0 évaluation0% ont trouvé ce document utile (0 vote)
20 vues1 page
This document provides instructions for making a simple hand pump model using common household items. The pump is constructed using a black film canister for the cylinder, bottle caps for the piston and valves, bicycle spoke for the connecting rod, and rubber tubing. Key steps include cutting the bottle caps to form the piston and valves, attaching the rubber tubing to the caps to create hinged flaps, and assembling the components by inserting the spoke through holes in the canister. When working properly, the up and down motion of the spoke will draw water into the canister through one valve and push it out of the delivery pipe through the other valve.
This document provides instructions for making a simple hand pump model using common household items. The pump is constructed using a black film canister for the cylinder, bottle caps for the piston and valves, bicycle spoke for the connecting rod, and rubber tubing. Key steps include cutting the bottle caps to form the piston and valves, attaching the rubber tubing to the caps to create hinged flaps, and assembling the components by inserting the spoke through holes in the canister. When working properly, the up and down motion of the spoke will draw water into the canister through one valve and push it out of the delivery pipe through the other valve.
Droits d'auteur :
Attribution Non-Commercial (BY-NC)
Formats disponibles
Téléchargez comme PDF, TXT ou lisez en ligne sur Scribd
This document provides instructions for making a simple hand pump model using common household items. The pump is constructed using a black film canister for the cylinder, bottle caps for the piston and valves, bicycle spoke for the connecting rod, and rubber tubing. Key steps include cutting the bottle caps to form the piston and valves, attaching the rubber tubing to the caps to create hinged flaps, and assembling the components by inserting the spoke through holes in the canister. When working properly, the up and down motion of the spoke will draw water into the canister through one valve and push it out of the delivery pipe through the other valve.
Droits d'auteur :
Attribution Non-Commercial (BY-NC)
Formats disponibles
Téléchargez comme PDF, TXT ou lisez en ligne sur Scribd
the centre and a 6-mm hole for the delivery valve port. 1. For making this pump you will 2. With a sharp scissors cut and Apply Fevibond to a 2-cm require a black film-reel bottle, remove the outer circle of the x 1-cm piece of bicycle one more cap, a cycle spoke, cap. The inner circle will make a rubber tube and stick it to old cycle tube, an old refill, superb piston. Rub it a little on cover the hole. This rubber simple hand tools and Fevibond sandpaper so that it is free inside will act like a hinge and - a rubber adhesive. the bottle - the cylinder. open and close like a valve.
6. Take another film-reel
bottle cap and make a 6-mm hole in it. Apply Fevibond to 4. Cut a 12-cm long piece a 2-cm x 1-cm piece of tube from a bicycle spoke Fix the rubber and stick it on one piston on the spoke threads 5. This is the piston, delivery valve side to cover the hole. This is with two nipple nuts. and connecting rod assembly. the suction valve.
8. Insert the spoke through
the bottle base and snap the suction valve lid to complete the hand pump assembly. Keep the pump in a bowl of water and move the spoke up and down. After a few priming strokes large quanta 7. Make a 3-mm hole in of water will gush out of the the centre of the bottle delivery pipe with every base so that the cycle upward stroke of the spoke. spoke can move freely Both the rubber washers - in it. Make another hole stuck only on one side as on the curved surface hinges, act as very efficient near the base and fix an valves. This is a superb model old refill or Frooti straw to understand the working of in it. This is the delivery a real hand pump. pipe.