0 évaluation0% ont trouvé ce document utile (0 vote)
1K vues4 pages
SPARK PLUG (PLATINUM-TIPPED TYPE) REMOVAL and INSTALLATION Top of Form Top of Form Zoom Bottom of Form Sized for Print Bottom of Form 6. Remove the six ignition coils using a suitable tool. If replacing the spark plugs use the correct SPARK PLUG for maximum performance.
SPARK PLUG (PLATINUM-TIPPED TYPE) REMOVAL and INSTALLATION Top of Form Top of Form Zoom Bottom of Form Sized for Print Bottom of Form 6. Remove the six ignition coils using a suitable tool. If replacing the spark plugs use the correct SPARK PLUG for maximum performance.
Droits d'auteur :
Attribution Non-Commercial (BY-NC)
Formats disponibles
Téléchargez comme DOCX, PDF, TXT ou lisez en ligne sur Scribd
SPARK PLUG (PLATINUM-TIPPED TYPE) REMOVAL and INSTALLATION Top of Form Top of Form Zoom Bottom of Form Sized for Print Bottom of Form 6. Remove the six ignition coils using a suitable tool. If replacing the spark plugs use the correct SPARK PLUG for maximum performance.
Droits d'auteur :
Attribution Non-Commercial (BY-NC)
Formats disponibles
Téléchargez comme DOCX, PDF, TXT ou lisez en ligne sur Scribd
2. Drain engine coolant. 3. Disconnect the mass air flow sensor electrical connector and remove the upper air cleaner case, mass air flow sensor and air cleaner to electric throttle control actuator tube. 4. Remove the intake manifold collector, gasket, and electric throttle control actuator. 5. Remove the six ignition coils. CAUTION: Do not shock it. Top of Form Top of Form
Zoom Sized for Print
Bottom of Form Bottom of Form
6. Remove the six spark plugs using a suitable tool.
• If replacing the spark plugs use the correct spark plug for maximum performance. INSPECTION AFTER REMOVAL Use standard type spark plug for normal driving conditions. The hot type spark plug is suitable when fouling occurs with the standard type spark plug under conditions such as: • Frequent engine starts • Low ambient temperatures The cold type spark plug is suitable when engine spark knock occurs with the standard type spark plug under conditions such as: • Extended highway driving • Frequent high engine revolution
Top of Form Top of Form
Zoom Sized for Print
Bottom of Form Bottom of Form
Do not use a wire brush for cleaning.
If plug tip is covered with carbon, a spark plug cleaner may be used. Cleaner air pressure: less than 588 kPa (6 kg/cm2, 85 psi) Cleaning time: less than 20 seconds Top of Form Top of Form
Zoom Sized for Print
Bottom of Form Bottom of Form
Checking and adjusting plug gap is not required between change intervals. Gap (nominal): 1.1 mm (0.043 inch)
INSTALLATION Installation is in the reverse order of removal.