Académique Documents
Professionnel Documents
Culture Documents
This
pressure regulation occurs just before the manifold by
Cevap : the low pressure bleed air valve.
2. Fuses are rated to a value by:
Cevap : the number of amperes they will carry.
3. In a steep turn to the left, when using spoilers
Cevap : The right aileron will descend, the left one will ascend, the right spoiler will retract and the left
one will extend.
4. The water separator of an air-conditioning unit is located at the cooling unit
Cevap : outlet and uses a centrifugal process.
5. A tubeless tyre has :
1- a built-in-air tube.
2- 2- no built-in-air tube.
3- 3- a crossed side casing.
4- 4- a radial side casing.
The combination of correct statements is
Cevap : 2, 4.
6. Which of these signals are inputs, at least, in the stall warning computers?
Cevap : Angle of attack and flaps and slats deflection.
7. As regards the Generator Control Unit (GCU) of an AC generator, it can be said that:
1. The GCU controls the AC generator voltage
2. Modern GCUs are provided with a permanent indication to record the failure
3. All the commands originating from the control panel are applied via the GCU, except dog
clutch release
4. The Auxiliary Power Unit (APU) provides the excitation of the AC generator as soon as the APU
starts up
The combination regrouping all the correct statements is
Cevap : 2, 3.
8. The Low Altitude Radio Altimeter uses the following wavelengths;
Cevap : centimetric.
9. The Microwave Landing System (MLS) uses the following wavelengths;
Cevap : centimetric.
10. A public transport aircraft is operated at FL 390. The total number of oxygen dispensing units and
outlets in the cabin must be at least the same as the total number of
Cevap : seats exceeded by 10%.
11. The Fan Markers uses the following wavelengths ;
Cevap : metric.
12. The airborne weather radar uses the following wavelengths;
Cevap : centimetric.
13. The secondary Surveillance Radar (SSR) uses the following wavelengths;
Cevap : decametric.
14. When a persistent overexcitation fault is detected on only one AC generator, the protection
device opens the;