Académique Documents
Professionnel Documents
Culture Documents
2:1994
ISO/IEC 8880-2:1992
Information technology—
Telecommunications and
information exchange between
systems—Protocol combinations
to provide and support the OSI
network service
Information technology—
Telecommunications and
information exchange between
systems—Protocol combinations
to provide and support the OSI
network service
STANDARDS AUSTRALIA
1 The Crescent,
Homebush NSW 2140 Australia
PREFACE
This Standard was prepared by the Joint Standards Australia/Standards New Zealand Committee IT/1 on
Information Syst ems — Interconnect ion to supersede AS/ NZS 4107:1993, Information
technology — Telecommunications and information exchange between systems — Protocol combinations to
provide and support the OSI network service, Part 2: Provision and support of the connection-mode
network service.
It is identical with and has been reproduced from ISO/IEC 8880-2: 1992, Information technology —
Telecommunications and information exchange between systems — Protocol combinations to provide and
support the OSI Network Service, Part 2: Provision and support of the connection-mode Network Service.
This Standard is issued as a Joint Standard under the terms of the Active Cooperation Agreement between
Standards Australia and Standards New Zealand.
The objective of this Standard is to provide OSI network designers with a description of the
connection-mode network service including the field of application.
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
This Standard is one of a series of Open Systems Interconnection (OSI) Standards which are currently
under development. Since OSI Standards are developmental, there may be some minor difficulties
encountered in their implementation. For this reason, Standards Australia will be providing, through the
OSI Help Desk, a service to coordinate and disseminate information concerning difficulties which are
identified in using this Standard.
Users of this Standard are advised by Standards Australia and Standards New Zealand, under arrangements
made with ISO and IEC, as well as certain other Standards organizations, that the number of this Standard
is not reproduced on each page; its identity is shown only on the cover and title pages.
For the purpose of this Standard, the source text should be modified as follows:
(a) Terminology The words ‘this Australian/New Zealand Standard’ should replace the words ‘this
International Standard’ wherever they appear.
(b) Decimal marker Substitute a full point for a comma where it appears as a decimal marker.
(c) References The references to international Standards should be replaced by references, where
appropriate, to the following Australian or Joint Australian/New Zealand Standards:
ISO AS
498 Information processing systems — Open 2777 Information processing systems — Open
S yst em s Int er connect i on — B as i c S yst em s Int e rconnect i on — B a si c
reference model reference model
7498/Add.1 Addendum 1: Connectionless-mode 2777 Supplement 1: Connectionless-mode
transmission transmission
7776 Information processing systems — Data 3512 Information processing systems — Data
Communications — High-level data-link communication — High-level data link
control procedures — Description of the control procedures — Description of the
X.25 LAPB-compatible DTE data-link X.25 LAPB-compatible DTE data link
procedures procedures
8648 Information processing systems — Open 3622 Information processing systems — Open
Systems Interconnection — Internal Systems Interconnecti on — Internal
organization of the Network layer organization of the network layer
iii
ISO AS
8802 Information processing systems — Data 4802 Information processing systems — Local
communication — Local Area networks area networks
ISO/IEC AS/NZS
7809 In f or m at i o n t e c hn o l o gy — T el e- 2751 In f or m at i o n t ec hn o l o g y — T el e -
communicat ions and informat ion communicat ions and information
exchange between systems — High-level exchange between systems — High-level
data-link control (HDLC) procedures — data link control procedures — Classes
Classes of procedures of procedures
8881 Information processing systems — Data 4166 Information processing systems — Data
communications — Use of the X.35 communications — Use of the X.25
packet level protocol in Local Area packet level protocol in local area
Networks networks
ISO/IEC AS/NZS
10732 Information technology — Use of X.25 —
Packet Layer Protocol to provide the
OSI connection-mode network service
over the telephone network
ITU-T Recommendation
X.21 Interface between Data Terminal —
Equipment (DTE) and Data Circuit
Terminating Equipment (DCE) for
Operation on Public Data Networks
Part 2:
Provision and support of the connection-mode network
service
Section 1: General
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
The following standards contain provisions which, through reference in 1.2.3 Additional references
this text, constitute provisions of this part of ISO/IEC 8880. At the time
of publication, the editions indicated were valid. All standards are ISO 7498/Add.1:1987, Information processing systems— Open Systems
subject to revision, and parties to agreements based on this part of Interconnection — Basic reference model — Addendum 1:
ISO/IEC 8880 are encouraged to investigate the possibility of applying Connectionless-mode transmission.
the most recent editions of the standards listed below. Members of IEC
and ISO maintain registers of currently valid International Standards. ISO 7776:1986, Information processing systems— Data communi-
cations — High-level data-link control procedures— Description of the
1.2.1 Identical Recommendations X.25 LAPB-compatible DTE data-link procedures.
International Standards
ISO/IEC 7809: 1991, Information technology— Telecommunications
CCITT Recommendation X.213(1992) ISO/IEC 8348:-1) , Information and information exchange between systems— High-level data-link
technology— Network service definition for Open Systems control (HDLC) procedures— Classes of procedures.
Interconnection.
ISO/IEC 8208:1990, Information technology— Data communications
CCITT Recommendation X.612(1992) ISO/IEC 9574:1992, — X.25 Packet Layer Protocol for Data Terminal Equipment.
Information technology— Provision of the OSI connection-mode
network service by packet mode terminal equipment connected to an ISO 8648:1988, Information processing systems— Open Systems
integrated services digital network (ISDN). Interconnection— Internal organization of the Network layer.
CCITT Recommendation X.613(1992) ISO/IEC 10588:- 1), ISO 8802: 1989, Information processing systems— Data commun-
Information technology— Use of X.25 Packet Layer Protocol in ication — Local Area Networks.
conjunction with X.21/X.21 bis to provide the OSI connection-mode
network service. ISO/IEC 8880-1:1990, Information technology— Telecommunications
and information exchange between systems— Protocol combinations to
CCITT Recommendation X.614(1992) ISO/IEC 10732:- 1), provide and support the OSI Network Service— Part 1. General
Information technology— Use of X.25 Packet Layer Protocol to provide principles.
the OSI connection-mode network service over the telephone network.
ISO/IEC 8881: 1989, Information processing systems— Data com-
1.2.2 Paired Recommendations International munications— Use of the X.25 packet level protocol in Local Area
Standards equivalent in technical content Networks.
CCITT Recommendation X.200 (1988), Reference model of Open CCITT Recommendation X.21, Interface between Data Terminal
Systems Interconnection for CCITT applications. Equipment (DTE) and Data Circuit Terminating Equipment (DCE) for
Operation on Public Data Networks.
1) To be published.
COPYRIGHT
This is a free preview. Purchase the entire publication at the link below: