Académique Documents
Professionnel Documents
Culture Documents
23—2005
ISO 128.23:1999
AS ISO 128.23—2005
Australian Standard™
This is a free 8 page sample. Access the full version at http://infostore.saiglobal.com.
Department of Defence
Department of Education, Training and Employment (South Australia)
Design Association of New Zealand
Institute for Drafting and Design Australia
Master Builders Australia
TAFE NSW
This is a free 8 page sample. Access the full version at http://infostore.saiglobal.com.
University of Melbourne
Australian Standard™
This is a free 8 page sample. Access the full version at http://infostore.saiglobal.com.
COPYRIGHT
© Standards Australia
All rights are reserved. No part of this work may be reproduced or copied in any form or by
any means, electronic or mechanical, including photocopying, without the written
permission of the publisher.
Published by Standards Australia GPO Box 5420, Sydney, NSW 2001, Australia
ISBN 0 7337 6622 6
ii
PREFACE
This Standard was prepared by the Standards Australia Committee ME-072, Technical Drawings.
This Standard is identical with and reproduced from ISO 128-23:1999, Technical drawings—General
principles of presentation, Part 23: Lines on construction drawings.
This Standard is Part 23 of the AS ISO 128 series, Technical drawings—General principles of
presentation, as follows:
AS ISO
128 Technical drawings—General principles of presentation
128.1 Part 1: Introduction and index
128.20 Part 20: Basic conventions for lines
128.21 Part 21: Preparation of lines by CAD systems
128.22 Part 22: Basic conventions and applications for leader lines and reference lines
This is a free 8 page sample. Access the full version at http://infostore.saiglobal.com.
CONTENTS
Page
Contents
1 Scope ........................................................................................................................................................................ 1
3 General principles.................................................................................................................................................... 2
© ISO 1999
All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means, electronic
or mechanical, including photocopying and microfilm, without permission in writing from the publisher.
International Organization for Standardization
Case postale 56 • CH-1211 Genève 20 • Switzerland
Internet iso@iso.ch
Printed in Switzerland
ii
ISO 128-23:1999(E) v © ISO
INTRODUCTION
Introduction
The basic conventions and the application of lines in respect to other fields of drawing practice are presented in
other parts of ISO 128 since requirements in industry vary considerably. For further information, see ISO 128-20.
This is a free 8 page sample. Access the full version at http://infostore.saiglobal.com.
iv
This is a free 8 page sample. Access the full version at http://infostore.saiglobal.com.
vi
NOTES
This is a free preview. Purchase the entire publication at the link below: