Académique Documents
Professionnel Documents
Culture Documents
4 mm
TABLE B4.3c SIFs for Typical Weldolet Branch Connections (Run Pipe Size: NPS 2 (DN 65) and NPS 3 (DN 80)
B.127
Downloaded from Digital Engineering Library @ McGraw-Hill (www.digitalengineeringlibrary.com)
Copyright 2004 The McGraw-Hill Companies. All rights reserved.
Any use is subject to the Terms of Use as given at the website.
1 in = 25.4 mm
TABLE B4.3d SIFs for Typical Weldolet Branch Connections (Run Pipe Size: NPS 4 (DN 100) and 6 or (DN 150)
B.128
Downloaded from Digital Engineering Library @ McGraw-Hill (www.digitalengineeringlibrary.com)
Copyright 2004 The McGraw-Hill Companies. All rights reserved.
Any use is subject to the Terms of Use as given at the website.
B.129
TABLE B4.3e SIFs for Typical Weldolet Branch Connections (Run Pipe Size: NPS 8 or
DN 200)
1 in = 25.4 mm
(B4.21)
where t = run pipe wall thickness, in
r = run pipe mean radius, in
rb = branch pipe mean radius, in
These equations are for integrally reinforced branch connections such as latrolets. By
the analogy used in Fig. NC-3673.2(b)-1 in Section III of the ASME Code, the SIF for
unreinforced 45 branch connections (stub-ins) can be obtained by multiplying the
factors obtained above by (4.4)2/3 = 2.685.
B.130
TABLE B4.3f SIFs for Typical Weldolet Branch Connections (Run Pipe Size: NPS 10
(DN 250))
1 in = 25.4 mm
e. Pipet
(B4.22)
B.131
TABLE B4.3g SIFs for Typical Weldolet Branch Connections (Run Pipe Size: NPS 12 or
DN 300)
1 in = 25.4 mm
f. Branchlet
(B4.23)
g. Reducing elbow
(B4.24)