Académique Documents
Professionnel Documents
Culture Documents
Introduction
Equipment:
1- .
2- .
3-
Apparatus
procedure
the azimuth was calculated using the two coordinates of
(SQU015) and (SQU027) the total station was setup at the
required points (SQU015), and total station was adjusted by
centering the bubble. The prism was set at (SQU027). The
coordinates of (SQU027) and the horizontal distance
between the two points were observed and compared with
the data conducted. The prism was located in each point as
according to the sketch in order to start conducted
Result:
Area1
Height (m)
Northing (m)
53.371
Easting (m)
Station
618753.254
618760.148
618767.049
618774.118
618781.000
618791.332
618795.200
618754.795
31
2609395.010
53.343
2609395.510
53.328
2609395.901
53.376
2609396.213
53.544
2609395.790
54.646
2609397.747
54.671
2609392.190
53.336
Height (m)
54.108
54.565
54.385
54.435
54.194
54.372
53.916
54.336
2609370.624
Northing (m)
Easting (m)
Station
2609445.984
2609357.332
618784.316
618789.723
618806.828
618789.207
618816.610
618788.870
618817.126
618788.677
54.237
2609453.294
618788.450
5.
54.226
2609460.403
618788.090
6.
54.123
2609467.035
618788.081
7.
53.905
2609451.341
618774.972
21
53.910
2609458.350
618774.713
22
53.842
2609465.151
618774.169
23
2609427.581
2609365.059
2609431.720
2609365.697
2609438.960
2609366.315
36
1.
39
2.
40
3.
41
4.
area 2
Figure
Discussion of result:
The results are shown in the table above. The points
coordinate chosen in the two areas are conducted with the
instrument. Some extreme points are used to draw the
maps. Proper shape for the area was drawind by conducted
the points.
Conclusion
In conclusion, the selection points created the shape of the
areas. The elevation ,coordinates, bounders and details
coordinate are knowing of each point were founded by total
station and drawn by AutoCAD.