Académique Documents
Professionnel Documents
Culture Documents
INTRODUCTION
The analyzed Filter element bulkhead was designed to withstand pressure load
of 125 psig (0.861875 MPa) as structural component as specified on Pressure
vessel datasheet for Dry Gas Filters Doc. No. 6A026-731J-0001 Rev.A.
A FE model and Stress analysis of Filter element bulkhead was built and run
using the ANSYS WORKBENCH 9.0 finite element software.
Page : 91
Modeling of Filter element Bulkhead
Page : 92
Pressure load 0.861875 MPa (125 psig) is working on Filter element Bulkhead
Page : 93
The Max. Local Primary Membrane Stress is 76.45 MPa (11088.2 psig) is created on
filter element Bulkhead due to pressure load, this is acceptable as allowable stress =
1.5*137.9 MPa = 206.85 (30000 psi)
Page : 94