Académique Documents
Professionnel Documents
Culture Documents
2—2003
IEC 60068-3-2:1976
AS 60068.3.2
Australian Standard™
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
Environmental testing
Australian Standard™
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
Environmental testing
Originated as AS 1099.3.2—1980.
Revised and redesignated as AS 60068.3.2—2003.
COPYRIGHT
© Standards Australia International
All rights are reserved. No part of this work may be reproduced or copied in any form or by any
means, electronic or mechanical, including photocopying, without the written permission of the
publisher.
Published by Standards Australia International Ltd
GPO Box 5420, Sydney, NSW 2001, Australia
ISBN 0 7337 5150 4
ii
PREFACE
This Standard was prepared by the Standards Australia Committee EL-026, Protective
Enclosures and Environmental Testing for Electrical/Electronic Equipment to supersede
AS 1099.3.2:1980, Basic environmental testing procedures for electrotechnology, Part 3:
Background information, Section 2: Combined temperature/low air pressure tests.
The objective of this Standard is to provide the electrotechnology industry with a complete set
of environmental test procedures published as a series under AS 60068 Environmental testing.
This Standard is Part 3.2 of that series.
This Standard is identical with, and has been reproduced from, IEC 60068-3-2:1976,
Environmental testing – Part 3: Background information – Section Two – Combined
temperature/low air pressure tests.
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
CONTENTS
Page
1 General ............................................................................................................................1
2 Reasons behind the design of the test ..............................................................................1
3 Environmental effects .......................................................................................................2
4 Testing facilities ...............................................................................................................3
5 Measurements of environmental parameters ....................................................................3
5.1 Temperature measurements ....................................................................................3
5.2 Air pressure measurements .....................................................................................3
Figure 1 – Combined effects of air pressure and air velocity on specimen surface
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
temperature ......................................................................................................................4
This is a free preview. Purchase the entire publication at the link below: