UR uceaoe ren een xe) Uae a 7,
M3500: FLOAT CONTROLLED MODULATING CONSTANT LEVEL VALVE Brrwova
OPERATING PRINCIPLE
The valve shall be fully open when the float is at the minimal controlled water level in the reservoir
and totally closed with the maximal level. The float pilot lft is 10 om.
Changes in water level are controlled by the float pilot. Through the action of the pilot and hydraulic
synchronizer the pilot lift and the main valve lift are completely balanced. It's means that for any rate
of flow discharged by the reservoir, the float pilot drive the main valve to rich the balancing between
inlet flow rate and outlet to the consumption. The stability and the reliability of the system is very
higher. The float pilot and the synchronizer are made in stainless steel. Valves normally used with
gravity supplied reservoir.
ADDITIONAL FEATURES AVAILABLE:
+ pressure sustaining, the valve maintain a minimal inlet pressure;
+ solenoid on-off control function. A remote controller switch on/off the valve;
. check function. When the outlet became higher than inlet, the function prevent the back flow;
+ anti-freeze option;
+ flow rate limiter control;
+ pressure relief or maximum inlet pressure surge control
113M3000/M2000 AUTOMATIC CONTROL VALVE
CIRCUIT DESCRIPTION wwovat
DRAIN
2b
ITEM DESCRIPTION MATERIAL,
1 | Main valve (04840015 EN1563
2 (a,b) | Isolating ball valve Niplated Brass
3_| Y-stiner wth calirated orifice 1.4401 EN10086-3 + Brass
4 _|_ Hydraulic synchronizer 1.4301 EN10086-3 + Brass
5 | C1500 float plot 41,4301 EN10088-3 + Brass
6 _| Position indicator with manual venting cock Brass + Hardened glass
7 _| Gauge holder with drainage Niplated Brass
8 | Pressure gauge 1.4301 EN10086-3 + Glycerine
= | Pipe 41.4304 EN10088-3
=| Fittings 1.4401 EN10088-3 + Brass
213PRUs cere user ZA
INSTALLATION: TYPE A.
IN-TANK INSTALLATION. (Float placed in a calm zone)
Low DIRECTION,
INSTALLATION: TYPE B.
(OUT-OF-TANK INSTALLATION.