Académique Documents
Professionnel Documents
Culture Documents
com
www.jwjobs.net
Code No: 53002 Set No. 1 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD II B.Tech. I Sem., I Mid-Term Examinations, September 2011 BASIC ELECTRICAL AND ELECTRONICS ENGINEERING Objective Exam Name: ______________________________ Hall Ticket No. A Answer All Questions. All Questions Carry Equal Marks. Time: 20 Min. Marks: 10. I 1. Choose the correct alternative: The unit of quantity of electricity is (A) Ampere (B) Coloumb (C) Ohm [ (D) Electron Volt [ ] ]
2.
The Mechanical energy source used to deive a dc generator is called a (A) Rotor (B)Prime Mover (C) Alternator (D) Motor drive A DC Generator working is based on the principle of (A) Ohms Law (B)Statically induced emf (C)Dynamically induced emf (D) Mutual induction The Principle of operation of a Transformer is (A) Electromagnetic Induction (C) Varying a conductor in a magnetic field
3.
4.
5.
The Regulation of an Alternator is positive when the power factor is (A) Zero (B) Leading (C) Unity (D) Lagging
6.
Three resistors each of R ohms are connected in delta. Their equivalent star value for each resistance is [ ] R (A) R (B) 3R (C) (D) 2R 3 Conductance is the reciprocal of (A) Reactance (B) Impedance
7.
8.
The flux involved in the emf equation of a transformer has (A) RMS value (B) Average value (C) Total value
T N
W U
R O
D L
(C) Resistance
[ (D) capacitance
9.
In a single phase transformer, with subscripts 1 and 2 for primary and secondary windings[ (B) E1N1= E2N2 and I1N1= I2N2 (A) E1N2= E2N1 and I1N1= I2N2 (C) E1N2= E2N1 and I1N2= I2N1 (D) E1N1= E2N2 and I1N2= I2N1 (C) Both A&B [ (D) None of the above Cont.2
10.
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 53002 II 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. Fill in the blanks:
:2:
Set No. 1
Two inductors of 2H, 4H are connected in parallel. Then the total inductance is _____ The examples for passive elements are ___________________ The purpose of starter for DC Motor is _______________________ The efficiency of a Transformer is maximum when _________________ The Regulation of a Transformer is zero, when the Power factor is _______ The Synchronous impedance method is used to determine the __________________ The electric current is defined as ________________________________________. Emf equation of a DC generator is ____________________________________. The synchronous speed of 50 Hz, 4 pole induction motor is _____________________. The other name for synchronous generator is _________________________.
-oOo-
T N
W U
R O
D L
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 53002 Set No. 2 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD II B.Tech. I Sem., I Mid-Term Examinations, September 2011 BASIC ELECTRICAL AND ELECTRONICS ENGINEERING Objective Exam Name: ______________________________ Hall Ticket No. A Answer All Questions. All Questions Carry Equal Marks. Time: 20 Min. Marks: 10. I 1. Choose the correct alternative: The Principle of operation of a Transformer is (A) Electromagnetic Induction (C) Varying a conductor in a magnetic field [ (B)Mutual Induction (D) Electrostatic induction [ ] ]
2.
The Regulation of an Alternator is positive when the power factor is (A) Zero (B) Leading (C) Unity (D) Lagging
3.
Three resistors each of R ohms are connected in delta. Their equivalent star value for each resistance is [ ] R (A) R (B) 3R (C) (D) 2R 3 Conductance is the reciprocal of (A) Reactance (B) Impedance (C) Resistance
4.
5.
The flux involved in the emf equation of a transformer has (A) RMS value (B) Average value (C) Total value
6.
In a single phase transformer, with subscripts 1 and 2 for primary and secondary windings[ (A) E1N2= E2N1 and I1N1= I2N2 (B) E1N1= E2N2 and I1N1= I2N2 (C) E1N2= E2N1 and I1N2= I2N1
7.
T N
W U
R O
D L
[ (D) capacitance
(D) E1N1= E2N2 and I1N2= I2N1 (C) Both A&B [ (D) None of the above [ (D) Electron Volt [ ] ]
8.
The unit of quantity of electricity is (A) Ampere (B) Coloumb (C) Ohm
9.
The Mechanical energy source used to deive a dc generator is called a (A) Rotor (B)Prime Mover (C) Alternator (D) Motor drive A DC Generator working is based on the principle of (A) Ohms Law (B)Statically induced emf (C)Dynamically induced emf (D) Mutual induction
10.
Cont.2
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 53002 II 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. Fill in the blanks:
:2:
Set No. 2
The efficiency of a Transformer is maximum when _________________ The Regulation of a Transformer is zero, when the Power factor is _______ The Synchronous impedance method is used to determine the __________________ The electric current is defined as ________________________________________. Emf equation of a DC generator is ____________________________________. The synchronous speed of 50 Hz, 4 pole induction motor is _____________________. The other name for synchronous generator is _________________________. Two inductors of 2H, 4H are connected in parallel. Then the total inductance is _____ The examples for passive elements are ___________________ The purpose of starter for DC Motor is _______________________
-oOo-
T N
W U
R O
D L
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 53002 Set No. 3 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD II B.Tech. I Sem., I Mid-Term Examinations, September 2011 BASIC ELECTRICAL AND ELECTRONICS ENGINEERING Objective Exam Name: ______________________________ Hall Ticket No. A Answer All Questions. All Questions Carry Equal Marks. Time: 20 Min. Marks: 10. I 1. Choose the correct alternative: Three resistors each of R ohms are connected in delta. Their equivalent star value for each resistance is [ ] R (A) R (B) 3R (C) (D) 2R 3 Conductance is the reciprocal of (A) Reactance (B) Impedance (C) Resistance
2.
3.
The flux involved in the emf equation of a transformer has (A) RMS value (B) Average value (C) Total value
4.
In a single phase transformer, with subscripts 1 and 2 for primary and secondary windings[ (A) E1N2= E2N1 and I1N1= I2N2 (B) E1N1= E2N2 and I1N1= I2N2 (C) E1N2= E2N1 and I1N2= I2N1
5.
6.
The unit of quantity of electricity is (A) Ampere (B) Coloumb (C) Ohm
7.
The Mechanical energy source used to deive a dc generator is called a (A) Rotor (B)Prime Mover (C) Alternator (D) Motor drive A DC Generator working is based on the principle of (A) Ohms Law (B)Statically induced emf (C)Dynamically induced emf (D) Mutual induction The Principle of operation of a Transformer is (A) Electromagnetic Induction (C) Varying a conductor in a magnetic field
8.
T N
W U
(D) E1N1= E2N2 and I1N2= I2N1 (C) Both A&B [ (D) None of the above [ (D) Electron Volt [ ] ]
R O
D L
[ (D) capacitance
9.
10.
The Regulation of an Alternator is positive when the power factor is (A) Zero (B) Leading (C) Unity (D) Lagging
Cont.2
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 53002 II 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. Fill in the blanks:
:2:
Set No. 3
The Synchronous impedance method is used to determine the __________________ The electric current is defined as ________________________________________. Emf equation of a DC generator is ____________________________________. The synchronous speed of 50 Hz, 4 pole induction motor is _____________________. The other name for synchronous generator is _________________________. Two inductors of 2H, 4H are connected in parallel. Then the total inductance is _____ The examples for passive elements are ___________________ The purpose of starter for DC Motor is _______________________ The efficiency of a Transformer is maximum when _________________
-oOo-
T N
W U
R O
D L
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 53002 Set No. 4 JAWAHARLAL NEHRU TECHNOLOGICAL UNIVERSITY HYDERABAD II B.Tech. I Sem., I Mid-Term Examinations, September 2011 BASIC ELECTRICAL AND ELECTRONICS ENGINEERING Objective Exam Name: ______________________________ Hall Ticket No. A Answer All Questions. All Questions Carry Equal Marks. Time: 20 Min. Marks: 10. I 1. Choose the correct alternative: The flux involved in the emf equation of a transformer has (A) RMS value (B) Average value (C) Total value [ ] (D) Max. value ]
2.
In a single phase transformer, with subscripts 1 and 2 for primary and secondary windings[ (A) E1N2= E2N1 and I1N1= I2N2 (B) E1N1= E2N2 and I1N1= I2N2 (C) E1N2= E2N1 and I1N2= I2N1 (D) E1N1= E2N2 and I1N2= I2N1 (C) Both A&B
3.
4.
The unit of quantity of electricity is (A) Ampere (B) Coloumb (C) Ohm
5.
The Mechanical energy source used to deive a dc generator is called a (A) Rotor (B)Prime Mover (C) Alternator (D) Motor drive A DC Generator working is based on the principle of (A) Ohms Law (B)Statically induced emf (C)Dynamically induced emf (D) Mutual induction The Principle of operation of a Transformer is (A) Electromagnetic Induction (C) Varying a conductor in a magnetic field
6.
7.
8.
The Regulation of an Alternator is positive when the power factor is (A) Zero (B) Leading (C) Unity (D) Lagging
T N
W U
R O
D L
9.
Three resistors each of R ohms are connected in delta. Their equivalent star value for each resistance is [ ] R (A) R (B) 3R (C) (D) 2R 3 Conductance is the reciprocal of (A) Reactance (B) Impedance (C) Resistance [ (D) capacitance Cont.2 ]
10.
www.jntuworld.com
www.jntuworld.com
www.jwjobs.net
Code No: 53002 II 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. Fill in the blanks:
:2:
Set No. 4
Emf equation of a DC generator is ____________________________________. The synchronous speed of 50 Hz, 4 pole induction motor is _____________________. The other name for synchronous generator is _________________________. Two inductors of 2H, 4H are connected in parallel. Then the total inductance is _____ The examples for passive elements are ___________________ The purpose of starter for DC Motor is _______________________ The efficiency of a Transformer is maximum when _________________ The Regulation of a Transformer is zero, when the Power factor is _______ The Synchronous impedance method is used to determine the __________________ The electric current is defined as ________________________________________.
-oOo-
T N
W U
R O
D L
www.jntuworld.com