Académique Documents
Professionnel Documents
Culture Documents
(Spacelink-2400BFA-Y)
I. TOOLS REQUIRED
1pc. M10 open wrench
1pc. Screw Driver
1) Antenna
2) Bracket
3) Galvanized Steel Pipe
4) SMA Connector
5) Polarization Mark
4. Use the modem LED indicator and modem GUI WIMAX status to find the best
signal and link quality while adjusting the position of the antenna. You can adjust
the up and down tilt of the antenna. The following are the preferred WIMAX
status:
RSSI: -57.5 dBm to -47.5 dBm (LED Status Indicator: Four LEDs on)
DL_FEC: 64-QAM(CTC)3/4
UP_FEC: QPSK (CTC)1/2
V. INSTALLATION GUIDELINES
1. Install the antenna on area with clear view of the donor cell (WIMAX BTS) as
much as possible.
2. Point the antenna directly on the donor cell (WIMAX BTS)
3. Adjust the up and down tilt of the antenna if necessary.
4. Ensure the connection between the antenna cable connector and the CPE is well
fixed. (Do not use special tools, hand tight only).
5. Fixed the connection of the mounting brackets using right tools.
6. Make sure the antenna is installed in a safe and suitable location and well clear
away from high power lines.
7. Do not attempt to carry out installation when it is raining, snowing or during
stormy weather.
8. Not recommendable installing the antenna on the rooftop since the external
antenna is not lightning proof.
9. Do not attempt to install the antenna on a pole of diameter other than the
specified 30~50mm.