Académique Documents
Professionnel Documents
Culture Documents
8:1994
Part 8: Determination of
manganese content—
Spectrophotometric method
AS/NZS 1050.8:1994
Analytical laboratories
Department of Defence, Materials Research Laboratory
Steel manufacturers
Part 8: Determination of
manganese content—
Spectrophotometric method
STANDARDS AUSTRALIA
1 The Crescent,
Homebush NSW 2140 Australia
PREFACE
This Standard was prepared by the Joint Standards Australia/Standards New Zealand
Committee CH/10 on the Analysis of Metals to supersede AS 1050.8 — 1980: Methods for
the analysis of iron and steel, Part 8: Determination of manganese content in iron and
steel (spectrophotometric method).
It is issued as a Joint Standard under the terms of the Active Cooperation Agreement
between Standards Australia and Standards New Zealand.
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
CONTENTS
Page
1 SCOPE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
2 REFERENCED DOCUMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
3 PRINCIPLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
4 REAGENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
5 APPARATUS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
6 SAMPLING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
7 PROCEDURE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
8 CALCULATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
9 PRECISION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
10 ACCEPTANCE OF ANALYTICAL VALUES . . . . . . . . . . . . . . . . . . . . . . . . . 8
11 TEST REPORT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
1 SCOPE This Joint Standard sets out a spectrophotometric method, using the
permanganate ion formed by oxidation, for the determination of the manganese content of
iron and steel. The method covers the range 0.01% to 2% manganese and is applicable to
all grades of iron and steel.
This is a free 5 page sample. Access the full version at http://infostore.saiglobal.com.
4 REAGENTS
4.1 General requirements During the analysis, only reagents of analytical reagent
grade and only distilled water or water of an equivalent purity shall be used. All solutions
shall be freshly prepared.
NOTE: If demineralized water is used, acidify the water with 10 mL of sulfuric acid
(ρ 20 1.84 g/mL) per litre of water. Bring the water to boiling, add several crystals of sodium
periodate and boil for 10 min.
4.2 Solids
4.2.1 Iron sponge or iron chips Containing >99.99% iron and <0.002% manganese.
4.2.2 Potassium permanganate
4.3 Solutions
4.3.1 Nitric acid (ρ 20 1.42 g/mL)
COPYRIGHT
This is a free preview. Purchase the entire publication at the link below: