Académique Documents
Professionnel Documents
Culture Documents
then took bnc to bnc cable, and change with T-connector. connect the BNC TO
BNC cable from the generator to the oscilloscope channel 1 as a carrier I / P.
then connect the function generator to the module with a bnc to alligator cable.
After that, connect the bnc to the alligator cable using a banana to banana
cable. place banana to banana cable at pwm I / P and at the ground.
5. Adjust VR1 to minimize distortion of the output signal U1 (A741).
6. Adjust VR2 and VR3 until we get a signal demodulated correctly.
then connect the bnc to alligator cable on a channel 2 at oscilloscope to the
output of a module with a connecting banana to banana cable .
7. Using the oscilloscope, observe the PWM input signal, the carrier signal, the
output signal U1 (test point TP1), U2 output signal (test point TP2), the output
signal of the MC1496 pin 10 (test point TP3), the output signal of the MC1496 pin
1 (test point TP4), the output signal of the MC1496 pin 12 (TP5 test point), the
input signal of the low-pass filter (test point TP6) and signal demodulation PWM
(Audio O / P) with move banana to banana cable from one point to other point.
Finally, record the measured results in Table 4-1.