Académique Documents
Professionnel Documents
Culture Documents
Text Book: Engineering Drawing (6th Ed) by Albert Boundy, 2001 Workbook:Engineering Drawing 111 by D. Quiblat References: Engineering Drawing and Design (6th ed.) by Jensen, 2002 : Engineering Graphics (1st Ed) by Muralidhara, Jagannath and Sathyanarayanaswawy, 2001 : Autocad 2004 Companion (2nd Ed) by Glencoe, 2004 SUBJECT MATTER Introduction to Engineering Drawing OBJECTIVES Familiarization on different drawing instrument, their usage and necessity in engineering drawing TEACHER'S ACTIVITY Class Discussion STUDENT'S ACTIVITY Label the parts of the instrument and analyze its uses EVALUATION TIME ALLOTMENT Week 1 June 14 - 19
Plate No. 1
Class Discussion
Vertical letters & Numerals (Pencil) Lettering Incline letters and Numerals (Pencil)
Week 2 June 21 - 28
Plate No. 2
Develop more techniques in incline letters and numerals (pencils) by using Pencil Develop more techniques in lettering using tech. ink
Class Discussion
Class Discussion
Plate No.3
Week 4 July 6 - 12
Plate no.4
Develop more techniques in incline letters and numerals (pencil) by using tech. ink lettering and numerals Open Week
Quiz
Preliminary Examination Week 7 (July 26 - 31) OBJECTIVES TEACHER'S STUDENT'S ACTIVITY ACTIVITY Develop more techniques in Class Discussion Geometric Figures drafting thru the use of basic drawing and use of compass To draw the three views of the beam support and switch base To draw and learn the top, front left and right side view of latch bracket To draft the given views completing the top view from information given on the front and side views Class Discussion Orthographic Projection 1
Plate no. 6
Plate no. 7
Class Discussion
Orthographic Projection 2
Week 10 Aug 24 - 29
Plate no. 8
Class Discussion
Plate no. 9
Plate no. 10
MIDTERM EXAMINATION Week 13 (Sept 6 - 11) To draft the given views Class Discussion Orthographic completing the top view from Reading 2 information given on the front and side views To draft the front, and the true Class Discussion Auxiliary view top view ( Revolved on the
Week 14 Sept 13 - 18
Week 15 Sept. 20 - 25
horizontal axis) Plate no. 11 To draw the three views of the object in the simplest: Position 1 about an axis to horizontal 15 deg. Position 2 About an axis to revolve 45 deg. Position 3 about an axis to revolve 30 deg. To draw the top view and make the front and two side views in section on cutting planes Class Discussion Revolution Sectional Views Draw the figure given Week 16 Sept. 27 - Oct. 2
Plate no. 12
Class Discussion
Sectional views
Week 17 Oct. 4 - 9
Final Examination - Week 18 (Oct. 11 - 16) Prepared by: Engr. Tomas U. Ganiron Jr, MSCE Date: 8 / 30 /04