Académique Documents
Professionnel Documents
Culture Documents
com
www.jwjobs.net
Code No: 55009 Set No. 1 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD III B.Tech. I Sem., I Mid-Term Examinations, September 2011 IC APPLICATIONS Objective Exam Name: ______________________________ Hall Ticket No. A I 1. Choose the correct alternative: Choose the limitation of an integrated circuit A) Less weight B) Less heat dissipation
Answer All Questions. All Questions Carry Equal Marks.Time: 20 Min. Marks: 10.
C) Less cost
2.
The output of an analog IC is a ____________ of input signal [ ] A) Linear function B) Exponential function C) Non-linear function D) Trigonometric function The Common mode output of a differential amplifier with a differential mode gain of 400 and CMRR of 80dB and a common mode input of 4sin 200 t V is [ A) 0.5sin 200 t B) 1.2sin 200 t C) 0.16sin 200 t D) 0.2sin 200 t
3.
4.
The time taken for the op-amp output voltage to go from -10V to +10V with a slew rate of 0.5v/s is [ ] A)20s B)30s C) 40s D)24s The output of an inverting amplifier with respect to input is A) 1800 out of phase B) 1800 in-phase C) 1800 out of phase Determine the output voltage when V1 = V2 = 1 V.
5.
6.
J
A)0 V 7. 8.
T N
W U
C) 1 V
R O
D L
0
[ D) 180 in-phase [
B) 2 V
D) 2 V
The overall voltage gain of an inverting amplifier, if R1 = 100 and Rf = 1 k A) 1 B) 10 C) 11 D) 9 What does the discharge transistor do in the 555 timer circuit? A) charge the external capacitor to stop the timing B) charge the external capacitor to start the timing over again C) discharge the external capacitor to stop the timing D) discharge the external capacitor to start the timing over again
Cont..2
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
:2:
Set No. 1 [ ]
The Control voltage in a VCO is also called A)Difference input voltage B) Operating input voltage C) Modulating input voltage D) Capacitor input voltage A band-pass response has A) Two critical frequencies C) A flat curve in the pass band Fill in the blanks
10.
II 11.
The difference between the two input bias currents when the output voltage is zero is called __________ The output of a cascaded differential amplifier is ____________
In the absence of input voltage or at zero frequency (d.c),op-amp gain is _____________ Determine the output voltage for this circuit with a sinusoidal input of 2.5 mV.
In voltage-to-current converter the output load current is ________________ In an integrator circuit if input is step, output is ________________ The frequency of Wien bridge oscillator is decided by _____________ A first-order low-pass Butterworth filter is realized by a RC network and _____________ A monostable 555 timer has the ______________ number of stable states Three configurations for switching regulators are ______________ -oOo-
T N
W U
R O
D L
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 55009 Set No. 2 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD III B.Tech. I Sem., I Mid-Term Examinations, September 2011 IC APPLICATIONS Objective Exam Name: ______________________________ Hall Ticket No. A I 1. Choose the correct alternative:
Answer All Questions. All Questions Carry Equal Marks.Time: 20 Min. Marks: 10.
The time taken for the op-amp output voltage to go from -10V to +10V with a slew rate of 0.5v/s is [ ] A)20s B)30s C) 40s D)24s The output of an inverting amplifier with respect to input is A) 1800 out of phase B) 1800 in-phase C) 1800 out of phase Determine the output voltage when V1 = V2 = 1 V. [ D) 180 in-phase
0
2.
3.
A)0 V
B) 2 V
4.
The overall voltage gain of an inverting amplifier, if R1 = 100 and Rf = 1 k A) 1 B) 10 C) 11 D) 9 What does the discharge transistor do in the 555 timer circuit? A) charge the external capacitor to stop the timing B) charge the external capacitor to start the timing over again C) discharge the external capacitor to stop the timing D) discharge the external capacitor to start the timing over again The Control voltage in a VCO is also called A)Difference input voltage B) Operating input voltage C) Modulating input voltage D) Capacitor input voltage A band-pass response has A) Two critical frequencies C) A flat curve in the pass band
5.
T N
W U
C) 1 V
R O
D L
D) 2 V
6.
7.
www.jntuworld.com
8.
Choose the limitation of an integrated circuit A) Less weight B) Less heat dissipation
C) Less cost
9.
The output of an analog IC is a ____________ of input signal [ ] A) Linear function B) Exponential function C) Non-linear function D) Trigonometric function The Common mode output of a differential amplifier with a differential mode gain of 400 and [ CMRR of 80dB and a common mode input of 4sin 200 t V is A) 0.5sin 200 t B) 1.2sin 200 t C) 0.16sin 200 t D) 0.2sin 200 t Fill in the blanks Determine the output voltage for this circuit with a sinusoidal input of 2.5 mV.
10.
II 11.
In voltage-to-current converter the output load current is ________________ In an integrator circuit if input is step, output is ________________ The frequency of Wien bridge oscillator is decided by _____________ A first-order low-pass Butterworth filter is realized by a RC network and _____________ A monostable 555 timer has the ______________ number of stable states Three configurations for switching regulators are ______________ The difference between the two input bias currents when the output voltage is zero is called __________ The output of a cascaded differential amplifier is ____________ In the absence of input voltage or at zero frequency (d.c),op-amp gain is _____________ -oOo-
T N
W U
R O
D L
19. 20.
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 55009 Set No. 3 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD III B.Tech. I Sem., I Mid-Term Examinations, September 2011 IC APPLICATIONS Objective Exam Name: ______________________________ Hall Ticket No. A I 1. Choose the correct alternative: Determine the output voltage when V1 = V2 = 1 V. [
Answer All Questions. All Questions Carry Equal Marks.Time: 20 Min. Marks: 10.
A)0 V
B) 2 V
C) 1 V
D) 2 V
2.
The overall voltage gain of an inverting amplifier, if R1 = 100 and Rf = 1 k A) 1 B) 10 C) 11 D) 9 What does the discharge transistor do in the 555 timer circuit? A) charge the external capacitor to stop the timing B) charge the external capacitor to start the timing over again C) discharge the external capacitor to stop the timing D) discharge the external capacitor to start the timing over again The Control voltage in a VCO is also called A)Difference input voltage B) Operating input voltage C) Modulating input voltage D) Capacitor input voltage A band-pass response has A) Two critical frequencies C) A flat curve in the pass band
3.
4.
T N
W U
R O
D L
[ ] [ ] [ ]
5.
6.
Choose the limitation of an integrated circuit A) Less weight B) Less heat dissipation
C) Less cost
7.
The output of an analog IC is a ____________ of input signal [ ] A) Linear function B) Exponential function C) Non-linear function D) Trigonometric function Cont..2
www.jntuworld.com
8.
The Common mode output of a differential amplifier with a differential mode gain of 400 and [ CMRR of 80dB and a common mode input of 4sin 200 t V is A) 0.5sin 200 t B) 1.2sin 200 t C) 0.16sin 200 t D) 0.2sin 200 t
9.
The time taken for the op-amp output voltage to go from -10V to +10V with a slew rate of 0.5v/s is [ ] A)20s B)30s C) 40s D)24s The output of an inverting amplifier with respect to input is A) 1800 out of phase B) 1800 in-phase C) 1800 out of phase Fill in the blanks In an integrator circuit if input is step, output is ________________ [ D) 180 in-phase
0
10.
A first-order low-pass Butterworth filter is realized by a RC network and _____________ A monostable 555 timer has the ______________ number of stable states Three configurations for switching regulators are ______________
The difference between the two input bias currents when the output voltage is zero is called __________ The output of a cascaded differential amplifier is ____________ In the absence of input voltage or at zero frequency (d.c),op-amp gain is _____________ Determine the output voltage for this circuit with a sinusoidal input of 2.5 mV.
T N
W U
R O
D L
V0= _______________ 20. In voltage-to-current converter the output load current is ________________
-oOo-
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 55009 Set No. 4 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD III B.Tech. I Sem., I Mid-Term Examinations, September 2011 IC APPLICATIONS Objective Exam Name: ______________________________ Hall Ticket No. A I 1. Choose the correct alternative: What does the discharge transistor do in the 555 timer circuit? A) charge the external capacitor to stop the timing B) charge the external capacitor to start the timing over again C) discharge the external capacitor to stop the timing D) discharge the external capacitor to start the timing over again The Control voltage in a VCO is also called A)Difference input voltage B) Operating input voltage C) Modulating input voltage D) Capacitor input voltage A band-pass response has A) Two critical frequencies C) A flat curve in the pass band [
Answer All Questions. All Questions Carry Equal Marks.Time: 20 Min. Marks: 10.
2.
3.
4.
Choose the limitation of an integrated circuit A) Less weight B) Less heat dissipation
5.
The output of an analog IC is a ____________ of input signal [ ] A) Linear function B) Exponential function C) Non-linear function D) Trigonometric function The Common mode output of a differential amplifier with a differential mode gain of 400 and CMRR of 80dB and a common mode input of 4sin 200 t V is [ A) 0.5sin 200 t B) 1.2sin 200 t C) 0.16sin 200 t D) 0.2sin 200 t
6.
7.
The time taken for the op-amp output voltage to go from -10V to +10V with a slew rate of 0.5v/s is [ ] A)20s B)30s C) 40s D)24s The output of an inverting amplifier with respect to input is C) 1800 out of phase A) 1800 out of phase B) 1800 in-phase Determine the output voltage when V1 = V2 = 1 V. [ D) 180 in-phase
0
T N
W U
R O
C) Less cost
D L
8.
9.
A)0 V
B) 2 V
C) 1 V
D) 2 V Cont..2
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
:2:
Set No. 4
10.
The overall voltage gain of an inverting amplifier, if R1 = 100 and Rf = 1 k A) 1 B) 10 C) 11 D) 9 Fill in the blanks A first-order low-pass Butterworth filter is realized by a RC network and _____________ A monostable 555 timer has the ______________ number of stable states Three configurations for switching regulators are ______________
The difference between the two input bias currents when the output voltage is zero is called __________ The output of a cascaded differential amplifier is ____________
In the absence of input voltage or at zero frequency (d.c),op-amp gain is _____________ Determine the output voltage for this circuit with a sinusoidal input of 2.5 mV.
In voltage-to-current converter the output load current is ________________ In an integrator circuit if input is step, output is ________________ The frequency of Wien bridge oscillator is decided by _____________
T N
W U
-oOo-
R O
D L
www.jntuworld.com