Académique Documents
Professionnel Documents
Culture Documents
1. Ensure that the machines key switch is in the ON position. 2. Disconnect the 4-pin power connector on the ECM for 30 seconds.
4. In the Insite software, ensure that the connection type is set to Inline II, Auto Detect, COM1 (displayed in lower right corner).
5. Click on Connect to ECM from the left column. Insite should ECM is ROM booted will display.
establish communication with the ECM and error code 5080 The
-1-
11.
password. Provide the following information when contacting ASIST: a. ECM serial number b. PCID c. Requested ECM code d. Machine model e. Machine serial number
-2-
13.
display.
14.
-3-
clicking [OK].
15.
16.
Note: The calibration has not failed; the download is complete at 99% and has transferred successfully. At this point the Insite software tries to power and keyed power when the ECM is reset and will say that the the ON position. reset the ECM and perform validation. The ECM requires both constant download has failed because it cant perform validation without the key in
17.
18.
-4-
19.
Note: Steps 19 & 20 require no waiting. Simply click [Next] and [Finish] as the screens appear.
wizard.
Click the [Finish] button to close the ECM calibration download Turn the tractor key switch to the ON position and click on Verify the software has been loaded successfully by going to
Connect to ECM.
Features and Parameters > System ID and Dataplate > Calibration Information > ECM code.
-5-