Vous êtes sur la page 1sur 20

Basler Electric

Spreadsheet for Performing Complex Number, Sequence Component, and Other Basic Electric System Calculations
Disclaimer
This spreadsheet presents basic calculations associated with electrical power. In developing this software Basler Electric has attempted to develop accurate calculation methods, but Basler Electric
does not warrant that the software is free from bugs, errors, or other program limitations. Users are encouraged to consult with a Basler Electric representative to determine the accuracy of the data and
results for the specific use or purpose of the user.
By use of this program, the user agrees that Basler Electric disclaims all warranties of noninfringement of third party rights, quality, performance, merchantability, or fitness for a particular purpose. The
user assumes the entire risk as to the quality and performance of the software. In no event will Basler Electric be liable for any indirect, special, or consequential damages. In the event of any litigation
regarding this software, the user agrees that the venue shall be the State of Illinois.
Purpose of this Spreadsheet
This spreadsheet is intended to assist in the performance of various calculations associated with electric power flow. It is essentially a complex number and sequence components calculator and a
shortcut to do a few other basic calculations.
Instructions, Notes
=> See each sheet for instructions specific to that sheet.
=> This spreadsheet is best viewed at 1024x768 or higher resolution. To fit everything on one screen some sheets use <100% zoom. If one has a higher resolution monitor, one might raise the zoom
control to 100% for clearer viewing.
=> This sheet uses complex number functions from the Excel Analysis ToolPak. Enable the Analysis ToolPak feature from the Excel menu "Tools/Add-Ins." If the Analysis ToolPak is not
listed as an available Add-In, then likely only a partial installation of Excel has been done on your machine. The Analysis ToolPak is distributed with Excel, but it is an optional component
that might not be installed in a partial installation of Excel. See test below to verify the complex number functions are working correctly.
=> Though locking and protection is used in much of the the spreadsheet, there is no password protection. If one has obtained this spreadsheet from third party source, be aware of possible changes to
calculations that may have been done, and keep a backup copy of the original spreadsheet in case one inadvertently changes a calculation for the worse.
=> All macros re-enable protection; editing the macros is the only way to stop this.
=> Most calculations are done on the Intermediate Calcs sheet and macros are used to copy data to the various other sheets.
=> Send comments on this spreadsheet to "info@basler.com"
100+100i

If the Excel Analysis ToolPak is installed and working properly, the cell to the left should contain "100+100i." If it says "#NAME?" or any other message, see the instructions above.

Revision Notes:
Rev. 1.0; 10/14/02; Initial version, consisting of the following sheets: ComplexCalc, ABC012, Basic Faults, Other Calcs, Graphs, Intermediate Calcs.
Rev. 1.1; 09/03; ABC012 sheet: gave explanation of xfmr theory, added mag * & / 1.732 calc, revised a few default field views.
Rev. 2.0: 10/18/04; Added more per unit calcs on "Other Calcs" sheet. Added the blank "User's Calcs" sheet. Added "Z,ABC<>012" sheet. Renamed some sheets.
Rev. 3.0: 03/06; Added "Z=OHL" sheet using simplified Carson's equation from Wagner and Evans.
Basler Electric Company, P.O. Box 269, Highland, Illinois USA 62249
Phone: 618/654-2341 - Fax: 618/654-2351 - Website: http://www.basler.com

12/21/2012

121410345.xls.ms_office

Basic Complex Number Calculator


Quantity 1

Real

Imaginary

3.00000

4.00000

Rect<=>Polar

R<P

R>P

Magnitude

Degrees

5.00000

53.130

+/-, Conjugate, Clear


+/-

Co

Cle

Copy Data to:


Q

Cle

Memory 2

Cle

Memory 3

Cle

Memory 4

Cle

3.00000

4.00000

Memory 1

3.00000

4.00000

Q1+Q

Calculate:

Q1-Q2

Q1/Q2

Q1xQ2

Q1<=>Q
Cle

Quantity 2

5.00000

53.130

5.00000

53.130

Q1xQ2

Q1 ||

+/-

Q1^2

Co

Sqrt

1/Q1

Calculations use data in RECTANGULAR FORMAT. If Polar data is entered, click on the Polar to Rect. Conv. button before clicking on a Calculate button.

Calc Results:
Q1 / Q2

Real

Imaginary

Magnitude

Degrees

1.00000

0.00000

1.00000

0.000

Copy results to:


Cle

Instructions/Notes:
=> Click on red arrows to convert between rectangular and polar formats, and click on M1/2/3/4 and Q1/2 to copy data from field to field as indicated. Click on Q1<=>Q2 to
exchange Q1 and Q2 data.
=> After entering rectangular Q1 and Q2 data, click on the indicated function boxes to see the appropriate information in the "Calc Results" field.
=> Almost all calculations are done on the "Intermediate Calcs" sheet and macros involving calculations are simply copying data from the Intermediate Calcs page.

100+100i

If the Excel Analysis ToolPak is installed and working properly, the cell to the left should contain "100+100i." If it says "#NAME?" or any other
message, or you see "#VALUE!" messages on this sheet, see the Instructions Sheet for details on enabling Excel's Analysis ToolPak.

User Notes:

12/21/2012

121410345.xls.ms_office

Basic Sequence Components Calculator and Converter

A-N
B-N
C-N

Vl-n

A-B
B-C
C-A

Vl-l

A-B-C Phase Quantities


Real
Imaginary
Magnitude
Degrees
415.0000
425.0000
415.0000
425.0000
415.0000
425.0000
Convert
Convert

0.0000
Convert

0.0000

0.000
Convert

0.000

0
1
2

1
30

Wye-Gnd /
Wye-Gnd

Real
A-N
B-N
C-N
A-B
B-C
C-A
A
B
C

Vl-l

M1

M2

+/-

Clear

0.0000

M1

M2

+/-

Clear

M1

M2

+/-

Clear

Clear

0.000

Convert

Convert
Vl-n

Vl-l

Mem1 = Vln x I* (using ABC-Rect. data)

Vl-n

Vl-l

Clear

Mem2 = I + Mem1 (using ABC-Rect.

Current Xfmr Effects on I


CT ratio (N:1):
1
for N:5 ratio, N=
5

(NOTE: VT Calcs Use ABC-Rect. Data)

Vl-n

0.0000

Convert

All Other Xfmr


Config.

Copy data to; Misc. functions:

Convert

0
1
2
0
1
2

Voltage Xfmr Effects on V and I


Pri./Sec. ph./ph. voltage ratio:
Pos.Seq. Phase shift; Pri.=>Sec.

Secondary
Quantities

0.0000

Convert

A
B
C
A
B
C

Mem 2

Convert

0
1
2
Convert

Mem 1

Degrees

0
1
2

Convert

A
B
C

0-1-2 Sequence Quantities


Imaginary
Magnitude

Real

Wye Sec.
no phase
shift

Delta A-B Sec.


I1,I2@+/-30deg
Io blocked

Delta A-C Sec.


I1,I2@-/+30deg
Io blocked

(CT Calcs Use ABC-Rect. Data)

A-B-C Phase Quantities


Imaginary
Magnitude

Degrees

Real

0-1-2 Sequence Quantites


Imaginary
Magnitude

Clear Secondary Data

Degrees

0
1
2
0
1
2
0
1
2

Copy to:
M1

M2

Vl-n

M1

M2

Vl-l

M1

M2

Instructions/Notes:
=> The spreadsheet implements the classical phase to sequence and sequence to phase calculations (see cell H4 and O4 comments), along with polar/rectangular conversion.
=> Green and yellow are user input fields. Yellow indicates a field used in the Transformer Effects calculations.
=> Vca and Vll-Vo are not user inputs because: a) two Vl-l quantities define the third. Vca was selected as defined by equation. b) Vl-l has no ground reference and hence no Vo.
=> Transformer effect calculations use ABC-Rectangular data in yellow fields.
=> See notes in cell D28 for an explanation of the Voltage Xfmr Effects calculations.
=> The spreadsheet accepts any voltage transformer phase shift, even one that is physically impossible. Use your good judgment when entering phase shifts.
=> The calculations Mem1 = V x I* (= S) and Mem2 = I + Mem1 (= Isum, for differential applications) use ABC-Rectangular format data.
=> CT secondary calculations for delta connections are for lines outside of the delta.
100+100i

If the Excel Analysis ToolPak is installed and working properly, the cell to the left should contain "100+100i." If it says "#NAME?" or any other message, or you see "#VALUE!" messages on this sheet, see the
Instructions Sheet for details on enabling Excel's Analysis ToolPak.

User Notes:

12/21/2012

121410345.xls.ms_office

Series Impedance of Medium Length Overhead Lines


Do you wish to enter data in miles and feet
(English); or kilometers and meters (SI-MKS)?
Presently Selected Unit System:

English
40

SI-MKS
English

35

60
1
100
0.11720
0.03730
0.00
29.00
0.11720
0.03730
-5.00
25.00
0.11720
0.03730
0.00
21.00
0.30000
0.02000
-2.50
35.00
0.30000
0.02000
-2.00
15.00

30

Height Above Ground

Units
Frequency for impedance calculations:
Hz
Total Line Length:
mile(s)
Ground Resistivity: Ohm-meters
Phase A
Resistance per unit length (Ra)
ohms/mile
Conductor Radius (Ds or GMR)
feet
X Dimension; = 0 for A phase
feet
Height above Ground (Y)
feet
Phase B
Resistance per unit length (Ra)
ohms/mile
Conductor Radius (Ds or GMR)
feet
Horizontal Distance from Ph A (X)
feet
Height above Ground (Y)
feet
Resistance per unit length (Ra)
Phase C
ohms/mile
Conductor Radius (Ds or GMR)
feet
Horizontal Distance from Ph A (X)
feet
Height above Ground (Y)
feet
Resistance per unit length (Ra)
Neutral 1
ohms/mile
Conductor Radius (Ds or GMR)
feet
Horizontal Distance from Ph A (X)
feet
Height above Ground (Y)
feet
Resistance
per
unit
length
(Ra)
Neutral 2
ohms/mile
Conductor Radius (Ds or GMR)
feet
Horizontal Distance from Ph A (X)
feet
Height above Ground (Y)
feet

25

20

15

10

Note 1: The equations use a simplified equation for the ground loop impedance that is a partial implementation of what is re
Carson's Equations then one should obtain a professionally written package that fully implements those equations.
Note 2: This sheet was first provided in Rev 3 of this spreadsheet. The results have not been deeply checked against a prof
Instructions/Notes:

=>This sheet calculates the series impedance of overhead lines using the processes described in the paper, "Zero Sequenc
=> The spreadsheet uses a simplifed equation for the ground loop reported by many texts. See the referenced paper for the
=> If any wire (phase or ground) does not exist, either enter a very high resistance or 0 resistance for that wire. The spreads
=> The X position of A phase relative to the ground plane is the X reference, so XA is fixed at 0. The X position of B, C, and
orientation. There is no requirement on the order of conductors; e.g., phase A could be the lowest, highest, the farthest to th
and is the reference against which the XB, XC, XN1, and XN2 coordinates are measured, and that Y is positive for all condu
=> This sheet does not calculate the effective diameter of bundled conductors. This is an easy calculation (see referenced p
=> The spreadsheet will not support more than 2 ground wires, nor does it calculate the mutual impedance with a parallel lin
100+100i
User Notes:

If the Excel Analysis ToolPak is installed and working properly, the cell to the left should contain "100+100i

Conductor Locations
40

35

N1

30
A

25

The impedance of the total line length in ohms:


Magnitude Degrees Magnitude Degrees
0.9187
77.68
0.2946
74.96
ZABC =
0.2940
74.90
0.9350
78.08
0.2659
73.52
0.2940
74.92
The impedances in the above matrix refer to the ABC domain impedances below

C
20

15

Resultant Symmetrical Component Domain Impedances in ohms


Magnitude Degrees Magnitude Degrees
1.4920
76.53
0.0161
-24.23
Z012 =
0.0155
-150.77
0.6396
79.28
0.0153
-24.91
0.0132
23.31
Z1, Z2 using K*ln(GMD/GMR) and phase A wire R, GMR
The impedances in the above matrix refer to the 012 domain impedances below.
Z00, Z11, and Z22 are the values commonly referred to as Z0, Z1, and Z2.

N2

10

0
-6

-4

-2

X Distance from Ph A

t is a partial implementation of what is referred to as Carson's Equations. See referenced paper for discussion. If one expects results that mi
y implements those equations.
not been deeply checked against a professionally written software package. Use the results with caution.

s described in the paper, "Zero Sequence Impedance of Overhead Transmission Lines" (see www.basler.com).
y texts. See the referenced paper for the equation.
r 0 resistance for that wire. The spreadsheet checks if R<0.00001 per unit length, and if so, it uses R =1E+6 per unit length instead.
is fixed at 0. The X position of B, C, and N1 and N2 can be positive or negative. The calculations and X and Y input accept any conductor
be the lowest, highest, the farthest to the right or the left, or anywhere in between. The only limitation is that phase A is expected to be at X
sured, and that Y is positive for all conductors.
is an easy calculation (see referenced paper) and is left to the user to apply and then enter the appropriate value in the cells.
the mutual impedance with a parallel line, nor does it calculate the impedance of 2+ parallel lines.

e cell to the left should contain "100+100i." If it says "#NAME?" or any other message, or you see "#VALUE!" messages on this sheet, see th

Magnitude Degrees
0.2658
73.51
0.2933
74.85
0.9167
77.63
ABC domain impedances below:

edances in ohms
Magnitude Degrees
0.0162
-150.40
0.0134
141.55
0.6396
79.28
0.6441
79.52
012 domain impedances below.
erred to as Z0, Z1, and Z2.

on. If one expects results that mimic

om).

6 per unit length instead.


Y input accept any conductor
t phase A is expected to be at X = 0

value in the cells.

" messages on this sheet, see the

Conductor X, Y coordinates
X
Y
A
0
29
B
-5
25
C
0
21
N1
-2.5
35
N2
-2
15
Separation between conductors (feet).
dX
dY
A-B
5.00
4.00
A-C
0.00
8.00
A-N1
2.50
-6.00
A-N2
2.00
14.00
B-C
-5.00
4.00
B-N1
-2.50
-10.00
B-N2
-3.00
10.00
C-N1
2.50
14.00
C-N2
2.00
6.00
N1-N2
-0.50
20.00
GMD, Phase Conductors, (feet).

Total
6.40
8.00
6.50
14.14
6.40
10.31
10.44
14.22
6.32
20.01
6.90

Blank unprotected sheet for user's work

Basic Fault Calculator

30o Lead

System Data:

Zn

Magnitude

Degrees
E prefault
0
Magnitude Degrees
Z0
Z1
Z2
Zf
Zn

Calculate

E-prefault

I-fault
Clear All

Z-system

Fault Calculations
Three Phase

A phase to ground

In Fault

In Fault
Mag

Degrees

I-a
I-b
I-c
I-0
I-1
I-2
Other side of Xfmr
Mag
I-a
I-b
I-c
I-0
I-1
I-2

In Fault
Mag

Degrees

I-a
I-b
I-c
I-0
I-1
I-2
Degrees

Z-fault

Phase B to Phase C

Other side of Xfmr


Mag
I-a
I-b
I-c
I-0
I-1
I-2

Mag

Degrees

I-a
I-b
I-c
I-0
I-1
I-2
Degrees

Other side of Xfmr


Mag
I-a
I-b
I-c
I-0
I-1
I-2

Degrees

Instructions:
=> Enter in the appropriate info in the System Data fields, an then press the "Calculate" button.
=> The spreadsheet is simply performing the classical fault calculations given below:
I-3ph:
I-B to C:
I-A to Gnd:
I1 = E/(Z1+Zf)
I1 = -I2 = E/(Z1+Z2+Zf)
I1 = I2 = I0 = E/(Z1+Z2+Z0+3Zf+3Zn)
and then converting to ABC quantities.
If the Excel Analysis ToolPak is installed and working properly, the cell to the left should contain
"100+100i." If it says "#NAME?" or any other message, or you see "#VALUE!" messages on this
100+100i
sheet, see the Instructions Sheet for details on enabling Excel's Analysis ToolPak.
User Notes:

11

12/21/2012

121410345.xls.ms_office

Basic Voltage Drop & Load Flow Calculator


Given Es, Er:
Magnitude
Es
Er

Degrees
0.0000

Magnitude
Es
I

Magnitude
Er
I
Given Es, Ss:
Magnitude
Es
Watts
Ss
Given Er, Sr:
Magnitude
Er
Watts
Sr

Magnitude

Z-line

Degrees

Solution is for:

Degrees
0.0000

Degrees
0.0000

Calculate

Degrees
0.0000
VARs

Calculate

Degrees
0.0000
VARs

X/R to Angle
Converter:

Z-line

I, Ss

Calculate

Given Er, I:

Er

Es

Calculate

Calculate

Given Es, I:

Miscellaneous Other Calcs:

I, Sr

VA/PF to
Watt/VAR

Clear Load Flow

Watts

VAR

VA

Power Fact.

Per Unit / Base Calculations

Ss
Sr
Sline
Real

Imaginary

Mag.

Degrees

Es
Er
Es-Er
I
Add the Window's Scientific Calculator to your Excel Toolbar:
1) Click through the Excel menu tree: Tools/Customize.
2) Select the "Commands" tab, then in the "Categories" list click on "Tools."
3) In the scroll-down list of "Commands," there will be a few items that are simply named "Custom."
Select the "Custom" command that has an icon that looks like a little calculator. Left click on it and
drag it to somewhere in your toolbars.
4) Click on Close.
5) If you want to remove the icon later, repeat step 1, left click on the icon and drag it off the toolbar.

Three Phase
MVA base, 3ph
kV Base, L-L
Given Ohmic Value
Given Current Value
Given MVA Value
KV, Line to Gnd
I-base
Z-base
Coverted Values
Ohms PU
Current PU
MVA PU

Instructions:
=> Enter in the basic data in the appropriate fields, and then press the appropriate "Calculate" button.
=> The load flow calculations are simple manipulations of S = E x I* and E = I x Z in complex number format. Macros just copy data from the Intermediate Calcs sheet to this sheet.
=> Calculations are for balanced systems (i.e., single phase represents all three phases).
=> Calculations use per unit voltages and currents, so that S = E x I* (e.g., the equation S = Sqrt(3) x El-l x I* is NOT used).
=> Generally Es or Er is the reference angle against which other angles are measured and 0 is degrees would normally be used for Es (or Er), so the angle for Es and Er defaults to
degrees. However, the angle for Es and Er can be set to other than 0 and the entered angle will be used in the calculations.
100+100i

If the Excel Analysis ToolPak is installed and working properly, the cell to the left should contain "100+100i." If it says "#NAME?" or any other message, or y
"#VALUE!" messages on this sheet, see the Instructions Sheet for details on enabling Excel's Analysis ToolPak.

User Notes:

12

12/21/2012

121410345.xls.ms_office

Graphs
Instructions; Setting graph plot ranges:
Between limitations in the Excel plotting/graphing functions and the varieties of plots that might be desired, only a few starting point graphs are provided below. To use these graphs one task that will likely be needed is to
adjust the min and max of the X and Y scales to be the same so the graphs will look "correct" for a polar type view. To set Xmax/min and Ymax/min, double left click on each axis (real and imaginary), and select the 'scale'
tab on the screen that pops up, then set the min and max values.

Graph of Q1, Q2, Calc Results from Complex Calc Sheet

Graph of Vln, Vll, I in ABC Format

Graph of Vln, Vll, I in 012 format

20
15

0
-20

-10

10

20

Imaginary

Imaginary

0
-5

-3

-1

-1

-5

Imaginary

10

-5

-3

-1

-1

-2

-2

-3

-3

-4

-4

-5

-5

-10
-15
-20
Real
Q1

Q2

Calc

Graph Data

Real

Q1

0 Phasor Origin (0)

4 Phasor End Point

0 Phasor Origin (0)

4 Phasor End Point

0 Phasor Origin (0)

0 Phasor End Point

Q2
Calc

Imaginary

Van

Vbn

Vcn

Vab

Vca

Ia

Ib

Ic

Vbc

Graph Data

Real

Van

0.000

0.000 Phasor Origin (0)

415.000

425.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

415.000

425.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

415.000

425.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

Vbn
Vcn
Vab
Vbc
Vca
Ia
Ib
Ic

13

Real

Real

12/21/2012

Imaginary

V0,ln

V1,ln

V2,ln

V1,ll

V2,ll

I0

I1

I2

Graph Data

Real

V0,ln

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

0.000

0.000 Phasor Origin (0)

0.000

0.000 Phasor End Point

V1,ln
V2,ln
V1,ll
V2,ll
I0
I1
I2

Imaginary

121410345.xls.ms_office

This sheet contains intermediate calculations for display on other pages.


Complex Calc Sheet. Data to be copied when the appropriate macro is run.
Rect. Conversion from polar data
Real
Imaginary

Polar Conversion from rect. Data


Magnitude
Degrees

Quantity 1

3.000000

4.000000

5.000000

53.130102

Quantity 2

3.000000

4.000000

5.000000

53.130102

Q1 + Q2
Q1 - Q2
Q1 x Q2
Q1 / Q2

6.000000
0.000000
-7.000000
1.000000

8.000000
0.000000
24.000000
0.000000

10.000000
0.000000
25.000000
1.000000

53.130102
0.000000
106.260205
0.000000

+/- Q1
Q1 Conjugate
+/- Q2
Q2 Conjugate

Q1^2
Sqrt(Q1)
1/Q1

-7.000000
2.000000
0.120000

24.000000
1.000000
-0.160000

25.000000
2.236068
0.200000

106.260205
26.565051
-53.130102

Q1<=>Q2

Q1 x Q2*
Q1 || Q2

25.000000
1.500000

0.000000
2.000000

25.000000
2.500000

0.000000
53.130102

Real

Imaginary

Magnitude

Angle

-3.000000
3.000000
-3.000000
3.000000

-4.000000
-4.000000
-4.000000
-4.000000

5.000000
5.000000
5.000000
5.000000

-126.869898
-53.130102
-126.869898
-53.130102

New Q1

3.000000

4.000000

5.000000

53.130102

New Q2

3.000000

4.000000

5.000000

53.130102

V&I,ABC<>012 Sheet. Data to be copied when the appropriate macro is run.


Vl-n ABC rectangular conversions

A-B-C Quantities
Real

Imaginary

Magnitude

Degrees

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary

Degrees

Vl-n

A-N
B-N
C-N

415.000000
415.000000
415.000000

425.000000
425.000000
425.000000

594.011784
594.011784
594.011784

45.682060
45.682060
45.682060

0
1
2

415.000000
0.000000
0.000000

425.000000
0.000000
0.000000

594.011784
0.000000
0.000000

45.682060
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-n ABC polar conversions

A-B-C Quantities
Real

Imaginary

Magnitude

Degrees

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary

Degrees

Vl-n

A-N
B-N
C-N

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-n 012 rectangular conversions

A-B-C Quantities
Real

Imaginary

Magnitude

Degrees

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary

Degrees

Vl-n

A-N
B-N
C-N

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-n 012 polar conversions

A-B-C Quantities
Real

Imaginary

Magnitude

Degrees

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary

Degrees

Vl-n

A-N
B-N
C-N

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l ABC rectangular conversions

A-B-C Quantities
Real

Imaginary

Magnitude

Degrees

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary

Degrees

Vl-n

A-N
B-N
C-N

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l ABC polar conversions

A-B-C Quantities
Real

Imaginary

Magnitude

Degrees

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary

Degrees

Vl-n

A-N
B-N
C-N

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l 012 rectangular conversions

A-B-C Quantities
Real

Imaginary

Magnitude

Degrees

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary

Degrees

Vl-n

A-N
B-N
C-N

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l 012 polar conversions

A-B-C Quantities
Real

Imaginary

Magnitude

Degrees

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary

Degrees

Vl-n

A-N
B-N
C-N

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000

0
1

I ABC rectangular conversions

A-B-C Quantities
Real
A
B
C

Vl-n

Imaginary
0.000000
0.000000
0.000000

I ABC polar conversions


Imaginary
0.000000
0.000000
0.000000

Real

0-1-2 Sequence Quantities


Magnitude

Imaginary
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Real

Imaginary
0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Magnitude
0.000000
0.000000
0.000000

A-B-C Quantities
Real

14

Magnitude

0.000000
0.000000
0.000000

I 012 rectangular conversions

Degrees
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

A-B-C Quantities
Real
A
B
C

Magnitude

0.000000
0.000000
0.000000

A
B

Imaginary
0.000000
0.000000

0.000000
0.000000

Magnitude

Degrees
0.000000
0.000000

Real

12/21/2012

0-1-2 Sequence Quantities


Magnitude

Imaginary
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

0.000000
0.000000

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000

0.000000
0.000000

Named Ranges List


a_1
a_2
abc_i.012
abc_i.012.p
abc_i.012.r
abc_i.abc
abc_i.abc.p
abc_i.abc.r
abc_mem1.012
abc_mem1.12
abc_mem1.ab
abc_mem1.abc
abc_mem2.012
abc_mem2.12
abc_mem2.ab
abc_mem2.abc
abc_results.012
abc_results.abc
abc_results.ix.012
abc_results.ix.abc
abc_results.vx.vll.012
abc_results.vx.vll.12
abc_results.vx.vll.ab
abc_results.vx.vll.abc
abc_results.vx.vln.012
abc_results.vx.vln.abc
abc_vll.012
abc_vll.12
abc_vll.12.p
abc_vll.12.r
abc_vll.ab
abc_vll.ab.p
abc_vll.ab.r
abc_vll.abc
abc_vln.012
abc_vln.012.p
abc_vln.012.r
abc_vln.abc
abc_vln.abc.p
abc_vln.abc.r
bf_all.results
cc_m1
cc_m2
cc_m3
cc_m4
cc_q1
cc_q1.polar
cc_q1.rect
cc_q1q2
cc_q2
cc_q2.polar
cc_q2.rect
cc_results
cc_results.data.only
ic.cc_1.over.q1
ic.cc_plusminus.q1
ic.cc_plusminus.q2
ic.cc_q1.conjugate
ic.cc_q1.divide.q2
ic.cc_q1.minus.q2
ic.cc_q1.over.q2
ic.cc_q1.parallel.q2
ic.cc_q1.plus.q2
ic.cc_q1.polar.conv.from.rect
ic.cc_q1.q2.exchange
ic.cc_q1.rect.conv.from.polar
ic.cc_q1.squared
ic.cc_q1.x.q2
ic.cc_q1.x.q2conjugate
ic.cc_q2.conjugate
ic.cc_q2.polar.conv.from.rect
ic.cc_q2.rect.conv.from.polar
ic.cc_sqrt.q1
ic.complexcheck.i
ic.complexcheck.r
ic.fault_all.results
ic.i.012.p_012.p
ic.i.012.p_012.r
ic.i.012.p_abc.p
ic.i.012.p_abc.r
ic.i.012.r_012.p
ic.i.012.r_012.r
ic.i.012.r_abc.p
ic.i.012.r_abc.r
ic.i.abc.p_012.p
ic.i.abc.p_012.r
ic.i.abc.p_abc.p
ic.i.abc.p_abc.r
ic.i.abc.r_012.p
ic.i.abc.r_012.r
ic.i.abc.r_abc.p
ic.i.abc.r_abc.r
ic.i_plusminus.012
ic.i_plusminus.abc
ic.isum3_012
ic.isum3_abc
ic.ix.dab_012
ic.ix.dab_abc
ic.ix.dac_012
ic.ix.dac_abc
ic.ix.yy_012
ic.ix.yy_abc

=IMCalcs!$H$276
=IMCalcs!$H$277
='V&I,ABC<>012'!$K$16:$O$18
='V&I,ABC<>012'!$N$16:$O$18
='V&I,ABC<>012'!$K$16:$L$18
='V&I,ABC<>012'!$D$16:$H$18
='V&I,ABC<>012'!$G$16:$H$18
='V&I,ABC<>012'!$D$16:$E$18
='V&I,ABC<>012'!$K$21:$O$23
='V&I,ABC<>012'!$K$22:$O$23
='V&I,ABC<>012'!$D$21:$H$22
='V&I,ABC<>012'!$D$21:$H$23
='V&I,ABC<>012'!$K$24:$O$26
='V&I,ABC<>012'!$K$25:$O$26
='V&I,ABC<>012'!$D$24:$H$25
='V&I,ABC<>012'!$D$24:$H$26
='V&I,ABC<>012'!$K$35:$O$43
='V&I,ABC<>012'!$D$35:$H$43
='V&I,ABC<>012'!$K$41:$O$43
='V&I,ABC<>012'!$D$41:$H$43
='V&I,ABC<>012'!$K$38:$O$40
='V&I,ABC<>012'!$K$39:$O$40
='V&I,ABC<>012'!$D$38:$H$39
='V&I,ABC<>012'!$D$38:$H$40
='V&I,ABC<>012'!$K$35:$O$37
='V&I,ABC<>012'!$D$35:$H$37
='V&I,ABC<>012'!$K$11:$O$13
='V&I,ABC<>012'!$K$12:$O$13
='V&I,ABC<>012'!$N$12:$O$13
='V&I,ABC<>012'!$K$12:$L$13
='V&I,ABC<>012'!$D$11:$H$12
='V&I,ABC<>012'!$G$11:$H$12
='V&I,ABC<>012'!$D$11:$E$12
='V&I,ABC<>012'!$D$11:$H$13
='V&I,ABC<>012'!$K$6:$O$8
='V&I,ABC<>012'!$N$6:$O$8
='V&I,ABC<>012'!$K$6:$L$8
='V&I,ABC<>012'!$D$6:$H$8
='V&I,ABC<>012'!$G$6:$H$8
='V&I,ABC<>012'!$D$6:$E$8
='Basic Faults'!$B$16:$L$34
=ComplexCalc!$D$9:$H$9
=ComplexCalc!$D$10:$H$10
=ComplexCalc!$D$11:$H$11
=ComplexCalc!$D$12:$H$12
=ComplexCalc!$D$5:$H$5
=ComplexCalc!$G$5:$H$5
=ComplexCalc!$D$5:$E$5
=ComplexCalc!$D$5:$H$7
=ComplexCalc!$D$7:$H$7
=ComplexCalc!$G$7:$H$7
=ComplexCalc!$D$7:$E$7
=ComplexCalc!$B$17:$H$17
=ComplexCalc!$D$17:$H$17
=IMCalcs!$B$18:$H$18
=IMCalcs!$K$12:$O$12
=IMCalcs!$K$14:$O$14
=IMCalcs!$K$13:$O$13
=IMCalcs!$B$15:$H$15
=IMCalcs!$B$13:$H$13
=IMCalcs!$B$18:$H$18
=IMCalcs!$B$20:$H$20
=IMCalcs!$B$12:$H$12
=IMCalcs!$G$7:$H$7
=IMCalcs!$K$16:$O$18
=IMCalcs!$D$7:$E$7
=IMCalcs!$B$16:$H$16
=IMCalcs!$B$14:$H$14
=IMCalcs!$B$19:$H$19
=IMCalcs!$K$15:$O$15
=IMCalcs!$G$9:$H$9
=IMCalcs!$D$9:$E$9
=IMCalcs!$B$17:$H$17
=IMCalcs!$D$730
=IMCalcs!$C$730
=IMCalcs!$B$221:$L$239
=IMCalcs!$N$108:$O$110
=IMCalcs!$K$108:$L$110
=IMCalcs!$G$108:$H$110
=IMCalcs!$D$108:$E$110
=IMCalcs!$N$103:$O$105
=IMCalcs!$K$103:$L$105
=IMCalcs!$G$103:$H$105
=IMCalcs!$D$103:$E$105
=IMCalcs!$N$98:$O$100
=IMCalcs!$K$98:$L$100
=IMCalcs!$G$98:$H$100
=IMCalcs!$D$98:$E$100
=IMCalcs!$N$93:$O$95
=IMCalcs!$K$93:$L$95
=IMCalcs!$G$93:$H$95
=IMCalcs!$D$93:$E$95
=IMCalcs!$K$123:$O$125
=IMCalcs!$D$123:$H$125
=IMCalcs!$K$170:$O$172
=IMCalcs!$D$170:$H$172
=IMCalcs!$K$155:$O$157
=IMCalcs!$D$155:$H$157
=IMCalcs!$K$160:$O$162
=IMCalcs!$D$160:$H$162
=IMCalcs!$K$150:$O$152
=IMCalcs!$D$150:$H$152
121410345.xls.ms_office

0.000000

0.000000

I 012 polar conversions

0.000000

0.000000

0.000000

0.000000

A-B-C Quantities
Real

A
B
C

Vl-n

A-N
B-N
C-N

Vl-l

A-N
B-C
C-A

A
B
C

Imaginary
0.000000
0.000000
0.000000

Magnitude

0.000000
0.000000
0.000000

+/- Vl-n

Degrees

Real

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

A-B-C Quantities
Real

Imaginary
-415.000000
-415.000000
-415.000000

Magnitude

-425.000000
-425.000000
-425.000000

+/- Vl-l

Degrees

Real

0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

Magnitude

0.000000
0.000000
0.000000

+/- I

Degrees

Real

0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

Voltage Xfmr
Wye-Wye

Real

Magnitude

0.000000
0.000000
0.000000

Degrees

Real

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Imaginary

Magnitude

Degrees

Real

Degrees

0.000000
0.000000
0.000000
Imaginary

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000
0-1-2 Sequence Quantities
Magnitude

Imaginary
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0-1-2 Sequence Quantities
Magnitude

Imaginary
0.000000
0.000000
0.000000

A-B-C Quantities
Real

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

A-B-C Quantities
Real

Degrees

0-1-2 Sequence Quantities


Magnitude

Imaginary
0.000000
0.000000
0.000000

0.000000 ic.lf_er.i

0.000000
0-1-2 Sequence Quantities
Magnitude

Imaginary

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000
Magnitude

0.000000
0.000000
0.000000
Degrees

Vl-n

A-N
B-N
C-N

415.000000
415.000000
415.000000

425.000000
425.000000
425.000000

594.011784
594.011784
594.011784

45.682060
45.682060
45.682060

0
1
2

415.000000
0.000000
0.000000

425.000000
0.000000
0.000000

594.011784
0.000000
0.000000

45.682060
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

A
B
C

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Voltage Xfmr
Other

Real

Imaginary

Magnitude

Degrees

Real

Imaginary

Magnitude

Degrees

Vl-n

A-N
B-N
C-N

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-l

A-B
B-C
C-A

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

A
B
C

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0
1
2

0.000000
0.000000
0.000000

0
1
2

45.682060
45.682060
45.682060

0
1
2

0.000000
0.000000
0.000000

0
1
2

Current Xfmr
Wye Sec.

Real

Imaginary

A
B
C

0.000000
0.000000
0.000000

Current Xfmr
DAB Sec.

Real
0.000000
0.000000
0.000000

Currrent Xfmr
DAC

Real

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Real

Magnitude

0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

Degrees

Real

0.000000
0.000000
0.000000

Imaginary

A
B
C

Degrees
0.000000
0.000000
0.000000

Imaginary

A
B
C

Magnitude

0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

Degrees

Real

0.000000
0.000000
0.000000

Magnitude
0.000000
0.000000
0.000000
Magnitude
0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000
Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Mem1 = S = V x I*
Real

Imaginary

A
B
C

0.000000
0.000000
0.000000

Magnitude

0.000000
0.000000
0.000000

Degrees

Real

0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

Magnitude
0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Mem2 = Isum = I + Mem1


Real

Imaginary

A
B
C

Isum

0.000000
0.000000
0.000000

Magnitude

0.000000
0.000000
0.000000

Degrees

Real

0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

Magnitude
0.000000
0.000000
0.000000

Load Flow. Data to be copied when the appropriate macro is run


Given Es, Er

Given Er, Sr
Watts

Ss
Sr
Sline

VAR
0
0
0

Real
Es
Er
Es-Er
I

VA
0
0
0

Imaginary
0
0
0
0

Power Fact.
0
0
0

Mag.
0
0
0
0

Watts
0
0
0

Ss
Sr
Sline

0
0
0
0

Es
Er
Es-Er
I

Degrees
0
0
0
0

VAR
0
0
0

Real

Given Es, Ss

VA
0
0
0

Imaginary
0
0
0
0

Power Fact.
0
0
0

Mag.
0
0
0
0

0
0
0
Degrees

0
0
0
0

0
0
0
0

Degrees
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

ic.lf_er.sr
ic.lf_es.er
ic.lf_es.i
ic.lf_es.ss
ic.s3_012
ic.s3_abc
ic.vll.012.p_vll.12.p
ic.vll.012.p_vll.12.r
ic.vll.012.p_vll.ab.p
ic.vll.012.p_vll.ab.r
ic.vll.012.p_vln.012.p
ic.vll.012.p_vln.012.r
ic.vll.012.p_vln.abc.p
ic.vll.012.p_vln.abc.r
ic.vll.012.r_vll.12.p
ic.vll.012.r_vll.12.r
ic.vll.012.r_vll.ab.p
ic.vll.012.r_vll.ab.r
ic.vll.012.r_vln.012.p
ic.vll.012.r_vln.012.r
ic.vll.012.r_vln.abc.p
ic.vll.012.r_vln.abc.r
ic.vll.abc.p_vll.12.p
ic.vll.abc.p_vll.12.r
ic.vll.abc.p_vll.ab.p
ic.vll.abc.p_vll.ab.r
ic.vll.abc.p_vln.012.p
ic.vll.abc.p_vln.012.r
ic.vll.abc.p_vln.abc.p
ic.vll.abc.p_vln.abc.r
ic.vll.abc.r_vll.12.p
ic.vll.abc.r_vll.12.r
ic.vll.abc.r_vll.ab.p
ic.vll.abc.r_vll.ab.r
ic.vll.abc.r_vln.012.p
ic.vll.abc.r_vln.012.r
ic.vll.abc.r_vln.abc.p
ic.vll.abc.r_vln.abc.r
ic.vll_plusminus.12
ic.vll_plusminus.ab
ic.vln.012.p_vll.12.p
ic.vln.012.p_vll.12.r
ic.vln.012.p_vll.ab.p
ic.vln.012.p_vll.ab.r
ic.vln.012.p_vln.012.p
ic.vln.012.p_vln.012.r
ic.vln.012.p_vln.abc.p
ic.vln.012.p_vln.abc.r
ic.vln.012.r_vll.12.p
ic.vln.012.r_vll.12.r
ic.vln.012.r_vll.ab.p
ic.vln.012.r_vll.ab.r
ic.vln.012.r_vln.012.p
ic.vln.012.r_vln.012.r
ic.vln.012.r_vln.abc.p
ic.vln.012.r_vln.abc.r
ic.vln.abc.p_vll.12.p
ic.vln.abc.p_vll.12.r
ic.vln.abc.p_vll.ab.p
ic.vln.abc.p_vll.ab.r
ic.vln.abc.p_vln.012.p
ic.vln.abc.p_vln.012.r
ic.vln.abc.p_vln.abc.p
ic.vln.abc.p_vln.abc.r
ic.vln.abc.r_vll.12.p
ic.vln.abc.r_vll.12.r
ic.vln.abc.r_vll.ab.p
ic.vln.abc.r_vll.ab.r
ic.vln.abc.r_vln.012.p
ic.vln.abc.r_vln.012.r
ic.vln.abc.r_vln.abc.p
ic.vln.abc.r_vln.abc.r
ic.vln_plusminus.012
ic.vln_plusminus.abc
ic.vx.other_012
ic.vx.other_abc
ic.vx.yy_012
ic.vx.yy_abc
JJH
lf_results
m_30
p_30
Print_Area
sqrt3

=IMCalcs!$H$194:$L$203
=IMCalcs!$H$182:$L$191
=IMCalcs!$B$182:$F$191
=IMCalcs!$B$206:$F$215
=IMCalcs!$B$194:$F$203
=IMCalcs!$K$165:$O$167
=IMCalcs!$D$165:$H$167
=IMCalcs!$N$89:$O$90
=IMCalcs!$K$89:$L$90
=IMCalcs!$G$88:$H$89
=IMCalcs!$D$88:$E$89
=IMCalcs!$N$85:$O$87
=IMCalcs!$K$85:$L$87
=IMCalcs!$G$85:$H$87
=IMCalcs!$D$85:$E$87
=IMCalcs!$N$81:$O$82
=IMCalcs!$K$81:$L$82
=IMCalcs!$G$80:$H$81
=IMCalcs!$D$80:$E$81
=IMCalcs!$N$77:$O$79
=IMCalcs!$K$77:$L$79
=IMCalcs!$G$77:$H$79
=IMCalcs!$D$77:$E$79
=IMCalcs!$N$73:$O$74
=IMCalcs!$K$73:$L$74
=IMCalcs!$G$72:$H$73
=IMCalcs!$D$72:$E$73
=IMCalcs!$N$69:$O$71
=IMCalcs!$K$69:$L$71
=IMCalcs!$G$69:$H$71
=IMCalcs!$D$69:$E$71
=IMCalcs!$N$65:$O$66
=IMCalcs!$K$65:$L$66
=IMCalcs!$G$64:$H$65
=IMCalcs!$D$64:$E$65
=IMCalcs!$N$61:$O$63
=IMCalcs!$K$61:$L$63
=IMCalcs!$G$61:$H$63
=IMCalcs!$D$61:$E$63
=IMCalcs!$K$119:$O$120
=IMCalcs!$D$118:$H$119
=IMCalcs!$N$57:$O$58
=IMCalcs!$K$57:$L$58
=IMCalcs!$G$56:$H$57
=IMCalcs!$D$56:$E$57
=IMCalcs!$N$53:$O$55
=IMCalcs!$K$53:$L$55
=IMCalcs!$G$53:$H$55
=IMCalcs!$D$53:$E$55
=IMCalcs!$N$49:$O$50
=IMCalcs!$K$49:$L$50
=IMCalcs!$G$48:$H$49
=IMCalcs!$D$48:$E$49
=IMCalcs!$N$45:$O$47
=IMCalcs!$K$45:$L$47
=IMCalcs!$G$45:$H$47
=IMCalcs!$D$45:$E$47
=IMCalcs!$N$41:$O$42
=IMCalcs!$K$41:$L$42
=IMCalcs!$G$40:$H$41
=IMCalcs!$D$40:$E$41
=IMCalcs!$N$37:$O$39
=IMCalcs!$K$37:$L$39
=IMCalcs!$G$37:$H$39
=IMCalcs!$D$37:$E$39
=IMCalcs!$N$33:$O$34
=IMCalcs!$K$33:$L$34
=IMCalcs!$G$32:$H$33
=IMCalcs!$D$32:$E$33
=IMCalcs!$N$29:$O$31
=IMCalcs!$K$29:$L$31
=IMCalcs!$G$29:$H$31
=IMCalcs!$D$29:$E$31
=IMCalcs!$K$113:$O$115
=IMCalcs!$D$113:$H$115
=IMCalcs!$K$139:$O$147
=IMCalcs!$D$139:$H$147
=IMCalcs!$K$128:$O$136
=IMCalcs!$D$128:$H$136
=IMCalcs!$C$990
='Other Calcs'!$F$11:$J$20
=IMCalcs!$K$676
=IMCalcs!$K$675
=IMCalcs!$A$1:$R$731
=IMCalcs!$K$276

Given Er, I
Watts

Ss
Sr
Sline

VAR
0
0
0

Real
Es
Er
Es-Er
I

VA
0
0
0

Imaginary
0
0
0
0

Power Fact.
0
0
0

Mag.
0
0
0
0

Watts
0
0
0

Ss
Sr
Sline

0
0
0
0

Es
Er
Es-Er
I

Degrees
0
0
0
0

VAR
0
0
0

Real

VA
0
0
0

Imaginary
0
0
0
0

Power Fact.
0
0
0

Mag.
0
0
0
0

0
0
0
Degrees

0
0
0
0

0
0
0
0

Given Es, I
Watts
Ss

15

VAR
0

VA
0

Power Fact.
0

12/21/2012

121410345.xls.ms_office

Sr
Sline

0
0

0
0

Real
Es
Er
Es-Er
I

0
0

Imaginary
0
0
0
0

0
0

Mag.
0
0
0
0

Degrees
0
0
0
0

0
0
0
0

Fault Calc. Data to be copies when the appropriate macro is run.


Three Phase

A phase to ground

In Fault

In Fault
Mag

In Fault

Degrees

I-a
I-b
I-c
I-0
I-1
I-2

Phase B to Phase C

Mag

0
0
0
0
0
0

0
0
0
0
0
0

Degrees

I-a
I-b
I-c
I-0
I-1
I-2

Other side of Xfmr

Mag

0
0
0
0
0
0

0
0
0
0
0
0

I-a
I-b
I-c
I-0
I-1
I-2

Other side of Xfmr


Mag

Degrees

I-a
I-b
I-c
I-0
I-1
I-2

0
0
0
0
0
0

0.000000
0.000000
0.000000
0
0
0

Other side of Xfmr


Mag

0
0
0
0
0
0

Degrees
0.000000
0.000000
0.000000
0
0
0

Degrees

I-a
I-b
I-c
I-0
I-1
I-2

Mag

0
0
0
0
0
0

0
0
0
0
0
0

I-a
I-b
I-c
I-0
I-1
I-2

Degrees
0.000000
0.000000
0.000000
0
0
0

0.000000
0.000000
0.000000
0
0
0

Complex Calc sheet - calculations


Rectangular to Polar conversions
Complex format
Q1
Q2

Mag

3+4i
3+4i

Math calculations
Restating Data:

Degrees

5.000000
5.000000

Real

Imaginary

Q1
Q2
Q2 Conjugate

3.000000
3.000000
3.000000

Q1+Q2
Q1-Q2
Q1xQ2
Q1/Q2
Q1^2
Sqrt(Q1)
1/Q1
Q1xQ2conjugate
1/Q2
1/Q1 + 1/ Q2
Q1||Q2 = 1/[1/Q1 + 1/Q2]

6.000000
0.000000
-7.000000
1.000000
-7.000000
2.000000
0.120000
25.000000
0.120000
0.240000
1.500000

Radians

53.130102
53.130102

Complex

Polar to Rectangular conversions


Radians
Real

0.927295
0.927295

0.927295
0.927295

Mag

4.000000 3+4i
4.000000 3+4i
-4.000000 3-4i

Degrees

8.000000
0.000000
24.000000
0.000000
24.000000
1.000000
-0.160000
0.000000
-0.160000
-0.320000
2.000000

6+8i
0
-7+24i
1
-7+24i
2+i
0.12-0.16i
25
0.12-0.16i
0.24-0.32i
1.5+2i

4.000000
4.000000

Radians

5.000000
5.000000
5.000000

53.130102
53.130102
-53.130102

0.927295
0.927295
-0.927295
Radians, basic calc

10.000000
0.000000
25.000000
1.000000
25.000000
2.236068
0.200000
25.000000
0.200000
0.400000
2.500000

53.130102
0.000000
106.260205
0.000000
106.260205
26.565051
-53.130102
0.000000
-53.130102
-53.130102
53.130102

0.927295
0.000000
1.854590
0.000000
1.854590
0.463648
-0.927295
0.000000
-0.927295
-0.927295
0.927295

Performing Calcs:

Imaginary

3.000000
3.000000

Simplified Radians

1.854590
0.000000
1.854590
0.463648
-0.927295
0.000000
-0.927295
-0.927295
0.927295

V&I,ABC<>012 sheet - calculations


Vll Vca

Real
Vca, rect.

Vca, polar

Vab
Vbc
Vca = -sum
Vab rectangular

0.000000
0.000000
0.000000
0.000000

Vac rectangular
Vca = -sum

0.000000
0.000000

V conversions, starting with Vln ABC rectangular


Given:
Vl-n

Imaginary
0.000000
0.000000
0.000000
0.000000

a1, a2 constants:
a_1
a_2

0.000000
Complex Format
0.000000 0

Real

Imaginary

AN
BN
CN

415.000000
415.000000
415.000000

AB
BC
CA

0.000000
0.000000
0.000000
Cmplx ABC Data/3

Complex Format

425.000000 415+425i
425.000000 415+425i
425.000000 415+425i

Square Root 3
sqrt3

-0.5+0.866025403784439i
-0.5-0.866025403784438i

Magnitude
0.000000

Degrees
0.000000

Radians
0.000000

Magnitude

Degrees

Radians

594.011784
594.011784
594.011784

45.682060
45.682060
45.682060

0.797302
0.797302
0.797302

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
Complex 012 Data

0.000000
0.000000
0.000000
Real

1.732050808

Calculated Line to Line, ABC format


Vl-l
ABC to 012 conversion

0.000000 0
0.000000 0
0.000000 0
*a_1

*a_2

Vl-n

AN
BN
CN

138.333333333333+141.666666666667i
0
138.333333333333+141.666666666667i
-191.853598869462+48.9668475235136i
53.5202655361292-190.63351419018i
1
138.333333333333+141.666666666667i
-191.853598869462+48.9668475235136i
53.5202655361292-190.63351419018i
2

414.999999999999+425.000000000001i
415.000000
2.1316282072803E-13+5.96855898038484E-13i
0.000000
1.98951966012828E-13+6.03961325396085E-13i
0.000000

Vl-l

AB
BC
CA

0
0
0

0
0
0

V conversions, starting with Vln ABC polar


Given:
Vl-n

0
0

Magnitude

0
1
2

0
0

Angle

Radians

Real

0.000000
0.000000
0.000000

Imaginary

AN
BN
CN

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0
0.000000
0.000000

0
0.000000
0.000000

0 0
0.000000 0
0.000000 0

AB
BC
CA

0.000000
0.000000
0.000000
Cmplx ABC Data/3

0.000000
0.000000
0.000000
*a_1

0.000000
0.000000
0.000000
*a_2

0.000000
0.000000
0.000000

0.000000 0
0.000000 0
0.000000 0
Complex 012 Data

Imaginary

Magnitude

Degrees

Radians

425.000000
0.000000
0.000000

594.011784
0.000000
0.000000

45.682060
0.000000
0.000000

0.797302
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Complex Format

Calculated Line to Line, ABC format


Vl-l
ABC to 012 conversion
Vl-n

16

AN
BN
CN

0
0
0

0
0

0
0

0
1
2

0
0
0

Real
0.000000
0.000000
0.000000

Imaginary

Magnitude

0.000000
0.000000
0.000000

12/21/2012

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

121410345.xls.ms_office

AB
BC
CA

Vl-l

0
0
0

V conversions, starting with Vln 012 rectangular


Given:

Real

0
1
2

Vl-n

0
1
2

0
0
0

Calculated Line to Line, ABC format

AB
BC
CA

Vl-l

Magnitude

0
1
2

012 to ABC conversion


0
1
2

Vl-n

0
0
0

Calculated Line to Line, ABC format

AB
BC
CA

Vl-l

0
0
0

Real

AB
BC
CA
AB
BC
CA

0
0
0

Calculated Line-Line, 012 format

0
1
2

0
0
0

V conversions, starting with Vll ABC polar


Given:

AB
BC
CA

0
0
0

0
0
0

V conversions, starting with Vll 012 rectangular


Given:

0
1
2

Vl-n

0.000000 0
0.000000 0
0.000000 0
Complex ABC data
0
0
0

Real
0.000000
0.000000
0.000000

012 to ABC conversion

Imaginary
0
0
0

Imaginary

Magnitude

0.000000
0.000000
0.000000

Imaginary

0.000000
0.000000
0.000000

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Imaginary

Magnitude

0.000000
0.000000
0.000000

Imaginary

0.000000
0.000000
0.000000

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Imaginary

Magnitude

0.000000
0.000000
0.000000

Imaginary

0.000000
0.000000
0.000000

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians

Complex 012 Data


0
1
2
Real

0.000000
0.000000
0.000000
*a_2

Imaginary

Complex Format

0.000000 0
0.000000 0
0.000000 0
Degrees
0.000000
0.000000
0.000000
*a_1

0
0
0
Imaginary
0.000000
0.000000
0.000000

AN
BN
CN

0
0

0.000000 0
0.000000 0
0.000000 0
Complex ABC data
0
0
0

Magnitude

0.000000
0.000000
0.000000
Imaginary

Real

0.000000
0.000000
0.000000
*a_2

0.000000
0.000000
0.000000

Real
0.000000
0.000000
0.000000
Complex Format

Real
0.000000
0.000000
0.000000

Degrees

0.000000
0.000000
0.000000
Radians

Complex Format
0 0
0 0
0 0

*a_2
0
0

0
0

0.000000
0.000000
0.000000
Complex 012 data

Real
0
0
0

0.000000
0.000000
0.000000
*a_1

0.000000
0.000000
0.000000
Magnitude

Calculated Line to Neutral, 012 format

Radians

Degrees

Real

0
1
2

Vl-l

0
0
0.000000
0.000000
0.000000
Complex 012 Data

012 to ABC conversion


0
1
2

0.000000
0.000000
0.000000
Real
0.000000
0.000000
0.000000
Complex Format

Imaginary
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Radians

0.000000
0.000000
0.000000
Complex 012 Data
0
0
0

AN
BN
CN

0
0

0.000000
0.000000
0.000000
*a_1

Magnitude
0
1
2

Vl-n

0.000000
0.000000
0.000000
*a_2

Real
0.000000
0.000000
0.000000

Degrees

0
1
2
Real

0.000000
0.000000
0.000000

Comment: V0 was included in calculations in the next 4 conversions below as a check. It should always be zero.

Calculated Line-LIne, 012 format


Vl-n

0
0
0

*a_2

Radians

Angle

0.000000
0.000000
0.000000
Cmplx ABC Data / 3

ABC to 012 conversion


Vl-l

0
0

0.000000 0
0.000000 0
0.000000 0
Complex 012 Data

0.000000
0.000000
0.000000

Real
0.000000
0.000000
0.000000
Complex Format

Imaginary

Magnitude

0
0
0.000000
0.000000
0.000000
*a_1

Magnitude

AB
BC
CA

Vl-l

Complex Format

Degrees

0.000000
0.000000
0.000000
Complex 012 Data

012 to ABC conversion


Vl-n

0
0

0
0
0

0
1
2

0
0

0.000000
0.000000
0.000000

Complex Format

0.000000 0
0.000000 0
0.000000 0
Complex ABC Data

0.000000
0.000000
0.000000

Real
0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
*a_2

0.000000 0
0.000000 0
0.000000 0
*a_1

Magnitude
0
1
2

Vl-n

Radians

Imaginary

0.000000
0.000000
0.000000
Cmfplx ABC Data / 3

ABC to 012 conversion


Vl-l

0
0

0
0
0

AN
BN
CN
Real

0
0
0.000000
0.000000
0.000000
*a_1

0.000000 0
0.000000 0
0.000000 0
Complex 012 Data

Real

0.000000
0.000000
0.000000
Real
0.000000
0.000000
0.000000
Complex Format

Imaginary
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
*a_2

Angle

0.000000
0.000000
0.000000
Cmplx ABC Data/3

V conversions, starting with Vll ABC rectangular


Given:
Vl-l

0
0

0
0
0

0
1
2

Radians

0.000000
0.000000
0.000000
*a_1

Magnitude

AB
BC
CA
V Line to Line, ABC to 012 Conversion
Vl-l

0.000000
0.000000
0.000000
*a_2
0
0

Angle

0.000000
0.000000
0.000000
Complex 012 data

AN
BN
CN
Real

0.000000
0.000000
0.000000

Radians

0.000000
0.000000
0.000000
Complex ABC Data

*a_2

Radians

0.000000
0.000000
0.000000

Degrees

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
*a_1
0
0

0
0
0

Magnitude

0
0
Angle

0.000000
0.000000
0.000000
Cmplx ABC Data/3

V conversions, starting with Vln 012 polar


Given:
Vl-n

0
0

0
0
0

Complex Format

0.000000 0
0.000000 0
0.000000 0
*a_1

Magnitude

AB
BC
CA
V Line to Line, ABC to 012 Conversion
Vl-l

0
1
2

0
0

Imaginary

0.000000
0.000000
0.000000
Complex 012 data

012 to ABC conversion


Vl-n

0
0

0.000000 0
0.000000 0
0.000000 0
Complex ABC Data

Imaginary

Magnitude

0.000000
0.000000
0.000000

Imaginary

0.000000
0.000000
0.000000

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000
Complex Format

Real

Imaginary

Magnitude

Degrees

Radians

Vl-l

0
1
2

0
0
0

0
0

0
0

AB
BC
CA

0
0
0

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Vl-n

0
1
2

0
0
0

0
0

0
0

AN
BN
CN

0
0
0

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

V conversions, starting with Vll 012 polar


Given:
Vl-l

Magnitude

Degrees

Radians

0
1
2

0.000000
0.000000
0.000000
Magnitude

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000
Radians

0
1
2

0.000000
0.000000
0.000000
Complex 012 data

0.000000
0.000000
0.000000
*a_1

0.000000
0.000000
0.000000
*a_2

Calculated Line to Neutral, 012 format


Vl-n
012 to ABC conversion

17

Real

Imaginary
0.000000
0.000000
0.000000

Real
0.000000
0.000000
0.000000
AB

Complex Format

0.000000 0
0.000000 0
0.000000 0
Imaginary
Complex Format
0.000000 0
0.000000 0
0.000000 0
Complex ABC Data
0

Real
0.000000

Imaginary

Magnitude

0.000000

12/21/2012

0.000000

Degrees
0.000000

Radians
0.000000

121410345.xls.ms_office

Vl-l

Vl-n

1
2

0
0

0
1
2

0
0
0

I conversions, starting with ABC rectangular


Given:

A
B
C

0
0
0

I conversions, starting with ABC polar


Given:

A
B
C

0
1
2

0
1
2

0.000000
0.000000

0
0

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Complex Format

0
1
2

0
0
0

Complex Format

0.000000 0
0.000000 0
0.000000 0
Complex Format 012 Data
0
0
0

Magnitude

0.000000
0.000000
0.000000
Complex ABC Data

*a_2
A
B
C

Radians

0
0
0

Real

0.000000
0.000000
0.000000
*a_2
A
B
C

0
0

0.000000 0
0.000000 0
0.000000 0
Complex ABC Data
0
0
0

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Complex Format

Real

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000
Real
0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
Real

0.000000
0.000000
0.000000

Degrees

0.000000
0.000000
0.000000

Radians

0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000

0
1
2

0
0

0
0

0.000000
0.000000
0.000000
Complex 012 Data

Real

0.000000
0.000000
0.000000
*a_2

0.000000
0.000000
0.000000
*a_1

Degrees

*a_2

Radians

Angle

0
0
0

Magnitude
0.000000
0.000000
0.000000

0
0

0
0

0.000000
0.000000
0.000000
Complex 012 Data

012 to ABC conversion

0.000000
0.000000

0.000000
0.000000
0.000000

0.000000 0
0.000000 0
0.000000 0
*a_1

Magnitude

0
1
2

0.000000
0.000000

0.000000
0.000000
0.000000

Imaginary

0
0
0

Vl-n conversions, starting with 012 polar


Given:

0.000000
0.000000

0.000000
0.000000
0.000000

0
0

0
0

0.000000
0.000000
0.000000
Complex 012 data

012 to ABC conversion

0.000000
0.000000

0
0
0

0.000000
0.000000
0.000000
*a_1

Real

0
1
2

0
0

AN
BN
CN

Angle

0
0
0

I conversions, starting with 012 rectangular


Given:
I

0
0

0.000000
0.000000
0.000000
Cmplx ABC Data / 3

ABC to 012 conversion

BC
CA

0.000000 0
0.000000 0
0.000000 0
*a_1

Magnitude
A
B
C

0
0

Imaginary

0.000000
0.000000
0.000000
Cmplx ABC Data / 3

ABC to 012 conversion


I

0
0

Real

A
B
C

0
0

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Complex Format

Real
0.000000
0.000000
0.000000

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Transformer calculations. First copy in base ABC data, then convert to 012 formats again. Then do the Xfmr conversion math.
Restating Primary Data:

Real

Imaginary

Vl-n

AN
BN
CN

415.000000
415.000000
415.000000

Vl-l

AB
BC
CA

0.000000
0.000000
0.000000

A
B
C

0.000000
0.000000
0.000000

Complex format

425.000000 415+425i
425.000000 415+425i
425.000000 415+425i

ABC to 012 conversion, rectangular format, then convert to polar


Cmplx ABC Data / 3

mag

degrees

radians

594.011784
594.011784
594.011784

45.682060
45.682060
45.682060

0.797302
0.797302
0.797302

0.000000 0
0.000000 0
0.000000 0

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000 0
0.000000 0
0.000000 0

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

*a_1

*a_2

Complex 012 Data

Real

Vl-n

AN
BN
CN

138.333333333333+141.666666666667i
0
138.333333333333+141.666666666667i
-191.853598869462+48.9668475235136i
53.5202655361292-190.63351419018i
1
138.333333333333+141.666666666667i
-191.853598869462+48.9668475235136i
53.5202655361292-190.63351419018i
2

414.999999999999+425.000000000001i
415.000000
2.1316282072803E-13+5.96855898038484E-13i
0.000000
1.98951966012828E-13+6.03961325396085E-13i
0.000000

Vl-l

AB
BC
CA

0
0
0

0
0

0
0

0
1
2

0
0
0

A
B
C

0
0
0

0
0

0
0

0
1
2

0
0
0

Imaginary

Magnitude

Degrees

Radians

425.000000
0.000000
0.000000

594.011784
0.000000
0.000000

45.682060
0.000000
0.000000

0.797302
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Voltage Transformer, Wye-Wye


Transformer Effect on:
Zero Sequence
Positve sequence
Negative sequence
Secondary Sequence Quantities

Magnitude
1
1
1
Seq. Mag. / VT ratio

Phase shift, degrees


0
30
-30
Degrees

Radians

Real

Imaginary

Vl-n

0
1
2

594.011784
0.000000
0.000000

45.682060
0.000000
0.000000

0.797302
0.000000
0.000000

415.000000
0.000000
0.000000

Vl-l

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000 0
0.000000 0
0.000000 0

0
1
2

0.000000
0.000000
0.000000
Complex 012 data

0.000000
0.000000
0.000000
*a_1

0.000000
0.000000
0.000000
*a_2

0.000000
0.000000
0.000000

0.000000 0
0.000000 0
0.000000 0
Complex ABC Data

012 to ABC conversion

Complex Format

425.000000 414.999999999999+425.000000000001i
0.000000 6.33778629463045E-13
0.000000 6.35886127663252E-13

Real

Vl-n

0
1
2

414.999999999999+425.000000000001i
AN
415+425.000000000001i
415.000000
6.33778629463045E-13 -3.16889314731522E-13+5.48868393490682E-13i
-3.16889314731522E-13-5.48868393490681E-13i
BN
414.999999999998+425.000000000001i
415.000000
6.35886127663252E-13 -3.17943063831626E-13+5.50693540470491E-13i
-3.17943063831626E-13-5.5069354047049E-13i
CN
414.999999999998+425.000000000001i
415.000000

Vl-l

0
1
2

0
0
0

0
0

0
0

AB
BC
CA

0
0
0

0
1
2

0
0
0

0
0

0
0

A
B
C

0
0
0

Imaginary

Magnitude

Degrees

Radians

425.000000
425.000000
425.000000

594.011784
594.011784
594.011784

45.682060
45.682060
45.682060

0.797302
0.797302
0.797302

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Voltage Transformer, Other than wye-wye


Transformer Effect on:
Zero Sequence
Positve sequence
Negative sequence
Secondary Sequence Quantities

18

Magnitude
0
1
1
Mag. / VT Ratio
0

0.000000

Phase shift, degrees


0
30
-30
Degrees
0.000000

Radians
0.000000

Real

Imaginary
0.000000

0.000000 0

Complex Format

12/21/2012

121410345.xls.ms_office

Vl-n

1
2

0.000000
0.000000

0.000000
0.000000

0.000000
0.000000

0.000000
0.000000

0.000000 6.33778629463045E-13
0.000000 6.35886127663252E-13

Vl-l

0
1
2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000 0
0.000000 0
0.000000 0

0
1
2

0.000000
0.000000
0.000000
Complex 012 data

0.000000
0.000000
0.000000
*a_1

0.000000
0.000000
0.000000
*a_2

0.000000
0.000000
0.000000

0.000000 0
0.000000 0
0.000000 0
Complex ABC Data

012 to ABC conversion

Real

Vl-n

0
1
2

0
6.33778629463045E-13
6.35886127663252E-13

AN
1.2696647571263E-12
0.000000
-3.16889314731522E-13+5.48868393490682E-13i
-3.16889314731522E-13-5.48868393490681E-13i
BN
-6.34832378563148E-13+1.82514697980993E-15i
0.000000
-3.17943063831626E-13+5.50693540470491E-13i
-3.17943063831626E-13-5.5069354047049E-13i
CN
-6.34832378563148E-13-1.82514697980801E-15i
0.000000

Vl-l

0
1
2

0
0
0

0
0

0
0

AB
BC
CA

0
0
0

0
1
2

0
0
0

0
0

0
0

A
B
C

0
0
0

Imaginary

Magnitude

Degrees

Radians

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Current Transformer, Wye secondary


Transformer Effect on:
Zero Sequence
Positve sequence
Negative sequence
Secondary Sequence Quantities

Magnitude
1
1
1
Seq. Mag / CT Ratio

0
1
2

0.000000
0.000000
0.000000
Complex Format 012 data

0
1
2

0
0
0

012 to ABC conversion


I

Phase shift, degrees


0
0
0
Degrees
0.000000
0.000000
0.000000
*a_1
0
0

Radians

Real

0.000000
0.000000
0.000000
*a_2

Imaginary
0.000000
0.000000
0.000000

A
B
C

0
0

0.000000 0
0.000000 0
0.000000 0
Complex ABC Data
0
0
0

Complex Format

Real
0.000000
0.000000
0.000000

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Current Transformer, DAB Secondary


Transformer Effect on:
Zero Sequence
Positve sequence
Negative sequence
Secondary Sequence Quantities

Magnitude

Phase Angle, degrees


0
0
1
30
1
-30
Seq. Mag. / CT Ratio
Degrees
0
1
2

0.000000
0.000000
0.000000
Complex 012 data

012 to ABC conversion


0
1
2

0
0
0

0.000000
0.000000
0.000000
*a_1
0
0

Radians

Real

0.000000
0.000000
0.000000
*a_2

Imaginary
0.000000
0.000000
0.000000

A
B
C

0
0

0.000000 0
0.000000 0
0.000000 0
Complex ABC Data
0
0
0

Complex Format

Real
0.000000
0.000000
0.000000

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Current Transformer, DAC Secondary


Transformer Effect on:
Zero Sequence
Positve sequence
Negative sequence
Secondary Sequence Quantities

Magnitude

Phase Angle, degrees


0
0
1
-30
1
30
Seq. Mag. / CT Ratio
Degrees
0
1
2

0.000000
0.000000
0.000000
Complex 012 data

012 to ABC conversion


0
1
2

0
0
0

Mem 1 = S = V x I*

0
0

Real
AN
BN
CN

I*

A
B
C

0
0
0

S = V x I*

A
B
C

0
0
0

Real

ABC to 012 conversion


0
0
0

Magnitude

Real
0.000000
0.000000
0.000000

Degrees

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0 0
0 0
0 0

0.000000
0.000000
0.000000

45.682060
45.682060
45.682060
Complex 012 Data

0.797302
0.797302
0.797302
Real

*a_2
0
1
2
Complex Format

Magnitude

0 0
0 0
0 0
*a_1
0
0

0
0
0

0.000000
0.000000
0.000000
Complex 012 Data

*a_2
0
1
2

0
0

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000
0
0
0

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians

0 0
0 0
0 0

Imaginary

Cmplx ABC Data / 3


A
B
C

I sum

0
0
0

Complex Format

0.797302
0.797302
0.797302

0
0

0
0
0

0.000000 0
0.000000 0
0.000000 0
Complex ABC Data

45.682060
45.682060
45.682060

0
0

A
B
C

I sum

Imaginary
0.000000
0.000000
0.000000

594.011784
594.011784
594.011784

*a_1

0
0
0

Mem 2 = Isum = I + Mem1

Complex Format
425 415+425i
425 415+425i
425 415+425i

Cmplx ABC Data / 3


AN
BN
CN

Real

A
B
C

0
0

415
415
415

ABC to 012 conversion

Radians
0.000000
0.000000
0.000000
*a_2

Imaginary

S = V x I*

0.000000
0.000000
0.000000
*a_1

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000
Real
0.000000
0.000000
0.000000

Imaginary

Magnitude

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Degrees
0.000000
0.000000
0.000000

Radians
0.000000
0.000000
0.000000

Load Flow Calculations


Given Es, Er
Magnitude
Es
Er
Z-line
Esr = Es-Er
I = Esr/Z
I*
Ss = Es x I*
Sline = dE x I*
Sr = Er x I*

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

* = conjugate in stated equations


Degrees
Radians
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Real
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Imaginary
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Complex
0
0
0
0
0.000000
0
0
0
0

Given Es, Ss
Magnitude
Es
Ss

19

0.000000
0.000000

Degrees
0.000000
0.000000

Radians
0.000000
0.000000

Real
0.000000
0.000000

Imaginary
0.000000 0
0.000000 0

Complex

12/21/2012

121410345.xls.ms_office

Z-line
I* = Ss/Es
I = (Ss/Es)*
Esr = I x Zline
Er = Es-Esr
Sline = Esr x I*
Sr = Er x I*

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0
0.000000
0
0
0
0
0

Given Es, I
Magnitude
Es
I
Zline
I*
Ss=Es x I*
Esr = I x Zline
Er = Es-Esr
Sline = Esr x I*
Sr = Er x I*

Degrees

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Radians

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Real

Imaginary

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Complex
0
0
0
0
0
0
0
0
0

Given Er, Sr
Magnitude
Er
Sr
Z-line
I* = Sr/Er
I = (Ss/Es)*
Esr = I x Zline
Es = Er+Esr
Sline = Esr x I*
Ss = Es x I*

Degrees

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Radians

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Real

Imaginary

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Complex
0
0
0
0.000000
0
0
0
0
0

Given Er, I
Magnitude
Er
I
Zline
I*
Sr=Er x I*
Esr = I x Zline
Es = Er+Esr
Sline = Esr x I*
Ss = Es x I*

Degrees

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Radians

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Real

Imaginary

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000
0.000000

Complex
0
0
0
0
0
0
0
0
0

Fault Calculations
Magnitude

Degrees

Radians

Real

Imaginary

Complex

Z0
Z1
Z2

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000 0
0.000000 0
0.000000 0

Zf
3Zf
3Zn
E prefault

0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000

Add/subtract 30 degrees for Xfmr effect


p_30
0.866025403784439+0.5i
m_30
0.866025403784439-0.5i

0
0
0
0

Three Phase Fault


Magnitude
Ztotal
Io
I1
I2

Degrees

0.000000
0.000000
0.000000
0.000000
I-012, repeated

In Fault
Io
I1
I2
Across Xfmr

0.000000
0.000000
0.000000
0.000000
*a_2

*a_1

0.000000
0.000000 0
0.000000 0
I-012, w/xfmr effects

Io
I1
I2

Radians

0.000000
0.000000
0.000000
0.000000

0
0
*a1

Imaginary

0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
Complex

A
B
C

0
0
0

A
B
C

0
0
0

*a2

0.000000
0

Real

0
0.000000 0

0
0

Complex
0
0.000000
0.000000
0.000000
Real

Complex

Imaginary

Magnitude

Degrees

Radians

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
Imaginary

0.000000
0.000000
0.000000
Magnitude

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000
Radians

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Real

A Phase to Ground
Magnitude
Ztotal
Io
I1
I2

Degrees

0.000000
0.000000
0.000000
0.000000
I-012, repeated

In Fault
Io
I1
I2
Across Xfmr

0.000000
0.000000
0.000000
0.000000
*a_2

*a_1

0.000000
0.000000 0
0.000000 0
I-012, w/xfmr effects

Io
I1
I2

Radians

0.000000
0.000000
0.000000
0.000000

0
0
*a1

Imaginary

0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
Complex

A
B
C

0
0
0

A
B
C

0
0
0

*a2

0.000000
0
0

Real

0
0

0
0

Complex
0
0.000000
0.000000
0.000000
Real

Complex

Imaginary

Magnitude

Degrees

Radians

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
Imaginary

0.000000
0.000000
0.000000
Magnitude

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000
Radians

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Real

B Phase to C Phase
Magnitude
Ztotal
Io
I1
I2

Degrees

0.000000
0.000000
0.000000
0.000000
I-012, repeated

In Fault
Io
I1
I2
Across Xfmr

0.000000
0.000000
0.000000
0.000000
*a_2

*a_1

0.000
0.000 0
0
0
I-012, w/xfmr effects

Io
I1
I2

Radians

0.000000
0.000000
0.000000
0.000000

0
0
*a1

Cell Used to check for Analysis ToolPak Installation


100+100i
100

20

Imaginary

0.000000
0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
0.000000
Complex

A
B
C

0
0
0

A
B
C

0
0
0

*a2

0.000000
0
0

Real

0
0

0
0

100

Complex

Complex
0
0.000000
0.000000
0
Real

Imaginary

Magnitude

Degrees

Radians

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000
Imaginary

0.000000
0.000000
0.000000
Magnitude

0.000000
0.000000
0.000000
Degrees

0.000000
0.000000
0.000000
Radians

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

0.000000
0.000000
0.000000

Real

12/21/2012

121410345.xls.ms_office

Vous aimerez peut-être aussi