Académique Documents
Professionnel Documents
Culture Documents
com
INTRODUCTION
This trainer has been designed with a view to provide practical & experimental knowledge of a general circuit of Audio Input Module on SINGLE PCB. SPECIFICATION 1. 2. 3. 4. 5. Power supply requirement Input signal Gain Standard Accessories : : : : 230V AC, 50 Hz. +6V, 250mA. Through Dynamic Microphone 100dB 1. A Training Manual. 2. Connecting Patch cords.
CHAPTER-1 THEORY & CIRCIUT DETAILS The Input Audio amplifier circuit consists of Pre-amplifier and Output amplifier stage. This section is used to amplify low level audio signal coming from Mike and give it to Loudspeaker. The pre-amplifier consists of one transistor BC 548B is connected in C-E configuration. The input signal from mike is connected to the base of BC548 through coupling capacitor. The amplified audio signal obtained at the collector of BC548 is given to the output driver amplifier consisting of IC TBA810 at pin 10 through volume control 10K Preset/ Pot. The IC TBA810 performs the functions of the audio amplifier, driver and the output stage. The amplified output signal available at the Pin 16 of this IC is given to Loudspeaker via coupling capacitor. The regulated power supply is used for different supply voltages. Following output D.C. Voltages are required to operate AM Modulation demodulation system. +6V, 250mA , Three terminal regulator IC 7806 is used for +6V output voltage
***************
EXPERIMENT-1 Aim: To amplify audio signal. Procedure: 1. Connect Dynamic microphone at input terminals of Audio input module. 2. Speak to mike and observe amplified output signal on CRO at output terminals. 3. Vary gain of amplified signal by gain pot. Conclusion :The theory of Audio amplifier understood. ******************