Académique Documents
Professionnel Documents
Culture Documents
THERMOGUARD PP IV+
TEMPERATURE CYCLE SENTRY COOL HEAT DEFROST HIGH SPEED
SETPOINT
HOURS
OIL PRESS
WATER TEMP
AMPS
ALARM
Continuous Mode - Turn the unit "on". Hold the Preheat/Start switch in the "Preheat" position for 10 to 90 seconds depending on ambient temperature. Then press the Preheat/Start switch to the "Start" position to start the engine. Cycle Sentry Mode - Turn the unit "on". If no other key is pressed, the engine will automatically preheat and start in about 10 seconds.
ON
START
MANUAL
CYCLE SENTRY
OFF
PREHEAT
DEFROST
CONTINUOUS
Used On: SB-III SR and SB-III SR+, Super-II SR and Super-II SR+, RMN SR and RMN SR+
with version 01xx, 02xx, 03xx and 04xx software TK 40431-6 13 August 1998
ALARM CODES
00 01 02 03 04 05 06 07 09 10 11 12 13 15 16 17 18 19 20 21 22 23 24 25 26 28 29 30 31 32 33 34 35 36 37 38 40 41 42 43 44 No Fault Power Up Reset (Data Log Only) Evaporator Coil Sensor Return air Sensor Discharge Air Sensor Ambient Air Sensor Engine Water Temp Sensor Engine RPM Sensor High Evaporator Temp High Discharge Pressure Unit Controlling on Discharge Air Sensor Sensor Shutdown Check Sensor calibration Glow Plug Check Manual Start Not Completed Engine Failed to Crank High Engine Water Temp Low Engine Oil Pressure Engine Failed to Start Cooling Cycle Check Heating Cycle Check Cooling Cycle Fault Heating Cycle Fault Alternator Check Check Refrigeration Capacity Pretrip Abort Defrost Damper Circuit Damper Stuck Closed Oil Pressure Switch Refrigeration capacity low Check Engine RPM Check Modulation Circuit Run Relay Circuit Electric Motor Failed to Run Check Engine Water Level Electric Phase Reversed High Speed Circuit Engine Water Temperature Check Unit Forced to Low Speed Unit Forced to Low Speed Modulation Fuel System Check 45 46 50 52 54 55 61 62 63 64 66 70 71 72 73 74 75 76 77 78 79
ALARM CODES
Hot Gas Circuit Air Flow Check Reset Clock Heat Circuit Test Mode Timeout Check Engine Speeds Battery Check Ammeter Out of Calibration Range Engine Stopped - Reason Unknown Pretrip Reminder Low Engine Oil Level Hourmeters Exceed 99999 Hourmeter 4 Exceeds set limit Hourmeter 5 Exceeds set limit Hourmeter 6 Exceeds set limit Microprocessor Reverted to Default Settings Internal Fault Code, Dealer Resettable Internal Fault Code, Dealer Resettable Internal Fault Code, Dealer Resettable Internal Fault Code, Dealer Resettable Data Log Overflow
ADDITIONAL INFORMATION
For additional information consult the following Thermo King manuals for your unit. Operating Manual Maintenance Manual Parts Manual Diagnosis Manual