The weight of the bar can be neglected. What is the maximum offset(dimension x) If the allowable stress in tension is limited to 70Mpa .Where will maximum tensile shear stress occur?
Q6)A crane hook carries a load of 20KN
as shown in figure.The section at X-X is rectangular whose vertical side is 20mm.find the stresses in the inner fibre at the given section
Q17)consider a crane hook made from a
50 mm dimeter bar and loaded as shown in figure.Determine the maximum tensile stress and specify its location.
40mm
Q22)determine the stress at A and B of a
machine part loaded as shown in figure Ri=100mm
Q24)A load of 2Kn is applied to the
frame of rectangular cross section of 12X40 as shown.calculate the circumferential stresses at A and B and compare these values with values found by using the straight beam formula Q25) A load of 60KN is applied to a c frame of rectangular cross section as shown in figure.for the section AB determine 1)Tensile force2)Bending moment 3)maximum tensile stress4)maximum shear stress and location
Q26)the offset bar has force applied as
shown in figure.The effect of the two applied force is a couple which causes the same bending moment at every section of the beam.Determine the maximum tension ,compression and shear stress ,and maximum shear stress and state where it occurs.
Q28)Figure shows the critical section of
a 60KN capacity carne hook.determine the dimensions of the section if the maximum stress is not to exceed 60Mpa.