Académique Documents
Professionnel Documents
Culture Documents
A3757
June 2004
A3757 Entry Document
1. Introduction
Vehicle theft is a big nuisance for vehicle owners. It usually happens that in a
congested market where no authorized parking arrangements are available, if you park
your vehicle then the chance of getting your vehicle at the same place after shopping,
is a big question. Even in residential colonies incidences of vehicle theft are quite
common. Commercially available vehicle security systems are very costly especially
for two-wheeler owners. This is the place from where motivation comes to develop a
low cost affordable vehicle security system (VSS) with same robustness as of costlier
ones.
In this project efforts are made to develop a low cost vehicle security solution
using Atmel’s Atmega8 microcontroller with Analog Device’s low cost acceleration
sensor ADXL311JE and Dallas semiconductor’s DS1973 iButton.
ADXL
311 A
T DS1973
M IButton
E
Battery G
A
8
Siren with
driver circuit
Figure 1: Block diagram of VSS
+5V +5V
RESET PC5
PD0 PC4
200 k
PD1 PC3
PD2 PC2 0.1
PD3 PC1
ADXL311
+5V PD4 PC0
VCC GND
0.1 GND ATMEGA AVREF +9V
Mechanical
iButton Key Slot
Holder
3
A3757 Entry Document
Atmega8
IButton in
Key ring
Acceleration
Sensor Module
SIREN