Académique Documents
Professionnel Documents
Culture Documents
ISO/IEC 17030:2003
AS ISO/IEC 17030
Australian Standard™
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
Conformity assessment—General
requirements for third-party marks of
conformity
This Australian Standard was prepared by Committee QR-010, Conformity
Assessment. It was approved on behalf of the Council of Standards Australia on
23 April 2004 and published on 25 May 2004.
Australian Standard™
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
Conformity assessment—General
requirements for third-party marks of
conformity
COPYRIGHT
© Standards Australia International
All rights are reserved. No part of this work may be reproduced or copied in any form or by any
means, electronic or mechanical, including photocopying, without the written permission of the
publisher.
Published by Standards Australia International Ltd
GPO Box 5420, Sydney, NSW 2001, Australia
ISBN 0 7337 6006 6
ii
PREFACE
This Standard was prepared by the Australian members of the Joint Standards Australia/Standards
New Zealand Committee QR-010, Conformity Assessment. After consultation with stakeholders in
both countries, Standards Australia and Standards New Zealand decided to develop this Standard as
an Australian Standard rather than an Australian/New Zealand Standard.
This Standard is identical with, and has been reproduced from, ISO/IEC 17030:2003, Conformity
assessment — General requirements for third-party marks of conformity.
The objective of this Standard is to provide general requirements for third party marks of conformity,
including their issue and use.
As this Standard is reproduced from an international standard, the following applies:
(a) Its number appears on the cover and title page while the international standard number appears
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
* ISO/IEC Guide 2 is published in Australia as HB 18.2. ISO/IEC Guide 2 is currently in revision within ISO TC CASCO.
When the revision is completed, it is intended to be published as a Standard: ISO/IEC 17000. Until ISO/IEC 17000 is
published, HB 18.2 should be referenced.
iii
CONTENTS
Page
INTRODUCTION ....................................................................................................................iv
1 Scope ....................................................................................................................... 1
2 Normative references................................................................................................ 1
3 Terms and definitions ............................................................................................... 1
4 General requirements ............................................................................................... 2
5 Design and application of third-party marks of conformity ......................................... 2
6 Issuing third-party marks of conformity ..................................................................... 3
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.