Académique Documents
Professionnel Documents
Culture Documents
BUSINESS SERIES
Model: SR224G
Table of Contents
Chapter 1: Introduction
Chapter 3: Installation
8 9
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 FCC Statement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Safety Notices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Industry Canada Statement . . . . . . . . . . . . . . . . . . . . . . . . . 12 Rglement dIndustry Canada . . . . . . . . . . . . . . . . . . . . . . . 12 EC Declaration of Conformity (Europe) . . . . . . . . . . . . . . . . . . 12 User Information for Consumer Products Covered by EU Directive 2002/96/EC on Waste Electric and Electronic Equipment (WEEE) . 13
21
NOTE: This
check mark indicates that there is a note of interest and is something that you should pay special attention to while using the product.
WARNING:
This exclamation point indicates that there is a caution or warning and it is something that could damage your property or product.
WEB: This
address.
Online Resources
Most web browsers allow you to enter the web address without adding the http:// in front of the address. This User Guide will refer to websites without including http:// in front of the address. Some older web browsers may require you to add it.
Resource
Linksys Linksys International Glossary Network Security
Website
www.linksys.com www.linksys.com/international www.linksys.com/glossary www.linksys.com/security
ii
Chapter 1: Introduction
Chapter 1: Introduction
The 24-Port 10/100 + 2-Port Gigabit Switch + 2 MiniGBIC
This new Linksys rack-mount switch delivers non-blocking, wire speed switching for your 10/100 Mbps network clients, plus multiple options for connecting to your network backbone. Twenty-four 10/100 ports wire-up your workstations, while the integrated 10/100/1000 ports or miniGBIC ports connect to your servers or backbone at Gigabit speeds. The SR224G incorporates non-blocking, wire-speed architecture that forwards packets as fast as your network can deliver them. It features broadcast storm suppression that maximizes the system availability. Also included are Address Learning and Aging function to prevent data transfer errors and Data Flow Control to help prevent packet loss. All ports have automatic MDI/MDI-X crossover detection, so you dont have to worry about the cable type. Each port independently and automatically negotiates for best speed and whether to run in half- or full-duplex mode. Head-of-line blocking prevention keeps your highspeed clients from bogging down in lower-speed traffic and fast storeand-forward switching prevents damaged packets from being passed on into the network. No matter how intensive your network demands, the Linksys 24-Port 10/100 + 2-Port Gigabit Switch + 2 MiniGBIC has speed, flexibility, and reliability that you can count on.
Chapter 1: Introduction
Features
Ideal for integrating your 10 Mbps and 100 Mbps network hardware 24 10/100 Ports provide dedicated bandwidth in Half or Full-Duplex modes 2 Gigabit Ethernet ports and 2 shared miniGBIC slots for Gigabit Fiber expansion Each port supports Auto MDI/MDI-X cable detection Compatible with all major network operating systems Advanced store-and-forward packet switching optimizes data transfers Auto partitioning protects PCs from downed network lines Signal regeneration ensures data transfer integrity
Front Panel
LEDs
System (Green) This LED lights up and remains lit when the Switch is powered on. 1-24 (Green) Each LED lights up when a connection is made through its corresponding port. It flashes when the corresponding port is active. Gigabit/miniGBIC 1-2 (Green) The Gigabit/miniGBIC LED lights up when a connection is made through the corresponding Gigabit port. It flashes when the corresponding port is active.
Ports
1-24 These ports connect the Switch to network devices, such as computers. Gigabit 1-2 The Gigabit RJ-45 ports support 10/100/1000 Mbps connections and are connection points for network devices such as Gigabit servers. Each Gigabit RJ45 port is paired with a miniGBIC port. If a miniGBIC module is present, the corresponding 10/100/1000 RJ-45 port will be disabled. MiniGBIC 1-2 The two miniGBIC (Gigabit interface converter) ports are connection points for miniGBIC modules, so the Switch can uplink via fiber to another switch or two. The miniGBIC ports are compatible with the MGBSX1, MGBLH1, and MGBT1 only.
24-Port 10/100 + 2-Port Gigabit Switch + 2 MiniGBIC
Back Panel
The power port is located on the back panel of the Switch.
Back Panel
Power The power port is where you will connect the included power cord.
Side Panel
The security slot is located on the side panel of the Switch.
Security slot The security slot is where you can attach a lock to protect the Switch from theft.
Placement Options
There are two ways to physically install the Switch:
Set the Switch on its four rubber feet. Mount the Switch in a standard rack (1U high).
Rack-Mount
To rack-mount the Switch, follow these instructions: 1 The Switch has four mounting holes on each side. Screw an included mounting bracket into each side.
Lift the Switch into the rack, and secure the brackets with additional screws (not included).
Connect to Rack
Chapter 3: Installation
Chapter 3: Installation
Overview
This chapter will explain how to connect network devices to the Switch. The application diagram shown here is an example of a typical network configuration.
Cable/DSL Modem Wireless Access Point
Internet
Router
Desktop
Notebook
Server
Application Diagram
When you connect your network devices, make sure you dont exceed the maximum cabling distance of 100 meters (328 feet).
Chapter 3: Installation
Connection Instructions
1 2 Make sure all of the devices you will connect to the Switch are powered off. Connect a Category 5 Ethernet network cable to one of the numbered ports on the Switch.
3 4 5
Connect the other end of the Ethernet network cable to a computer or other network device. Repeat steps 2 and 3 to connect additional devices. If you are using a Gigabit port, connect a Category 5e network cable to a Gigabit port on the Switch, and connect the other end to a Gigabit server or other network device. If you are using a miniGBIC port, then connect a miniGBIC module to a miniGBIC port. For detailed instructions, refer to the modules documentation. NOTE: The miniGBIC ports are compatible with the MGBSX1, MGBLH1, and MGBT1.
7 8
Connect the supplied power cord to the Switchs power port. Plug the other end of the adapter into an electrical outlet. Power on the devices connected to the Switch. Each active ports corresponding LED will light up on the Switch. Congratulations! The installation of the Switch is complete.
Appendix A: Specifications
Appendix A: Specifications
Model Standards Ports Cabling Type LEDs Security Feature Dimensions WxHxD Unit Weight Power Certification Operating Temp. Storage Temp. Operating Humidity SR224G IEEE 802.3, 802.3u, 802.3x, 802.3ab 24 10/100 Ports, 2 10/100/1000 Ports, and 2 Shared MiniGBIC Ports Category 5, and Multi-Mode fiber 1310 nm, and 850 nm Supported System, 1-24, Gigabit/miniGBIC 1-2 Security Slot 17.01" x 1.75" x 8.20" (432 x 44.5 x 208 mm) 6.17 lb (2.8 kg) 110-120V AC, 30W FCC Class B, CE 32 to 104F (0 to 40C) -40 to 158F (-40 to 70C) 20% to 95% Relative Humidity, Noncondensing
This warranty does not apply if the Product (a) has been altered, except by Linksys, (b) has not been installed, operated, repaired, or maintained in accordance with instructions supplied by Linksys, or (c) has been subjected to abnormal physical or electrical stress, misuse, negligence, or accident. In addition, due to the continual development of new techniques for intruding upon and attacking networks, Linksys does not warrant that the Product will be free of vulnerability to intrusion or attack. TO THE EXTENT NOT PROHIBITED BY LAW, IN NO EVENT WILL LINKSYS BE LIABLE FOR ANY LOST DATA, REVENUE OR PROFIT, OR FOR SPECIAL, INDIRECT, CONSEQUENTIAL, INCIDENTAL OR PUNITIVE DAMAGES, REGARDLESS OF THE THEORY OF LIABILITY (INCLUDING NEGLIGENCE), ARISING OUT OF OR RELATED TO THE USE OF OR INABILITY TO USE THE PRODUCT (INCLUDING ANY SOFTWARE), EVEN IF LINKSYS HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. IN NO EVENT WILL LINKSYS LIABILITY EXCEED THE AMOUNT PAID BY YOU FOR THE PRODUCT. The foregoing limitations will apply even if any warranty or remedy provided under this Agreement fails of its essential purpose. Some jurisdictions do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to You. Please direct all inquiries to: Linksys, P.O. Box 18558, Irvine, CA 92623.
10
FCC Statement
This product has been tested and complies with the specifications for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used according to the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which is found by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:
Reorient or relocate the receiving antenna Increase the separation between the equipment or devices Connect the equipment to an outlet other than the receivers Consult a dealer or an experienced radio/TV technician for assistance
Safety Notices
Caution: To reduce the risk of fire, use only No.26 AWG or larger telecommunication line cord. Do not use this product near water, for example, in a wet basement or near a swimming pool. Avoid using this product during an electrical storm. There may be a remote risk of electric shock from lightning.
11
12
User Information for Consumer Products Covered by EU Directive 2002/96/EC on Waste Electric and Electronic Equipment (WEEE)
This document contains important information for users with regards to the proper disposal and recycling of Linksys products. Consumers are required to comply with this notice for all electronic products bearing the following symbol:
(Bulgarian) -
2002/96/EC , / , . , . . . - , , .
13
Cetina (Czech) - Informace o ochran ivotnho prosted pro zkaznky v zemch Evropsk unie
Evropsk smrnice 2002/96/ES zakazuje, aby zazen oznaen tmto symbolem na produktu anebo na obalu bylo likvidovno s netdnm komunlnm odpadem. Tento symbol udv, e dan produkt mus bt likvidovn oddlen od bnho komunlnho odpadu. Odpovdte za likvidaci tohoto produktu a dalch elektrickch a elektronickch zazen prostednictvm urench sbrnch mst stanovench vldou nebo mstnmi ady. Sprvn likvidace a recyklace pomh pedchzet potencilnm negativnm dopadm na ivotn prosted a lidsk zdrav. Podrobnj informace o likvidaci starho vybaven si laskav vydejte od mstnch ad, podniku zabvajcho se likvidac komunlnch odpad nebo obchodu, kde jste produkt zakoupili.
14
(Greek) -
2002/96/EC / . . . . , , .
15
Italiano (Italian) - Informazioni relative allambiente per i clienti residenti nellUnione Europea
La direttiva europea 2002/96/EC richiede che le apparecchiature contrassegnate con questo simbolo sul prodotto e/o sullimballaggio non siano smaltite insieme ai rifiuti urbani non differenziati. Il simbolo indica che questo prodotto non deve essere smaltito insieme ai normali rifiuti domestici. responsabilit del proprietario smaltire sia questi prodotti sia le altre apparecchiature elettriche ed elettroniche mediante le specifiche strutture di raccolta indicate dal governo o dagli enti pubblici locali. Il corretto smaltimento ed il riciclaggio aiuteranno a prevenire conseguenze potenzialmente negative per lambiente e per la salute dellessere umano. Per ricevere informazioni pi dettagliate circa lo smaltimento delle vecchie apparecchiature in Vostro possesso, Vi invitiamo a contattare gli enti pubblici di competenza, il servizio di smaltimento rifiuti o il negozio nel quale avete acquistato il prodotto.
16
17
Polski (Polish) - Informacja dla klientw w Unii Europejskiej o przepisach dotyczcych ochrony rodowiska
Dyrektywa Europejska 2002/96/EC wymaga, aby sprzt oznaczony symbolem znajdujcym si na produkcie i/lub jego opakowaniu nie by wyrzucany razem z innymi niesortowanymi odpadami komunalnymi. Symbol ten wskazuje, e produkt nie powinien by usuwany razem ze zwykymi odpadami z gospodarstw domowych. Na Pastwu spoczywa obowizek wyrzucania tego i innych urzdze elektrycznych oraz elektronicznych w punktach odbioru wyznaczonych przez wadze krajowe lub lokalne. Pozbywanie si sprztu we waciwy sposb i jego recykling pomog zapobiec potencjalnie negatywnym konsekwencjom dla rodowiska i zdrowia ludzkiego. W celu uzyskania szczegowych informacji o usuwaniu starego sprztu, prosimy zwrci si do lokalnych wadz, sub oczyszczania miasta lub sklepu, w ktrym produkt zosta nabyty.
18
Slovenina (Slovak) - Informcie o ochrane ivotnho prostredia pre zkaznkov v Eurpskej nii
Poda eurpskej smernice 2002/96/ES zariadenie s tmto symbolom na produkte a/alebo jeho balen nesmie by likvidovan spolu s netriedenm komunlnym odpadom. Symbol znamen, e produkt by sa mal likvidova oddelene od benho odpadu z domcnost. Je vaou povinnosou likvidova toto i ostatn elektrick a elektronick zariadenia prostrednctvom pecializovanch zbernch zariaden urench vldou alebo miestnymi orgnmi. Sprvna likvidcia a recyklcia pome zabrni prpadnm negatvnym dopadom na ivotn prostredie a zdravie ud. Ak mte zujem o podrobnejie informcie o likvidcii starho zariadenia, obrte sa, prosm, na miestne orgny, organizcie zaoberajce sa likvidciou odpadov alebo obchod, v ktorom ste si produkt zakpili.
19
20
NOTE: Details on warranty and RMA issues can be found in the Warranty and Regulatory Information section of this Guide.
21
Notes
7032710NC-RR
22
www.linksys.com