Académique Documents
Professionnel Documents
Culture Documents
Cold Start
When start using the CodeProx for the time, it is advised to coldstart the system to clear the internal memory and reset
the system to default setting.
Upon switching on the unit, it will enter power up mode and the RED LED will be blinking for 10 seconds. During this
moment press the exit button for approximately 2 seconds to ColdStart the system.
Note: After coldstart, AutoPin Mode is turned OFF by default. After programming new Pin, remember to enable AutoPin
Mode through Programming Mode or using SuperPin.
Programming Mode
To access the programming mode, user has to press *(asterisk) followed by the Master Pin number (Default = 123456).
SuperPin
This is a shortcut to enable or disable AutoPin Mode. In idle mode, press *(asterisk) and the the 6 digits SuperPin to
enable or disable the AutoPin Mode (Default = 987654).
Wiring Diagram
_
+
Exit Push
+
Button
Magnetic
From +12V
regulated power
supply ( min 2A)
_ EM Lock
contact