Académique Documents
Professionnel Documents
Culture Documents
May 2013
NL series
NL453232 NL565050 4532 [1812 inch]* 5650 [2220 inch]
* Dimensions Code JIS[EIA]
(1/12)
SAFETY REMINDERS
Please pay sufficient attention to the warnings for safe designing when using these products.
REMINDERS
The storage period is less than 6 months. Be sure to follow the storage conditions (Temperature: 5 to 40C, Humidity: 10 to 75% RH or less). If the storage period elapses, the soldering of the terminal electrodes may deteriorate. Do not use or store in locations where there are conditions such as gas corrosion (salt, acid, alkali, etc.). Before soldering, be sure to preheat components. The preheating temperature should be set so that the temperature difference between the solder temperature and chip temperature does not exceed 150C. Soldering corrections after mounting should be within the range of the conditions determined in the specifications. If overheated, a short circuit, performance deterioration, or lifespan shortening may occur. When embedding a printed circuit board where a chip is mounted to a set, be sure that residual stress is not given to the chip due to the overall distortion of the printed circuit board and partial distortion such as at screw tightening portions. Self heating (temperature increase) occurs when the power is turned ON, so the tolerance should be sufficient for the set thermal design. Carefully lay out the coil for the circuit board design of the non-magnetic shield type. A malfunction may occur due to magnetic interference. Use a wrist band to discharge static electricity in your body through the grounding wire. Do not expose the products to magnets or magnetic fields. Do not use for a purpose outside of the contents regulated in the delivery specifications. The products listed on this catalog are intended for use in general electronic equipment (AV equipment, telecommunications equipment, home appliances, amusement equipment, computer equipment, personal equipment, office equipment, measurement equipment, industrial robots) under a normal operation and use condition. The products are not designed or warranted to meet the requirements of the applications listed below, whose performance and/or quality require a more stringent level of safety or reliability, or whose failure, malfunction or trouble could cause serious damage to society, person or property. If you intend to use the products in the applications listed below or if you have special requirements exceeding the range or conditions set forth in the each catalog, please contact us. (1) Aerospace/Aviation equipment (2) Transportation equipment (cars, electric trains, ships, etc.) (3) Medical equipment (4) Power-generation control equipment (5) Atomic energy-related equipment (6) Seabed equipment (7) Transportation control equipment (8) Public information-processing equipment (9) Military equipment (10) Electric heating apparatus, burning equipment (11) Disaster prevention/crime prevention equipment (12) Safety equipment (13) Other applications that are not considered general-purpose applications
When designing your equipment even for general-purpose applications, you are kindly requested to take into consideration securing protection circuit/device or providing backup circuits in your equipment.
(2/12)
S
Product compatible with RoHS directive Compatible with lead-free solders
APPLICATION
Smart meters, AV equipment, xDSL, electronic devices for communications infrastructure such as mobile base stations, industrial equipment, other
NL
Series name
453232
LWH Dimensions (mm) 453232 4.53.23.2 565050 5.65.05.0 T
T
Packaging style Taping
1R0
Inductance (H) 1R0 1 100 10 101 100 102 1000 103 10000
J
Inductance tolerance J 5%
PF
Internal code
RoHS Directive Compliant Product: See the following for more details related to RoHS Directive compliant products. http://www.tdk.co.jp/rohs/
(3/12)
T4
T: Temperature
T3
T3
T2 T1
t1
t3
t2
t: Time
Time t1 90 to 120s
(4/12)
NL series
NL453232 Type
SHAPE & DIMENSIONS
4.50.3
R0.2
3.20.2
102J
C0.5
0.5
2.60.1 (0.6)
(3.3)
(0.6)
3.20.2
Dimensions in mm
1.5
1.5
2.8
Dimensions in mm
(5/12)
NL seriesNL453232 Type
ELECTRICAL CHARACTERISTICS
CHARACTERISTICS SPECIFICATION TABLE
L (H) 1 1.2 1.5 1.8 2.2 2.7 3.3 3.9 4.7 5.6 6.8 8.2 10 12 15 18 22 27 33 39 47 56 68 82 100 120 150 180 220 270 330 390 470 560 680 820 1000
Tolerance 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
Q min. 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 50 40 40 40 40 40 40 40 40 40 30 30 30 30
L, Q measuring frequency (MHz) 7.96 7.96 7.96 7.96 7.96 7.96 7.96 7.96 7.96 7.96 7.96 7.96 2.52 2.52 2.52 2.52 2.52 2.52 2.52 2.52 2.52 2.52 2.52 2.52 0.796 0.796 0.796 0.796 0.796 0.796 0.796 0.796 0.796 0.796 0.796 0.796 0.252
DC resistance ( ) max. 0.5 0.55 0.6 0.65 0.7 0.75 0.8 0.9 1 1.1 1.2 1.4 1.6 2 2.5 2.8 3.2 3.6 4 4.5 5 5.5 6 7 8 8 9 9.5 10 12 14 16 26 30 30 35 40
Rated current (mA) max. 450 430 410 390 380 370 355 330 315 300 285 270 250 225 200 190 180 170 160 150 140 135 130 120 110 110 105 102 100 92 85 80 62 50 50 30 30
Part No. NL453232T-1R0J-PF NL453232T-1R2J-PF NL453232T-1R5J-PF NL453232T-1R8J-PF NL453232T-2R2J-PF NL453232T-2R7J-PF NL453232T-3R3J-PF NL453232T-3R9J-PF NL453232T-4R7J-PF NL453232T-5R6J-PF NL453232T-6R8J-PF NL453232T-8R2J-PF NL453232T-100J-PF NL453232T-120J-PF NL453232T-150J-PF NL453232T-180J-PF NL453232T-220J-PF NL453232T-270J-PF NL453232T-330J-PF NL453232T-390J-PF NL453232T-470J-PF NL453232T-560J-PF NL453232T-680J-PF NL453232T-820J-PF NL453232T-101J-PF NL453232T-121J-PF NL453232T-151J-PF NL453232T-181J-PF NL453232T-221J-PF NL453232T-271J-PF NL453232T-331J-PF NL453232T-391J-PF NL453232T-471J-PF NL453232T-561J-PF NL453232T-681J-PF NL453232T-821J-PF NL453232T-102J-PF
Rated current: smaller value of either Idc1 or Idc2. Idc1: When based on the inductance change rate (10% below the initial value) Idc2: When based on the temperature increase (Temperature increase of 20C by self heating)
Measurement equipment Measurement item Product No. L, Q 4194A Self-resonant frequency 8753C DC resistance VP-2941A Equivalent measurement equipment may be used.
(6/12)
NL seriesNL453232 Type
ELECTRICAL CHARACTERISTICS
L FREQUENCY CHARACTERISTICS GRAPH
100000
10000
102J
821J 681J 561J 471J 391J 331J 271J 221J 181J 820J 680J 151J 470J 8R2J 390J 330J 270J 220J 180J 150J 120J
121J
101J
1000
Inductance(H)
100
10
2R7J
0.1 0.001
0.01
0.1 Frequency(MHz)
10
100
Measurement equipment Product No. Manufacturer 4294A Agilent Technologies Equivalent measurement equipment may be used.
(7/12)
NL seriesNL453232 Type
ELECTRICAL CHARACTERISTICS
Q FREQUENCY CHARACTERISTICS GRAPH
100
90
1R5J 1R0J 2R2J 4R7J
80
1R2J
70
60
8R2J 680J 331J
50
100J 150J 271J
40
221J
30
391J 270J
20
10
0 0.001
0.01
0.1 Frequency(MHz)
10
100
Measurement equipment Product No. Manufacturer 4294A Agilent Technologies Equivalent measurement equipment may be used.
(8/12)
NL series
NL565050 Type
SHAPE & DIMENSIONS
5.60.3
472J
50.3
C1
1 (0.5) (4.6) (0.5)
50.3
40.2
Dimensions in mm
4.5
Dimensions in mm
(9/12)
NL seriesNL565050 Type
ELECTRICAL CHARACTERISTICS
CHARACTERISTICS SPECIFICATION TABLE
L (mH) 1.2 1.5 1.8 2.2 2.7 3.3 3.9 4.7 5.6 6.8 8.2 10
tolerance 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
Q min. 30 30 30 30 30 30 30 30 30 30 30 20
L, Q measuring frequency (MHz) 0.252 0.252 0.252 0.252 0.252 0.252 0.252 0.252 0.252 0.252 0.252 0.0796
Self-resonant frequency (MHz) min. 1.5 1.4 1.3 1.2 1.1 1 1 0.9 0.8 0.7 0.6 0.5
Part No. NL565050T-122J-PF NL565050T-152J-PF NL565050T-182J-PF NL565050T-222J-PF NL565050T-272J-PF NL565050T-332J-PF NL565050T-392J-PF NL565050T-472J-PF NL565050T-562J-PF NL565050T-682J-PF NL565050T-822J-PF NL565050T-103J-PF
Rated current: smaller value of either Idc1 or Idc2. Idc1: When based on the inductance change rate (10% below the initial value) Idc2: When based on the temperature increase (Temperature increase of 20C by self heating)
Measurement equipment Measurement item Product No. L, Q 4194A Self-resonant frequency 8753C DC resistance VP-2941A Equivalent measurement equipment may be used.
(10/12)
NL seriesNL565050Type
ELECTRICAL CHARACTERISTICS
L FREQUENCY CHARACTERISTICS GRAPH
100000
103J
100000
822J 392J
10000
122J
Inductance(H)
1000
100
10
1 0.001
0.01
0.1 Frequency(MHz)
10
Measurement equipment Product No. Manufacturer 4294A Agilent Technologies Equivalent measurement equipment may be used.
(11/12)
NL seriesNL565050 Type
ELECTRICAL CHARACTERISTICS
Q FREQUENCY CHARACTERISTICS GRAPH
60
50
40
562J 332J
472J 182J
30
222J
822J
272J
20
682J
152J
10
392J 122J
103J
0 0.001
0.01
0.1 Frequency(MHz)
10
Measurement equipment Product No. Manufacturer 4294A Agilent Technologies Equivalent measurement equipment may be used.
(12/12)
NL series
Packaging Style
REEL DIMENSIONS
2.0 0.5 B
A 180 180
B 17 17
C 60 60
D 13 13
E 0.5 0.5
(1.0)
Dimensions in mm
TAPE DIMENSIONS
E D0 P2 P0 P1 K
C E
A0
B0 Dimensions in mm
A0 3.6 5.4
B0 4.9 5.8
D0 1.5+0.1/-0 1.5+0.1/-0
E F P0 P1 P2 W 1.750.1 5.500.05 4.000.10 8.000.10 2.000.05 12.00.30 1.750.1 5.500.05 4.000.10 8.000.10 2.000.05 12.00.30
K 3.2 5.4
t 0.4 0.4