor Power Supply (TPS, MDP, Baro, Fuel Tank Press Sensor) Ignition switch-IG Engine coolant temperature sensor Throttle Position Sensor Signal Barometric Pressure Sensor Signal Vehicle Speed Sensor Signal AYC/ACD signal Camshaft Position Sensor Signal Crankshaft Position Sensor Signal Volume Air Flow Sensor Signal Intercooler Sprayer switch (Manual) Sensor Ground (O2 Sensors, Coolant Temp, TPS, MDP, Fuel Tank Press Sensor)

Connector 62/ C115


Starter Signal Intake Air Temp Sensor Signal High temperature sensor O2 Sensor (front) High temp sensor Ground Knock Sensor Backup Power Supply (12v Constant Power) 5V Sensor Power Supply (TPS, MDP, Baro, Fuel Tank Press Sensor) Ignition switch-IG Engine coolant temperature sensor Throttle Position Sensor Signal Barometric Pressure Sensor Signal Vehicle Speed Sensor Signal Idle position switch Camshaft Position Sensor Signal Crankshaft Position Sensor Signal Volume Air Flow Sensor Signal Body earth Ground for sensors

Recap Swap cables 8 and pin 22 fuel pump relay with AC control relay

Disconnect pin 87 AYC/ACD signal Connect Cable 20 to pin 32 Rad Fan Hi to condensor fan Hi Connect Cable 21 to pin 34 Rad fan lo to condensor fan lo Connect cable 6 Secondary air system to pin 53 of Evo 7 ECU disconnect pin 91 or rewire for IC sprayer manual operation Evo 4 only disconnect pin 40 and ground cable or connect to pin 92 sensor ground Evo 4 only disconnect pin 33 if alternator is not charging battery

Evo 5/6

Operating Conditions
2 3 (at 20degC) 2 3 (at 20degC)

No.1 injector No.3 injector Fuel pressure control valve Idle Speed Control (ISC) Motor Coil (A1) ISC Motor Coil (B1) Secondary air control solenoid valve Fuel pump relay 1 Ignition Power Transistor (for cyl 1&4) Turbo Wastegate Solenoid 12V Switched Power Supply Chassis Ground No.2 injector No.4 injector ISC Motor Coil (A2)

2 3 (at 20degC) 2 3 (at 20degC)

ISC Motor Coil (B2) Volume Air Flow Sensor Reset Signal Radiator fan motor relay (HI) Radiator fan motor relay (Lo) A/C compressor relay Ignition Power Transistor (for cyl 2&3) 12V Switched Power Supply Chassis Ground

Fan at high speed (coolant temperature: 105C or above) Fan at low speed (coolant temperature: 90 100C)

Alternator G terminal

Check Engine Light (Service Engine Soon) Power Steering Pressure Switch (Input) Engine control relay Fuel pump relay No.2 (Additional pressure for higher loads) Sensor Ground (IAT, Cam and Crank Angle Sensors) Alternator FR terminal

A/C pressure switch

Diagnostic OBDII Pin 1

Tachometer signal O2 Sensor Heater (front) Diagnostic OBDII Pin 7 - K Line

Starter Signal Intake Air Temp Sensor Signal

O2 Sensor (front) Knock Sensor ECU Init signal Backup Power Supply (12v Constant Power) 5V Sensor Power Supply (TPS, MDP, Baro, Fuel Tank Press Sensor) Ignition switch-IG Engine coolant temperature sensor Throttle Position Sensor Signal Barometric Pressure Sensor Signal Vehicle Speed Sensor Signal Idle position switch Camshaft Position Sensor Signal Crankshaft Position Sensor Signal Volume Air Flow Sensor Signal Body earth Ground for sensors

n 92 sensor ground y

Vous aimerez peut-être aussi