0 évaluation0% ont trouvé ce document utile (0 vote)
62 vues1 page
The document provides troubleshooting information for a Rosemount 3051 Wireless transmitter and wireless network. For the transmitter, it lists symptoms such as an unresponsive or erratic pressure reading, and recommends checking the test equipment, impulse piping, calibration, and pressure calculations. For the wireless network, it lists symptoms such as a device not joining or short battery life, and recommends actions like verifying the network ID and join key, enabling active advertising, checking the power module, and optimizing the update rate.
The document provides troubleshooting information for a Rosemount 3051 Wireless transmitter and wireless network. For the transmitter, it lists symptoms such as an unresponsive or erratic pressure reading, and recommends checking the test equipment, impulse piping, calibration, and pressure calculations. For the wireless network, it lists symptoms such as a device not joining or short battery life, and recommends actions like verifying the network ID and join key, enabling active advertising, checking the power module, and optimizing the update rate.
The document provides troubleshooting information for a Rosemount 3051 Wireless transmitter and wireless network. For the transmitter, it lists symptoms such as an unresponsive or erratic pressure reading, and recommends checking the test equipment, impulse piping, calibration, and pressure calculations. For the wireless network, it lists symptoms such as a device not joining or short battery life, and recommends actions like verifying the network ID and join key, enabling active advertising, checking the power module, and optimizing the update rate.
Check impulse piping or manifold for blockage Verify applied pressure is within sensor limits
Digital Pressure Variable reading is low or
high
Check test equipment (verify accuracy)
Check impulse piping for blockage or low fill in wet leg Verify transmitter is calibrated properly Verify pressure calculations for application
Digital Pressure Variable reading is erratic
Check application for faulty equipment in pressure line
Verify transmitter is not reacting directly to equipment turning on/off
LCD display is not functioning
Reseat the LCD according to Installing the LCD display on page 46
Verify that the LCD display is a wireless LCD Meter. An LCD from a wired device will not function in a wireless device. Rosemount part number: 00753-9004-0002 Verify that the LCD display mode is not disabled.
Table 6-3. Wireless Network Troubleshooting
Symptom
Recommended Actions
Device not joining the network
Verify network ID and join key
Wait longer (30 min.) Enable High Speed Operation (Active Advertising) on Smart Wireless Gateway Check Power Module Verify device is within range of at least one other device Verify network is in active network advertise Power Cycle device to try again Verify device is configured to join. Send the Force Join command to the device See troubleshooting section of Smart Wireless Gateway for more information
Short battery life
Check that Power Always On mode is off
Verify device is not installed in extreme temperatures Verify that device is not a network pinch point Check for excessive network rejoins due to poor connectivity
Limited Bandwidth Error
Reduce the Update Rate on transmitter
Increase communication paths by adding more wireless points Check that device has been online for at least an hour Check that device is not routing through a limited routing node Create a new network with an additional Smart Wireless Gateway