Académique Documents
Professionnel Documents
Culture Documents
Symbol
RDRN RDRNS ROVE ISOT ADNW SKPF NPRV FML10
Description
For the rapid traverse command, a dry run is disabled/enabled. The rapid traverse override signal ROV2 (G117, #7) is enabled/disabled. When a reference position is not established, manual rapid traverse is disabled/enabled. Feedrate specification A/B With G31, a dry run, override, or automatic acceleration/deceleration is disabled/enabled. When a position coder is not used, the command of feed per rotation is disabled/enabled. The unit of parameters in which the rapid traverse rate and cutting feedrate are specified is not multiplied/is multiplied by ten. Of the commands specifying feed in the positive direction on each axis, external deceleration is valid for rapid traverse only/for both rapid traverse and cutting feed. Of the commands specifying feed in the negative direction on each axis, external deceleration is valid for rapid traverse only/for both rapid traverse and cutting feed. The function for changing the speed of outer arc machining is disable/enabled. In helical interpolation, the feedrate is not clamped/is clamped to the maximum cutting feedrate. If the cutting feedrate override is 0% in rapid traverse, a stop does not occur/occurs. The signal of feedrate override in 1% steps is disable/enabled. Minimum deceleration ratio for the speed of inner arc machining by automatic corner override (MDR) Amount of automatic override for the inside of a corner Inside angle for determining whether to use automatic override for the inside of a corner Feedrate change corresponding to a graduation on the manual pulse generator when the F command is specified with one digit Feedrate after acceleration/deceleration for automatic corner deceleration Difference between feedrates of two blocks, for each axis, for automatic corner deceleration Feedrate after acceleration/deceleration for automatic corner deceleration (for lookahead control) Maximum feedrate with standard arc radius Minimum feedrate with standard arc radius (X to 4) Rapid traverse feedrate for each axis (7, 8) (5, 6) Maximum cutting feedrate
0059#0 to #2
EDP:
0059#3 to #5
EDM:
0393#1 0393#4
COVOUT HLCLMP
STOV0 OVR255
10
186
9. PARAMETERS
(6) Parameters related to the feedrate (2/2) No.
0530 7530 0533 7533 0534 7534 0548 0549 0559 to 0562 0565, 0566 0567 0568 0569 0538, 0584 0580 0581 0605 to 0608 0636 0684 0788 to 0796 0878
For M series
Symbol
Description
(X to 4) FL speed in exponential acceleration/ deceleration of cutting feed (5, 6) (X to 4) F0 speed of rapid traverse override (5, 6) (X to 4) FL speed at a reference position return (5, 6) FL speed in exponential acceleration/deceleration of manual feed Cutting feedrate in the automatic mode at power on Jog rapid traverse rate for each axis Jog feedrate when the rotary switch is set to position 10 Maximum cutting feedrate with feedrate specification B F0 speed of rapid traverse override on an additional axis with feedrate specification B FL speed at a reference position return on an additional axis with feedrate specification B Maximum feedrate by the F command specified with one digit Start distance (Le) for inner corner automatic override End distance (Ls) for inner corner automatic override FL speed of exponential acceleration/deceleration for manual feed on each axis External deceleration speed Feedrate with which the error detect function assumes that deceleration is completed Feedrate corresponding to the F command specified with one digit FL speed for exponential acceleration/deceleration of cutting feed (for lookahead control)
187