Académique Documents
Professionnel Documents
Culture Documents
Use For jointing XLPE- and EPR-insulated cables with Al- and Cu-conductor and various types of cable sheaths. Standard Meets the requirements of: IEC 62067 including Annex D Design The cable joint consists of a premolded joint tube with two premolded adapters made in rubber, a bolt connector and a prefabricated PUR casted copper casing as a protective outer jacket.
SMPGB-C 420 SMPGB 420
See table below for diameter across the prepared insulation. The joint is available in two different types: SMPGB: Straight cable joint. SMPGB-C: Cross-bonded cable joint. The joint is available for different types of cable screens and cable sheaths. PAL For aluminium laminated cable. Pb For cables with metal screen; lead, corrugated copper/aluminium or corrugated stainless steel. The following cable data should be stated when ordering: Voltage Diameter of prepared insulation Conductor cross section Conductor diameter Conductor material, Cu or Al Screen, cross section and type If optical fibres in screen Note: Torque wrench and installation tool RKM 420 are needed when assemblying. For corrugated copper and stainless steel, the flux is not included in the soldering kit. For flux, contact your local supplier.
Designation SMPGB 420 Pb SMPGB 420 PAL SMPGB-C 420 Pb SMPGB-C 420 PAL
6/31 | Kabeldon cable accessories 1420 kV | Cable accessories for XLPE-insulated cables 52420 kV
Technical specification, tools and accessories SMPGB 420 and SMPGB-C 420 kV
Dimensions in mm
575
2000
SMPGB 420
575
2000
SMPGB-C 420
Max 3 m
OKJ 1 Opto fiber kit for cables with integrated optical fibers in the earth screen.
Description Installation tool for SMPGB 420 kV Kit for splicing of optical fibers Integrated PD-measurement sensor for measuring of partial discharges in SMPGB 420
Cable accessories for XLPE-insulated cables 52420 kV | Kabeldon cable accessories 1420 kV |
6/32