Académique Documents
Professionnel Documents
Culture Documents
c
Memory Failure Plug In or Replace Power Cord, Power Cords Can Fail Even
Though They Look Fine.
Replace The Power Supply; Use a Known-good Spare For Testing.
Replace Motherboard, Use a known-good spare for testing.
Remove All Memory (RAM) retest. if the system still wont boot replace bank 1.
2) System Beeps on start up, Fan is running, no cursor on screen. Improperly
Seated or failing graphics adapter. Reset or replace graphics adapter, use
known-good spare or testing.
3) Operating System will not boot.
Monitor is malfunctioning
VGA card is not seated properly in the slot. First check the monitor. is it plugged
in, turned on, and the cable connected correctly. are the brightness and
contrast knobs turned on full? If these two possibilities are ruled out, make the
VGA card is seated correctly in the BUS. finally, install the video card in another
video card and see if your monitor cranks up.
11) Slow video performance with any card type. Video BIOS is not cached.
Enable caching of video BIOS.
12) Picture displayed in DOS, but not in windows. Wrong video driver. Start
system in safe mode, verify video driver and install the correct driver.
13) System Reboots Power good voltage level is out of limit. Check PSU with
multi-meter. replace power supoply.
14) Electrical Shocks on case. Power supply is not grounding properly. Change
power cable to 3pin cable. check domestic wiring for faults.
15) System Cant Maintain correct date & Time when turned off. CMOS battery
about to fail. Replace CMOS battery.
16) BIOS Update fails BIOS are not compatible. Enable flash recovery features
and restore BIOS.
17) Key board failure error appears when starting the system. Keyboard not
plugged in properly.
Keyboard cable or keyboard jack is defective. Re insert the keyboard connector
to port. test network cable and jack using a millimeters..
18) Keys are sticking. Keyboard might have dust inside keys. Remove key tops
and clean under keys, or wash out keyboard.
By;
þ
p