Vous êtes sur la page 1sur 10

UTS

Buatlah program Ladder Diagram dengan software cx-programmer untuk soal nomor 1 s/d 4,
sesuai dengan petunjuk soal nomor 3 dan 4.
1. A. Perancangan program
Step 1 : FS, Motor enable & Motor direction ; OFF
Step 2 : PB OPEN, Motor enable ; ON
Step 3 : SENSOR OPEN MAX, Motor open ; OFF
Step 4 : PB CLOSE, Motor enable & Motor direction : ON
Step 5 : SENSOR CLOSE MAX, Motor enable & Motor direction ; OFF
B. Addres Input/Output
Input :
PB OPEN : 0.00
PB CLOSE : 0.01
S CLOSE MAX : 0.02
S OPEN MAX : 0.03
Output :
Motor enable : 100.00
Motor direction : 100.01
C. Ladder Diagram

2. A. Perancangan program
Step 1 : First flag (always on), Jam ANDW A352 D0 dan Menit ANDW A351

Step
Step
Step
Step

2
3
4
5

:
:
:
:

08.15
16.15
08.20
16.25

motor on selama 5 menit


motor on selama 10 menit
motor stop
mtor stop

3. A. Perancangan program

Step 1 : PB ON, Mesin A ; ON


Step 2 : Mengaktifka counter
Step 3 : PB STOP, Mesin A ; OFF
Step 4 : PB ON, Mesin B ; ON
Step 5 : Mengaktifkan counter
Step 6 : PB STOP, Mesin B ; OFF
Step 7 : PB ON, Mesin C ; ON
Step 8 : Mengaktifkan counter
Step 9 : PB OFF, Mesin C : OFF
B. Input/Output
Input :
PB ON : 0.00
PB NC : 0.01
Output :
Mesin A : 100.00
Mesin B : 100.01
Mesin C : 100.02
C. Ladder diagram

4. A. Perancangan program
Step 1 : PB ON, Mesin A ; ON

Step 2 : Mesin B : ON
Step 3 : Mesin C ; ON
B. Input/Output
Input :
PB ON : 0.00
PB STOP : 0.01
Output :
Mesin A : 100.00
Mesin B : 100.01
Mesin C : 100.02
C. Ladder diagram

Vous aimerez peut-être aussi