Vous êtes sur la page 1sur 84

PURPOSE MASS AND BALANCE Question 1 of 36

1Number: 804

2. 3. low gross mass and forward centre of gravity. 4. high gross mass and aft centre of gravity. Flag this question

Question 2 of 36
Number: 805

2. 3. A decrease of the stalling speed. 4. A decrease in the landing speed. Flag this question

Question 3 of 36
Number: 1066 Question: If nose wheel moves aft during gear retraction, how will this movement affect the location of the centre of gravity (cg) on the aircraft?

1.

2. 3. The cg location will change, but the direction cannot be told the information given. 4. It will not affect the cg location. Flag this question

Question 4 of 36
Number: 2695 Question: At maximum certificated take-off mass an aeroplane departs from an airfield which is not limiting for either take-off or landing masses. During initial climb the number one engine suffers a contained disintegration. An emergency is declared and the aeroplane returns to departure airfield for an immediate landing. The most likely result of this action will be

2.

3. 4. a high threshold speed and a shorter stop distance. Flag this question

Question 5 of 36
Number: 13080

2. allowed take off mass and basic empty mass. 3. operating mass and basic empty mass. 4. allowed take off mass and basic empty mass plus trip fuel. Flag this question

Question 6 of 36
Number: 13460

2. increase longitudinal static stability 3. not change the manoeuvrability 4. have no effect on longitudinal static stability Flag this question

Question 7 of 36
Number: 2051

2. 3. The dihedral, angle of sweepback and the keel effect. 4. The relationship of thrust and lift to weight and drag. Flag this question

Question 8 of 36
Number: 2077 Question: Assuming gross mass, altitude and airspeed remain unchanged, movement of the centre of gravity from the forward to the aft limit will cause

1. 2. reduced maximum cruise range. 3.

4. Flag this question

Question 9 of 36
Number: 4376 Question: Which of the following statements is correct?

2. The centre of gravity is given in percent of MAC calculated from the leading edge of the wing, where MAC always = the wing chord halfway between the centre line of the fuselage and the wing tip 3. The station (STA) is always the location of the centre of gravity in relation to a reference point, normally the leading edge of the wing at MAC

Flag this question

Question 10 of 36
Number: 4377 Question: Which of the following statements is correct?

2. If the actual centre of gravity is located behind the aft limit of centre of gravity it is possible that the aeroplane will be unstable, making it necessary to increase elevator forces 3. A tail heavy aeroplane is less stable and stalls at a lower speed than a nose heavy aeroplane

4. The lowest stalling speed is obtained if the actual centre of gravity is located in the middle between the aft and forward limit of centre of gravity Flag this question

Question 11 of 36
Number: 4378

2. The Maximum Zero Fuel Mass ensures that the centre of gravity remains within limits after the uplift of fuel. 3. The Basic Empty Mass is equal to the mass of the aeroplane excluding traffic load and useable fuel but including the crew.

Flag this question

Question 12 of 36
Number: 4564

3. Stalling speeds will be lower. 4. Gradient of climb for a given power setting will be higher. Flag this question

Question 13 of 36
Number: 4565

2. be decreased, drag will decrease and endurance will increase. 3. remain constant, drag will increase and endurance will increase. 4. remain constant, drag will decrease and endurance will decrease. Flag this question

Question 14 of 36
Number: 4570 Question: Which of the following is most likely to affect the range of centre of gravity positions on an

2.

3. 4. Location of the undercarriage. Flag this question

Question 15 of 36
Number: 4484

Question: Prior to departure an aircraft is loaded with 16500 litres of fuel at a fuel density of 780 kg/m. This is entered into the load sheet as 16500 kg and calculations are carried out accordingly. As a result of

2. lighter than anticipated and the calculated safety speeds will be too low 3. heavier than anticipated and the calculated safety speeds will be too low. 4. heavier than anticipated and the calculated safety speeds will be too high Flag this question

Question 16 of 36
Number: 4485 Question: An additional baggage container is loaded into the aft cargo compartment but is not entered into

2. are unaffected but V1 will be increased. 3. will not be achieved. 4. will be greater than required. Flag this question

Question 17 of 36
Number: 4486 Question: Fuel loaded onto an aeroplane is 15400 kg but is erroneously entered into the load and trim sheet

2. V1 will be reached sooner than expected 3.

4. Flag this question

Question 18 of 36
Number: 4503 Question: During take-off you notice that, for a given elevator input, the aeroplane rotates much more

2. the centre of gravity is too far forward. 3.

4.

Flag this question

Question 19 of 36
Number: 4507

2. tend to over rotate during take-off. 3.

4. Flag this question

Question 20 of 36
Number: 4508

2.

3. 4. be totally unrelated to the position of the centre of gravity. Flag this question

Question 21 of 36
Number: 4511

2. extremely stable and require small elevator control to change pitch. 3. extremely unstable and require small elevator control to change pitch. 4. extremely unstable and require excessive elevator control to change pitch. Flag this question

Question 22 of 36
Number: 4512

2. become lighter making the aeroplane more difficult to manouevre in pitch. 3. become lighter making the aeroplane more easy to manouevre in pitch. 4. become heavier making the aeroplane more easy to manouevre in pitch. Flag this question

Question 23 of 36

Number: 4513

2.

3. 4. a reduced fuel consumption as a result of reduced drag. Flag this question

Question 24 of 36
Number: 4515 Question: A flight benefits from a strong tail wind which was not forecast. On arrival at destination a straight in approach and immediate landing clearance is given. The landing mass will be higher than planned and

1.

2. 3. the approach path will be steeper. 4. the landing distance will be unaffected. Flag this question

Question 25 of 36
Number: 5459 Question: The mass displacement caused by landing gear extension: 1. creates a longitudinal moment in the direction (pitch-up or pitch-down) determined by the type of

2. creates a pitch-down longitudinal moment 3. creates a pitch-up longitudinal moment 4. does not create a longitudinal moment Flag this question

Question 26 of 36
Number: 5477 Question: During a violent avoidance manoeuvre, a light twin aircraft, certified to FAR 23 requirements was subjected to an instantaneous load factor of 4.2. The Flight Manual specifies that the aircraft is certified in the normal category for a load factor of -1.9 +3.8. Considering the certification requirements and taking into account that the manufacturer of the twin did not include, during its conception, a supplementary

2. no distortion, permanent or temporary of the structure

3. 4. a elastic deformation whilst the load was applied, but no permanent distortion Flag this question

Question 27 of 36
Number: 6117 Question: Due to a mistake in the load sheet the aeroplane is 100kg heavier than you believe it to be. As a consequence:

1. V VMU VR will all occur earlier.

2. 3. VR will be higher. 4. V will be higher.

Flag this question

Question 28 of 36
Number: 6118

2.

3. 4. Stay the same. Flag this question

Question 29 of 36
Number: 6119

2. May only be moved if permitted by the regulating authority and endorsed in the aeroplane's certificate of airworthiness. 3. Is in a fixed position and is unaffected by aeroplane loading. 4. Must be maintained in a fixed position by careful distribution of the load. Flag this question

Question 30 of 36
Number: 6120

2. The CAA 3.

4. Flag this question

Question 31 of 36
Number: 6121

3. Lower stick forces per G loading. 4. Lower stalling speed. Flag this question

Question 32 of 36
Number: 6122

2. Improvement in nose wheel steering. 3. No likelihood of a nose up overbalance on a nose wheel aircraft on the ground resulting in tail damage. 4. Higher stick forces per G loading with no risk of over-stressing the airframe in manoeuvres. Flag this question

Question 33 of 36
Number: 6123 Question: Just prior to take-off, a baggage handler put a large put a large extra bag into the forward hold without recording it in the LMC's. What are the effects of this action? 1. VMC will increase if the extra load is forward of the datum. 2. Stick forces in flight will decrease if the extra load is behind the datum. 3. Stick

2. all of the above

3. 4. 2,3 and 4 only Flag this question

Question 34 of 36
Number: 6124

2. Fuel usage. 3. Cabin crewmembers performing their normal duties. 4. Mass added or removed at the neutral point. Flag this question

Question 35 of 36
Number: 6125

2. Marginal increase 3. No effect 4. Increases Flag this question

Question 36 of 36
Number: 7297

2. Does not influence longitudinal static stability. 3.

4. Flag this question 2-

LOADING

Question 1 of 136
Number: 296 Question: The take-off mass of an aeroplane is 117 000 kg, comprising a traffic load of 18 000 kg and fuel of 46 000 kg. What is the dry operating mass?

1.

2. 3. 99 000 kg 4. 71 000 kg Flag this question

Question 2 of 136
Number: 299

2. fuel and passengers baggage and cargo.

4. unusable fuel and reserve fuel. Flag this question

Question 3 of 136
Number: 290 Question: Given: Dry Operating Mass= 29 800 kg, Maximum Take-Off Mass= 52 400 kg, Maximum ZeroFuel Mass= 43 100 kg, Maximum Landing Mass= 46 700 kg, Trip fuel= 4 000 kg, Fuel quantity at brakes release= 8 000 kg. The maximum traffic load is:

1. 2. 14 600 kg 3. 9 300 kg 4. 13 300 kg Flag this question

Question 4 of 136
Number: 807 Question: Given the following : - Maximum structural take-off mass 48 000 kg - Maximum structural landing mass: 44 000 kg - Maximum zero fuel mass: 36 000 kg -Taxi fuel: 600 kg -Contingency fuel: 900 kg -Alternate fuel: 800 kg -Final reserve fuel: 1 100 kg -Trip fuel: 9 000 kg. The actual TOM can never be

2. 48 400 kg 3. 48 000 kg

4. Flag this question

Question 5 of 136
Number: 1065 Question: The maximum zero-fuel mass: 1- is a regulatory limitation 2- is calculated for a maximum load factor of +3.5 g 3- is based on the maximum permissible bending moment at the wing root 4- is defined on the assumption that fuel is consumed from the outer wings tank first 5- is defined on the assumption that fuel is consumed from the centre wing tank first 6- can be increased by stiffening the wing The combination of

2. 2, 3, 6 3.

4. Flag this question

Question 6 of 136
Number: 1067 Question: At the flight preparation stage, the following parameters in particular are available for

2. The Operating Mass includes the traffic load. 3. The Operating Mass is the mass of the aircraft without take-off fuel. 4. The Dry Operating Mass includes take-off fuel. Flag this question

Question 7 of 136
Number: 1068

2. Operating mass plus luggage of passengers and cargo. 3.

4. Flag this question

Question 8 of 136
Number: 1069

Question: Given that: - Maximum structural take-off mass: 146 000 kg, - Maximum structural landing mass: 93 900 kg, - Maximum zero fuel mass: 86 300 kg, - Trip fuel: 27 000 kg, - Taxi fuel: 1 000 kg, Contingency fuel: 1350 kg, - Alternate fuel: 2650 kg, - Final reserve fuel: 3000 kg, Determine the actual

2. 146 000 kg. 3.

4. Flag this question

Question 9 of 136
Number: 1070

3. variable equipment for the flight. 4. Maximum Structural Take-Off Mass. Flag this question

Question 10 of 136
Number: 1071 Question: Given are:- Maximum structural take-off mass: 72 000 kg, - Maximum structural landing mass: 56 000 kg, - Maximum zero fuel mass: 48 000 kg, - Taxi fuel: 800 kg, - Trip fuel: 18 000 kg, - Contingency fuel: 900 kg, - Alternate fuel: 700 kg, - Final reserve fuel: 2 000 kg. The actual take-off mass can never be

2. 70 400 kg 3. 72 000 kg

4. Flag this question

Question 11 of 136
Number: 1088

2. It is dry operating mass minus fuel load.

3.

4. Flag this question

Question 12 of 136
Number: 2678 Question: Given an aeroplane with: Maximum Structural Landing Mass: 125000 kg Maximum Zero Fuel Mass: 108500 kg Maximum Structural Take-off Mass: 155000 kg Dry Operating Mass: 82000 kg Scheduled trip fuel is 17000 kg and the reserve fuel is 5000 kg. Assuming performance limitations are not restricting,

2. 130500 kg and 31500 kg 3. 125500 kg and 26500 kg 4. 125500 kg and 21500 kg Flag this question

Question 13 of 136
Number: 2679 Question: For the purpose of completing the Mass and Balance documentation, the Traffic Load is

2. plus the Operating Mass. 3.

4. Flag this question

Question 14 of 136
Number: 2680 Question: For the purpose of completing the Mass and Balance documentation, the Operating Mass is

2.

3. 4. Trip Fuel Mass. Flag this question

Question 15 of 136
Number: 2681

Question: When establishing the mass breakdown of an aeroplane, the empty mass is defined as the sum of the:

2. basic mass plus special equipment mass 3. basic mass plus variable equipment mass 4. empty mass dry plus variable equipment mass Flag this question

Question 16 of 136
Number: 2682 Question: For the purpose of completing the Mass and Balance documentation, the Dry Operating Mass is defined as:

2. The total mass of the aircraft ready for a specific type of operation excluding crew and crew baggage. 3. The total mass of the aircraft ready for a specific type of operation excluding all usable fuel. 4. The total mass of the aircraft ready for a specific type of operation excluding all traffic load. Flag this question

Question 17 of 136
Number: 2686 Question: An aeroplane's weighing schedule indicates that the empty mass is 57320 kg. The nominal Dry Operating Mass is 60120 kg and the Maximum Zero Fuel Mass is given as 72100 kg. Which of the following is a correct statement in relation to this aeroplane?

2. operational items have a mass of 2800 kg and the maximum useful load is 14780 kg. 3. operational items have a mass of 2800 kg and the maximum traffic load for this aeroplane is 14780 kg. 4. operational items have a mass of 2800 kg and the maximum useful load is 11980 kg. Flag this question

Question 18 of 136
Number: 2687 Question: An aeroplane is to depart from an airfield where the performance limited take-off mass is 89200 kg. Certificated maximum masses are as follows: Ramp (taxi) mass- 89930 kg, Maximum Take-off mass89430 kg, MaximumLanding mass- 71520 kg, Actual Zero fuel mass- 62050 kg, Fuel on board at ramp: Taxi fuel- 600 kg, Trip fuel- 17830 kg, Contingency, final reserve and alternate -9030 kg. If the Dry Operating

2. 21220 kg

3. 4. 21500 kg Flag this question

Question 19 of 136
Number: 2688 Question: The empty mass of an aeroplane, as given in the weighing schedule, is 61300 kg. The operational items (including crew) is given as a mass of 2300 kg. If the take-off mass is 132000 kg (including a useable

2. 26900 kg. 3. 70700 kg 4. 29600 kg Flag this question

Question 20 of 136
Number: 2689 Question: The following data applies to an aeroplane which is about to take off: Certified maximum takeoff mass - 141500 kg Performance limited take-off mass - 137300 kg Dry Operating Mass - 58400 kg Crew and crew hand baggage mass - 640 kg Crew baggage in hold - 110 kg Fuel on board - 60700 kg From this

2.

3. 4. 18200 kg Flag this question

Question 21 of 136
Number: 2690 Question: A revenue flight is to be made by a jet transport. The following are the aeroplane's structural limits: -Maximum Ramp Mass: 69 900 kg, -Maximum Take Off Mass: 69 300 kg, Maximum Landing Mass: 58 900 kg, Maximum Zero Fuel Mass: 52 740 kg. The performance limited take off mass is 67 450kg and the performance limited landing mass is 55 470 kg. Dry Operating Mass: 34 900 kg. Trip Fuel: 6 200 kg. Taxi Fuel: 250 kg. Contingency & final reserve fuel:1 300 kg. Alternate Fuel: 1 100 kg. The maximum

2. 19 100 kg 3. 19 500 kg 4. 19 200 kg Flag this question

Question 22 of 136
Number: 2691 Question: A revenue flight is to be made by a jet transport. The following are the aeroplane's structural limits: -Maximum Ramp Mass: 69 900 kg, -Maximum Take Off Mass: 69 300 kg, Maximum Landing Mass: 58 900 kg, Maximum Zero Fuel Mass: 52 740 kg. Take Off and Landing mass are not performance limited. Dry Operating Mass: 34 930 kg Trip Fuel: 11 500 kg Taxi Fuel: 250 kg Contingency & final reserve fuel: 1

2.

3. 4. 21 070 kg Flag this question

Question 23 of 136
Number: 2692 Question: A revenue flight is to be made by a jet transport. The following are the aeroplane's structural limits: -Maximum Ramp Mass: 69 900 kg, -Maximum Take Off Mass: 69 300 kg, Maximum Landing Mass: 58 900 kg, Maximum Zero Fuel Mass: 52 740 kg Take Off and Landing mass are not performance limited. Dry Operating Mass: 34 900 kg Trip Fuel: 11 800 kg Taxi Fuel: 500 kg Contingency & final reserve fuel: 1

3. 19 100 kg 4. 19 200 kg Flag this question

Question 24 of 136
Number: 2693 Question: At reference or see Loading Manual MRJT 1 Figure 4.14. The medium range twin jet transport is scheduled to operate from a departure airfield where conditions limit the take-off mass to 65050 kg. The destination airfield has a performance limited landing mass of 54500 kg. The Dry Operating Mass is 34900 kg. Loading data is as follows - Taxi fuel 350 kg Trip fuel 9250 kg Contingency and final reserve fuel 1100 kg Alternate fuel 1000 kg Traffic load 18600 kg Check the load and ensure that the flight may be operated without exceeding any of the aeroplane limits. Choose, from those given below, the most appropriate

3. The flight is 'zero fuel mass' limited and the traffic load must be reduced to 14170 kg.

4. The flight may be safely operated with the stated traffic and fuel load.

Question 25 of 136
Number: 2694 Question: The following data is extracted from an aeroplane's loading manifest: Performance limited takeoff mass 93500 kg Expected landing mass at destination 81700 kg Maximum certificated landing mass 86300 kg Fuel on board 16500 kg During the flight a diversion is made to an en-route alternate which is not 'performance limited' for landing. Fuel remaining at landing is 10300 kg. The landing mass

2. is 87300 kg which is acceptable in this case because this is a diversion and not a normal scheduled landing. 3.

4. Flag this question

Question 26 of 136
Number: 2670 Question: With respect to aeroplane loading in the planning phase, which of the following statements is always correct ? LM = Landing Mass TOM = Take-off Mass MTOM = Maximum Take-off Mass ZFM = Zero Fuel Mass MZFM = Maximum Zero Fuel Mass DOM = Dry Operating Mass

1. 2. Reserve Fuel = TOM - Trip Fuel 3.

4. Flag this question

Question 27 of 136
Number: 13048 Question: Considering only structural limitations, on very short legs with minimum take-off fuel, the traffic

3. Maximum Take-off Mass. 4. Maximum Landing Mass. Flag this question

Question 28 of 136
Number: 13535

2. The total mass of passengers, baggage, cargo and usable fuel 3.

4. Flag this question

Question 29 of 136
Number: 13521 Question: Which of the following statements is correct?

2. The Maximum Zero Fuel Mass ensures that the centre of gravity remains within limits after the uplift of fuel.

4. The Maximum Take-off Mass is equal to the maximum mass when leaving the ramp. Flag this question

Question 30 of 136
Number: 13434

2.

3. 4. a take-off limiting mass which is affected by the aerodrome altitude and temperature Flag this question

Question 31 of 136
Number: 1962

2. Dry Operating Mass minus the variable load. 3. Take-off Mass minus Zero Fuel Mass.

4. Flag this question

Question 32 of 136
Number: 1943 Question: Considering only structural limitations, on long distance flights (at the aeroplane's maximum

2. The Maximum Zero Fuel Mass plus the Take-off Mass. 3.

4. Flag this question

Question 33 of 136
Number: 1944

2. the Maximum Take-off Mass minus the take-off fuel mass. 3.

4. Flag this question

Question 34 of 136
Number: 1945 Question: Given: Maximum structural take-off mass= 146 900 kg, Maximum structural landing mass= 93 800 kg, Maximum zero fuel mass= 86 400 kg, Trip fuel= 27 500 kg, Block fuel= 35 500 kg Engine starting

2. 120 300 kg 3.

4. Flag this question

Question 35 of 136
Number: 2078

Question: While making mass and balance calculation for a particular aircraft, the term 'Basic Empty Mass'

3. all the oil and fuel. 4. all the consumable fuel and oil, but not including any radio or navigation equipment installed by manufacturer. Flag this question

Question 36 of 136
Number: 2079 Question: The term 'Maximum Zero Fuel Mass' consist of:

1. 2. The maximum mass authorized for a certain aeroplane not including the fuel load and operational

4. The maximum mass authorized for a certain aeroplane not including traffic load and fuel load. Flag this question

Question 37 of 136
Number: 2080

3. Operating Mass plus all the traffic load. 4. Basic Empty Mass plus the fuel loaded. Flag this question

Question 38 of 136
Number: 2081

2. Dry Operating Mass plus the take-off fuel 3. Actual Landing Mass plus the take-off fuel

4. Flag this question

Question 39 of 136
Number: 3666

2. the sum of the Maximum Zero Fuel Mass and the trip fuel. 3.

4. Flag this question

Question 40 of 136
Number: 3667

2. allowed take off mass and basic mass plus trip fuel 3. allowed take off mass and basic mass 4. operating mass and basic mass Flag this question

Question 41 of 136
Number: 3669 Question: Given: Dry operating mass = 38 000 kg maximum structural take-off mass = 72 000 kg maximum landing mass = 65 000 kg maximum zero fuel mass = 61 000 kg Fuel burn = 8 000 kg Take-off

3. 71 300 kg and 25 300 kg 4. 73 000 kg and 24 700 kg Flag this question

Question 42 of 136
Number: 3672 Question: Maximum allowed take-off mass limit: 37 200kg Dry Operating Mass: 21 600 kg Take-off fuel: 8 500 kg Passengers on board: male 33,female 32, children 5 Baggages: 880 kg The company uses the standard passenger mass systems (see annex) allowed by regulations. The flight is not a holiday charter. In these conditions, the maximum cargo that may be loaded is

1. 2. 1 098 kg 3.

4. Flag this question

Question 43 of 136
Number: 3385 Question: The crew of a transport aeroplane prepares a flight using the following data: - Dry operating mass: 90 000 kg - Block fuel: 30 000 kg - Taxi fuel: 800 kg - Maximum take-off mass: 145 000 kg The

2. 55 000 kg 3.

4. Flag this question

Question 44 of 136
Number: 4533 Question: 'Standard Mass' as used in the computation of passenger load establish the mass of a child as

2. 35 kg for children over 2 years occupying a seat and 10 kg for infants (less than 2 years) occupying

4. 35 kg only if they are over 2 years old and occupy a seat. Flag this question

Question 45 of 136
Number: 4534

2. limited by the runway take off distance available. It is tabulated in the Flight Manual.

3. 4. a take - off limiting mass which is affected by the aerodrome altitude and temperature. Flag this question

Question 46 of 136
Number: 4535 Question: For a particular aeroplane, the structural maximum mass without any fuel on board, other than

3. a fixed value which will limit the amount of fuel carried. 4. a variable value which is governed by the traffic load carried. Flag this question

Question 47 of 136
Number: 4536 Question: An aeroplane, which is scheduled to fly an oceanic sector, is due to depart from a high altitude airport in the tropics at 1400 local time. The airport has an exceptionally long runway. Which of the

2. maximum certificated take - off mass. 3.

4. Flag this question

Question 48 of 136
Number: 4401 Question: Given an aeroplane with: Maximum Structural Landing Mass: 68000 kg Maximum Zero Fuel Mass: 70200 kg Maximum Structural Take-off Mass: 78200 kg Dry Operating Mass : 48000 kg Scheduled trip fuel is 7000 kg and the reserve fuel is 2800 kg, Assuming performance limitations are not restricting, the

2. 77200 kg and 22200 kg

3. 4. 75000 kg and 20000 kg

Flag this question

Question 49 of 136
Number: 4556 Question: On an aeroplane with a seating capacity of more than 30, it is decided to use standard mass values for computing the total mass of passengers. If the flight is not a holiday charter, the mass value which may

3. 88 kg (male) 74 kg (female). 4. 76 kg Flag this question

Question 50 of 136
Number: 4557

3. 38 kg for all flights. 4. 35 kg for holiday charters and 38 kg for all other flights. Flag this question

Question 51 of 136
Number: 4558 Question: On an aeroplane with 20 or more seats engaged on an inter-continental flight, the 'standard mass'

2.

3. 4. 14 kg per passenger. Flag this question

Question 52 of 136
Number: 4559 Question: The following data applies to a planned flight. Dry Operating Mass 34900 kg, Performance limited Take-Off Mass 66300 kg, Performance limited Landing Mass 55200 kg, Maximum Zero Fuel Mass 53070 kg, Fuel required at ramp:- Taxy fuel 400 kg, trip fuel 8600 kg, contingency fuel 430 kg, alternate fuel 970 kg, holding fuel 900 kg, Traffic load 16600 kg. Fuel costs at the departure airfield are such that it is

decided to load the maximum fuel quantity possible. The total fuel which may be safely loaded prior to

2. 15200 kg 3. 10730 kg 4. 13230 kg Flag this question

Question 53 of 136
Number: 4560 Question: In determining the Dry Operating Mass of an aeroplane it is common practice to use 'standard mass' values for crew. These values are

2. flight crew (male) 88 kg. (female) 75 kg., cabin crew 75 kg. each. These do not include an allowance for hand baggage.

4. flight crew (male) 88 kg. (female) 75 kg., cabin crew 75 kg. each. These include an allowance for hand baggage. Flag this question

Question 54 of 136
Number: 4563 Question: An aeroplane is to depart from an airfield at a take-off mass of 302550 kg. Fuel on board at takeoff (including contingency and alternate of 19450 kg) is 121450 kg. The Dry Operating Mass is 161450 kg. The useful load will be

1. 2. 39105 kg 3. 121450 kg 4. 19650 kg Flag this question

Question 55 of 136
Number: 4568 Question: Conversion of fuel volume to mass

3. must be done by using actual measured fuel density values. 4. may be done by using standard fuel density values as specified in JAR - OPS 1. Flag this question

Question 56 of 136
Number: 4569

2.

3. 4. has 6 or more seats. Flag this question

Question 57 of 136
Number: 4571 Question: A jet transport has the following structural limits: -Maximum Ramp Mass: 63 060 kg -Maximum Take Off Mass: 62 800 kg -Maximum Landing Mass: 54 900 kg -Maximum Zero Fuel Mass: 51 300 kg The aeroplane's fuel is loaded accordance with the following requirements: -Taxi fuel: 400 kg -Trip fuel: 8400 kg -Contingency & final reserve fuel: 1800 kg -Alternate fuel: 1100 kg If the Dry Operating Mass is 34930 kg, determine the maximum traffic load that can be carried on the flight if departure and landing airfields are not

3. 17 070 kg 4. 16 430 kg Flag this question

Question 58 of 136
Number: 4572 Question: A flight has been made from London to Valencia carrying minimum fuel and maximum traffic load. On the return flight the fuel tanks in the aeroplane are to be filled to capacity with a total fuel load of 20100 litres at a fuel density of 0.79 kg/l. The following are the aeroplane's structural limits: -Maximum Ramp Mass: 69 900 kg -Maximum Take Off Mass: 69 300 kg -Maximum Landing Mass: 58 900 kg -Maximum Zero Fuel Mass: 52 740 kg The performance limited take off mass at Valencia is 67 330 kg. The landing mass at London is not performance limited. Dry Operating Mass: 34 930 kg Trip Fuel (Valencia to London): 5 990 kg Taxi fuel: 250 kg The maximum traffic load that can be carried from Valencia will be:

1. 2. 9 830 kg 3. 16 770 kg 4. 14 331 kg

Question 59 of 136
Number: 4573

3. traffic load only. 4. the revenue-earning portion of traffic load only. Flag this question

Question 60 of 136
Number: 4574 Question: An aeroplane is performance limited to a landing mass of 54230 kg. The Dry Operating Mass is

2. 12200 kg. 3.

4. Flag this question

Question 61 of 136
Number: 4575 Question: See Loading Manual MRJT 1 Figure 4.5 For the medium range transport aeroplane, from the loading manual, determine the maximum total volume of fuel which can be loaded into the main wing tanks.

2. 11646 litres 3. 5674 litres 4. 8850 litres Flag this question

Question 62 of 136
Number: 4481 Question: An aeroplane is weighed and the following recordings are made: nose wheel assembly scale 5330 kg left main wheel assembly scale 12370 kg right main wheel assembly scale 12480 kg If the 'operational

items' amount to a mass of 1780 kg with a crew mass of 545 kg, the empty mass, as entered in the weight

3. 31960 kg 4. 28400 kg Flag this question

Question 63 of 136
Number: 4483

2. the weighing schedule and is amended to take account of changes due to modifications of the

3. the weighing schedule. If changes occur, due to modifications, the aeroplane must be re-weighed always. 4. the loading manifest. It differs from the zero fuel mass by the value of the 'traffic load'. Flag this question

Question 64 of 136
Number: 4504

2.

3. 4. traffic load, potable water and lavatory chemicals. Flag this question

Question 65 of 136
Number: 4505 Question: The total mass of the aeroplane including crew, crew baggage; plus catering and removable passenger equipment; plus potable water and lavatory chemicals but excluding usable fuel and traffic load, is

2. Aeroplane Prepared for Service ( APS) Mass. 3. Zero Fuel Mass.

4. Flag this question

Question 66 of 136
Number: 4506 Question: The responsibility for determination of the mass of 'operating items' and 'crew members' included

2. the authority of the state of registration. 3.

4. Flag this question

Question 67 of 136
Number: 4509 Question: The Dry Operating Mass is the total mass of the aircraft ready for a specific type of operation but

2. potable water and lavatory chemicals. 3.

4. Flag this question

Question 68 of 136
Number: 4510 Question: The Take-off Mass of an aeroplane is 66700 kg which includes a traffic load of 14200 kg and a

2. 41455 kg

3. 4. 56200 kg Flag this question

Question 69 of 136
Number: 4520

Question: The maximum certificated taxi (or ramp) mass is that mass to which an aeroplane may be loaded prior to engine start. It is:

3. a value which is only affected by the outside air temperature. Corrections are calculated from data given in the Flight Manual. 4. a value which varies only with airfield altitude. Standard corrections are listed in the Flight Manual. Flag this question

Question 70 of 136
Number: 4521

2. maximum certificated take - off mass. 3.

4. Flag this question

Question 71 of 136
Number: 4522

2.

3. 4. tyre speed and temperature limitations. Flag this question

Question 72 of 136
Number: 4524

2. differ by the mass of usable fuel.

3. 4. are the same value. Flag this question

Question 73 of 136
Number: 4525 Question: Mass for individual passengers (to be carried on an aircraft) may be determined from a verbal

3. passengers carried is less than 6. 4. passenger seats available is less than 20. Flag this question

Question 74 of 136
Number: 4527 Question: The empty mass of an aeroplane is given as 44800 kg. Operational items (including crew standard mass of 1060 kg) are 2300 kg. If the maximum zero fuel mass is given as 65500 kg, the maximum

2.

3. 4. 23000 kg Flag this question

Question 75 of 136
Number: 4528 Question: At reference or see Loading Manual MRJT 1 Figure 4.14. The following data relates to a planned flight of an aeroplane - Dry Operational mass 60520 kg Performance limited take-off mass 92750 kg, Performance limited landing mass 72250 kg, Maximum Zero Fuel mass 67530 kg. Fuel on board at take-off - Trip fuel 12500 kg, Contingency and final reserve fuel 2300 kg, Alternate fuel 1700 kg. Using this data, as

2.

3. 4. 7730 kg

Flag this question

Question 76 of 136
Number: 4529 Question: At reference or see Loading Manual MRJT 1 Figure 4.14. Aeroplane Dry Operating mass 85000 kg, Performance limited take-off mass 127000 kg, Performance limited landing mass 98500 kg, Maximum zero fuel mass 89800 kg, Fuel requirements for flight -Trip fuel 29300 kg, Contingency and final reserve

2.

3. 4. 7100 kg Flag this question

Question 77 of 136
Number: 4530 Question: The Maximum Zero Fuel Mass is a structural limiting mass. It is made up of the aeroplane Dry

2.

3. 4. traffic load, unuseable fuel and crew standard mass. Flag this question

Question 78 of 136
Number: 4531 Question: The take-off mass of an aeroplane is 141000 kg. Total fuel on board is 63000 kg including 14000

2.

3. 4. 93000 kg Flag this question

Question 79 of 136
Number: 5627 Question: For the purpose of calculating traffic loads, an operator's loading manual gives the following standard mass values for passengers. (These values include an allowance for hand baggage) Male 88 kg,

Female 70 kg, Child 35 kg, Infant 6 kg.The standard mass value to be used for hold baggage is 14 kg per piece.The loading manifest shows the following details :Passengers loaded, Males 40, Females 65, Children 8, Infants 5. Baggage in hold number 4: 120 pieces. Using the standard mass values given and the data in the appendix, select from the following the correct value for the mass of freight (all loaded in hold No1) which

2.

3. 4. 280 kg

Question 80 of 136
Number: 5466 Question: The operator of an aircraft equipped with 50 seats uses standard masses for passengers and baggage. During the preparation of a scheduled flight a group of passengers present themselves at the checkin desk, it is apparent that even the lightest of these exceeds the value of the declared standard mass.

2.

3. 4. the operator may use the standard masses for the load and balance calculation without correction Flag this question

Question 81 of 136
Number: 5468 Question: The Dry Operating Mass of an aircraft is 2 000 kg. The Maximum Take-off Mass, Landing and Zero Fuel Mass are identical at 3500 kg. The block fuel mass is 550kg, and the taxi fuel mass is 50 kg. The

2. 950 kg 3. 1 450 kg 4. 1 500 kg Flag this question

Question 82 of 136
Number: 5469 Question: Based on actual conditions, an aeroplane has the following performance take-off mass limitations: Flaps : 0 10 15 Runway: 4100 4400 4600 Climb: 4700 4500 4200 Masses are in kg Structural

2. 4 200 kg 3.

4. Flag this question

Question 83 of 136
Number: 5470 Question: The basic empty mass of an aircraft is 30 000 kg. The masses of the following items are : catering: 300 kg - safety and rescue material: nil - fly away kit: nil - crew (inclusive crew baggage): 365kg fuel at take-off: 3 000 kg - unusable fuel: 120 kg - passengers, baggage, cargo: 8 000 kg The Dry Operating

2. 30 785 kg 3. 30 300 kg 4. 38 300 kg Flag this question

Question 84 of 136
Number: 5480 Question: By adding to the basic empty mass the following fixed necessary equipment for a specific flight

2. Zero Fuel Mass 3.

4. Flag this question

Question 85 of 136
Number: 5482 Question: An aircraft basic empty mass is 3000 kg. The maximum take-off, landing, and zero-fuel mass are

3. 2 200 kg 4. 1 550 kg Flag this question

Question 86 of 136

Number: 5276 Question: The flight preparation of a turbojet aeroplane provides the following data: Take-off runway limitation: 185 000 kg Landing runway limitation: 180 000 kg Planned fuel consumption: 11 500 kg Fuel already loaded on board the aircraft: 20 000 kg Knowing that: Maximum take-off mass (MTOM): 212 000 kg Maximum landing mass (MLM): 174 000 kg Maximum zero fuel mass (MZFM): 164 000 kg Dry operating mass (DOM): 110 000 kg The maximum cargo load that the captain may decide to load on board is:

1. 2. 55 000 kg 3. 61 500 kg 4. 55 500 kg Flag this question

Question 87 of 136
Number: 5288 Question: The crew of a transport aeroplane prepares a flight using the following data: - Block fuel: 40 000 kg - Trip fuel: 29 000 kg - Taxi fuel: 800 kg - Maximum take-off mass: 170 000 kg - Maximum landing mass: 148 500 kg - Maximum zero fuel mass: 112 500 kg - Dry operating mass: 80 400 kg The maximum

2. 18 900 kg 3. 32 900 kg

4. Flag this question

Question 88 of 136
Number: 14408

2.

3. 4. It is the actual take-off mass, less traffic load. Flag this question

Question 89 of 136
Number: 14409 Question: The maximum quantity of fuel that can be loaded into an aircraft's tanks is given as 3800 US Gallons. If the fuel density (specific gravity) is given as 0.79 the mass of fuel which may be loaded is

1.

2. 3. 14383 kg. 4. 18206 kg. Flag this question

Question 90 of 136
Number: 14051 Question: At maximum certificated take-off mass an aeroplane departs from an airfield which is not limiting for either take-off or landing masses. During initial climb the number one engine suffers a contained disintegration. An emergency is declared and the aeroplane returns to departure airfield for an immediate

2. a landing further along the runway than normal. 3. a landing short resultant from the increased angle of approach due to the very high aeroplane mass.

4. Flag this question

Question 91 of 136
Number: 14054 Question: In relation to an aeroplane, the term '' Basic Empty Mass'' includes the mass of the aeroplane structure complete with its powerplants, systems, furnishings and other items of equipment considered to be an integral part of the particular aeroplane configuration. Its value is

3. printed in the loading manual and includes unusable fuel. 4. inclusive of an allowance for crew, crew baggage and other operating items. It is entered in the loading manifest. Flag this question

Question 92 of 136
Number: 14055 Question: Prior to departure the medium range twin jet aeroplane is loaded with maximum fuel of 20100 litres at a fuel density (specific gravity) of 0.78. Using the following data - Performance limited take-off mass 67200 kg Performance limited landing mass 54200 kg. Dry Operating Mass 34930 kg. Taxi fuel 250 kg. Trip fuel 9250 kg, Contingency and holding fuel 850 kg, Alternate fuel 700 kg. The maximum permissible traffic load is

1. 2. 12840 kg 3.

4. Flag this question

Question 93 of 136
Number: 14062 Question: The operator of an aircraft equipped with 50 seats uses standard masses for passengers and baggage. During the preparation of a scheduled flight a group of passengers present themselves at the check-

2. the operator may use the standard masses for the balance but must correct these for the load calculation 3.

4. Flag this question

Question 94 of 136
Number: 14715 Question: The Maximum Zero Fuel Mass is a mass limitation for the:

1.

2. 3. total load of the fuel imposed upon the wing 4. strength of the fuselage Flag this question

Question 95 of 136
Number: 4228

2. The maximum traffic load is not limited by the reserve fuel quantity. 3. The Maximum Landing Mass is basically equal to the Maximum Zero Fuel Mass.

4. Flag this question

Question 96 of 136
Number: 6126

2. The empty mass plus the trip fuel mass. 3.

4. Flag this question

Question 97 of 136
Number: 6127 Question: The Regulated Take-off Mass:

2. Is the lower of maximum structural take-off mass and the performance limited take-off mass.

3. The maximum structural take-off mass subject to any last minute mass changes. 4. The maximum performance limited take-off mass subject to any last minute mass changes. Flag this question

Question 98 of 136
Number: 6128

3. MZFM minus both traffic load and the fuel load. 4. Take-off mass minus the traffic load and the fuel load. Flag this question

Question 99 of 136
Number: 6129 Question: The Operating Mass:

1.

2. 3. Is the landing mass minus the traffic load. 4. Is the take-off mass minus the basic empty mass and crew mass. Flag this question

Question 100 of 136


Number: 6130

2. Weight X gravity. 3. None of the above. 4. The force exerted on a body by gravity. Flag this question

Question 101 of 136


Number: 6131

2. Is usually the mass of the basic aeroplane without any operating fluids. 3. Is the mass of an aeroplane as produced by the manufacturer including operating fluids, toilet and galley water plus all required equipment plus unusable fuel. 4. Is usually determined by the aircraft manufacturer during weighing at the manufacturing plant and

Flag this question

Question 102 of 136


Number: 6132

2.

3. 4. The manufacturer Flag this question

Question 103 of 136


Number: 6133

2. Part of the under load. 3.

4. Flag this question

Question 104 of 136


Number: 6134

2. Tom minus Useful Load. 3.

4. Flag this question

Question 105 of 136


Number: 6135

3. Dry operating mass plus usable fuel load. 4. That part of the traffic load which generates revenue. Flag this question

Question 106 of 136


Number: 6136

2. 979.664 L 3. 9979.66 L 4. 9785.58 L

Flag this question

Question 107 of 136


Number: 6137

2.

3. 4. 6338 imp Flag this question

Question 108 of 136


Number: 6138

2. 358 L 3.

4. Flag this question

Question 109 of 136


Number: 6139

2. US Gall x 1.205 3.

4. Flag this question

Question 110 of 136


Number: 6140

2. 161 USG

3. 4. 168 USG Flag this question

Question 111 of 136


Number: 6141

2. 58,458 lbs 3. 314,970 lbs 4. 271,525 lbs Flag this question

Question 112 of 136


Number: 6142

2. 1 USG = 6.8 lbs 3. 1 USG = 3.8 lbs 4. 1 USG = 4 lbs Flag this question

Question 113 of 136


Number: 6143

3. 5361 lbs 4. 8122 lbs Flag this question

Question 114 of 136


Number: 6144

2. Can be increased by stiffening the wing. 3. Imposes fuel dumping from the outer wings tank first.

4. Flag this question

Question 115 of 136


Number: 6145 Question: The Maximum Zero Fuel Mass is the mass of the aeroplane with no usable fuel on board. It is a

2. Governed by the requirements of the centre of gravity limits and the structural limits of the aeroplane. 3.

4. Flag this question

Question 116 of 136


Number: 6146 Question: With regards to the Maximum Zero-Fuel Weight (MZFW).

2.

3. 4. It is lower than the Maximum Take-Off Weight by the weight of a payload. Flag this question

Question 117 of 136


Number: 6147

2.

3. 4. Maximum zero fuel mass augmented by the fuel burn. Flag this question

Question 118 of 136


Number: 6148

2. The aircraft will be unable to get airborne. 3. No damage will occur providing the aircraft is within the regulated landing mass. 4. No damage will occur providing the aircraft is within the performance limited landing mass. Flag this question

Question 119 of 136


Number: 6149 Question: If an aeroplane lands below its Max Structural Landing Mass but above the Performance Limited Landing Mass for the arrival airfield: 1. It will not suffer physical damage as a result of the extra mass. 2. Tyre temperature limits could be exceeded. 3. It might not have sufficient runway length in which to stop

2. 1,3,4 and 5 only 3.

4. Flag this question

Question 120 of 136


Number: 6150 Question: A twin-engine aeroplane is certified for a Max Structural TOM and a Max LM of 58,000 kg and 55,000 kg respectively. Given the information below, what is the limiting take-off mass for the aeroplane? Performance Limiting TOM 61000 kg Performance Limiting LM 54000 kg Operating mass 55000 kg Trip fuel 3000 kg Contingency fuel 5% of trip fuel Alternate fuel 500 kg Final reserve 500 kg Flight duration 3

3. 61000 kg 4. 56545 kg Flag this question

Question 121 of 136


Number: 6151 Question: An aeroplane takes off as normal on a scheduled flight however, shortly after take-off the aeroplane is diverted to another airfield. Max Structural TOM 14000 kg Performance Limited TOM 12690 kg Max Structural LM 9600 kg Trip Fuel to original destination 6000 kg Contingency fuel 200 kg Alternate fuel 200 kg Final reserve fuel 750 kg Expected landing mass at original destination 4600kg Actual flight duration 2 hours Fuel consumption 1500 kg per hour Performance Limited LM at diversion airfield 9000 kg

1.

2. 3. The aeroplane cannot land safely because its mass is beyond the limit for the runway limitations. 4. The aeroplane cannot land safely because it is above its MSLM. Flag this question

Question 122 of 136


Number: 6152 Question: An aeroplane develops a serious technical problem shortly after take-off and has to return to its departure airfield. In order to land safely the aircraft must dump fuel. How much fuel must be dumped?

2. As much as the pilot feels is just sufficient to land safely. 3. Sufficient to reduce the mass to the zero fuel mass. 4. The fuel system automatically stops the jettison at the Regulate Landing Mass. Flag this question

Question 123 of 136


Number: 6153 Question: "A scheduled flight of three hours estimated time, within Europe, is to be conducted. Using the data given calculate the maximum mass of freight that may be loaded in the following circumstances: Performance limited take-off mass: 67,900 kg Performance limited landing mass: 56,200 kg MZFM: 51,300 kg DOM: 34,960 kg Fuel on board at ramp: 15,800 kg Taxi fuel: 450 kg Trip fuel: 10,200 kg Passengers: 115 adults + 6 children Flight crew (each 85 kg): 2 Cabin crew (each 75 kg): 5 Allow standard baggage for

2. 4764 kg 3. 1047 kg 4. 6147 kg Flag this question

Question 124 of 136


Number: 6154 Question: Given: DOM = 3415 lbs Trip fuel = 400 lbs Passenger Mass = 600 lbs Freight/baggage = 1050 lbs Maximum structural TOM = 5850 lbs Performance TOM = 5200 lbs The traffic load is to be reduced to

3. 400 lbs 4. 600 lbs Flag this question

Question 125 of 136


Number: 6155 Question: Given: DOM(APS) = 3500 lbs Trip fuel = 500 lbs Passenger Mass = 400 lbs Freight/baggage = 1250 lbs Maximum structural TOM = 5850 lbs Performance Regulated TOM = 5200 lbs The traffic load is

2.

3. 4. 250 lbs Flag this question

Question 126 of 136


Number: 6156 Question: What is the allowed traffic load for a medium range jet aircraft where the DOM is 35058 kg, where the limitations are MZFM 52790 kg, RTOM 61875 kg, RLM 53871 kg. The TOF is 13358 kg of

2. 17,732 kg 3. 10, 376 kg 4. 14,355 kg Flag this question

Question 127 of 136


Number: 6157

2. 9 seats or more 3.

4. Flag this question

Question 128 of 136


Number: 6158 Question: For the purposes of mass and balance JAR-OPS 1 defines a child as a person aged:

1.

2. 3. Of 2 years but having reached 15 years old. 4. Of 3 years but not having reached their 15th birthday. Flag this question

Question 129 of 136


Number: 6159

3. Any non-human, non-animal cargo. 4. Excess freight. Flag this question

Question 130 of 136


Number: 6160

2. An infant must always be seated in its own seat and accounted for as 35 kg. 3.

4. Flag this question

Question 131 of 136


Number: 6161 Question: Standard passenger masses used for a holiday charter flight are:

1. 2. Average mass of adult person 84 Kg. 3.

4. Flag this question

Question 132 of 136


Number: 6162 Question: If standard mass tables are being used for checked baggage and a number of passengers check in baggage that is expected to exceed the standard baggage mass, the operator:

2. Need make no alterations if the Take-off mass is not likely to exceeded. 3. Determine the actual masses of such baggage. 4. Must determine the actual mass of such baggage by weighing or by deducting an adequate mass increment. Flag this question

Question 133 of 136


Number: 6163 Question: On any flight identified as carrying a significant number of passengers whose masses, including hand baggage, are expected to exceed the standard passenger mass the operator:

1. 2. Must determine the actual mass of such passengers.

4. Need only determine the actual masses or apply an increment if the Take-off mass is likely to be exceeded. Flag this question

Question 134 of 136


Number: 6164 Question: The weighing machine used for passenger weighing shall have a capacity of at least and shall

3. 250 kg, 1 kg 4. 200 kg, 500 g Flag this question

Question 135 of 136


Number: 6165 Question: For an aircraft having 16 passenger seats, if no hand luggage is carried, how much weight may be deducted from the standard passenger weights for passengers over 12 years old?

1. 2.

3. 4. 10 Kg Flag this question

Question 136 of 136


Number: 6166

2. 84 kg

3. 4. 85 kg Flag this question

03CG CALCULATIONS
Question 1 of 24
Number: 297 Question: A location in the aircraft which is identified by a number designating its distance from the datum

3. Index. 4. MAC. Flag this question

Question 2 of 24
Number: 803

2. which is always used as datum when computing moments. 3. where the sum of the external forces is equal to zero. 4. where the sum of the moments from the external forces acting on the body is equal to zero.

Flag this question

Question 3 of 24
Number: 1080

2. vertical axis. 3.

4. Flag this question

Question 4 of 24
Number: 1081

2. It is the distance from the centre of gravity to the point through which the weight of the component acts. 3. It is the most forward position of the centre of gravity.

Flag this question

Question 5 of 24
Number: 1082 Question: An aircraft has its centre of gravity located 7 metres from the datum line and it has a weight of 49000 N. The moment about the datum is:

1. 2.

3. 4. 7000 Nm. Flag this question

Question 6 of 24
Number: 1083 Question: Which one of the following is correct?

1.

2.

3. 4. Arm = Force / Moment Flag this question

Question 7 of 24
Number: 13024 Question: In calculations with respect to the position of the centre of gravity a reference is made to a datum. The datum is

2. a reference plane which is chosen by the aircraft manufacturer. Its position is given in the aircraft

3. calculated from the loading manifest. 4. an arbitrary reference chosen by the pilot which can be located anywhere on the aircraft. Flag this question

Question 8 of 24
Number: 13456 Question: The datum is a reference from which all moment (balance) arms are measured. Its precise

2. at or near the focal point of the aircraft axis system. 3. at or near the forward limit of the centre of gravity.

4. Flag this question

Question 9 of 24
Number: 4474 Question: Moment (balance) arms are measured from a specific point to the body station at which the mass is located. That point is known as

1. 2. the centre of gravity of the aircraft. 3.

4.

Flag this question

Question 10 of 24
Number: 4476 Question: The centre of gravity of an aircraft is that point through which the total mass of the aircraft is said

2. always parallel to the aircraft's vertical axis. 3. governed by the distribution of the mass within the aircraft. 4. at right angles to the flight path. Flag this question

Question 11 of 24
Number: 4477

2. through a point defined as the datum point. 3. through its centre of pressure. 4. through the main wheels of its undercarriage assembly. Flag this question

Question 12 of 24
Number: 4478

2. vertically through the datum point. 3.

4. Flag this question

Question 13 of 24
Number: 4496 Question: Which of the following is unlikely to have any effect on the position of the centre of gravity on

2.

3. 4. Movement of cabin attendants going about their normal duties.

Flag this question

Question 14 of 24
Number: 4501

3. the moment. 4. the force. Flag this question

Question 15 of 24
Number: 4519 Question: A mass of 500 kg is loaded at a station which is located 10 metres behind the present Centre of Gravity and 16 metres behind the datum. (Assume: g=10 m/sec squared). The moment for that mass used in

2.

3. 4. 50000 Nm Flag this question

Question 16 of 24
Number: 5619 Question: For the purpose of aeroplane mass and balance calculations, the datum point is defined as:

2. a variable point, that is dependent on the load distribution for its location, from which all balance arms are measured

4. a point near the centre of the aeroplane. It moves longitudinally as masses are added forward and aft of its location. Flag this question

Question 17 of 24
Number: 5478 Question: The centre of gravity is the

1. 2. focus along the longitudinal axis, in relation to a datum line 3.

4. Flag this question

Question 18 of 24
Number: 6167 Question: The centre of gravity is that on an aircraft through this the total is considered to act

2.

3. 4. point; moment; upwards Flag this question

Question 19 of 24
Number: 6168 Question: If all the moments are positive when calculating mass (weight) and balance, the position of the

2. Centre line of the nose or tail wheel depending on the aircraft type. 3.

4. Flag this question

Question 20 of 24
Number: 6169 Question: Balance Arm (B) is:

1.

2. 3. The distance from the centre of gravity to the centre of a mass. 4. The point on which a lever is supported, balanced, or about which it turns.

Flag this question

Question 21 of 24
Number: 6170 Question: The aircraft datum is a reference point that is defined on or relative to the aircraft about which

2. variable, movements 3. forward, arms 4. movable, moments Flag this question

Question 22 of 24
Number: 6171

3. Is the point through which all the forces of gravity are said to act. 4. Is a vertical plane through which all the forces of gravity are said to act. Flag this question

Question 23 of 24
Number: 6172

3. Between the nose and the tail. 4. At the fire wall. Flag this question

Question 24 of 24
Number: 6173 Question: Determine the attached drawing and consider the correct mass & balance calculation (balanced

2. Fb = A / (Fa x B)

3. 4. Fb = (A x B) / Fa Flag this question

04MASS AND BALANCE DETAILS OF AIRCRAFTS


Question 1 of 31
Number: 295 Question: The loaded centre of gravity (cg) of an aeroplane is 713 mm aft of datum. The mean aerodynamic chord lies between station 524 mm aft and 1706 mm aft. The cg expressed as % MAC (mean aerodynamic

2. 41 % 3. 10 % 4. 60 % Flag this question

Question 2 of 31
Number: 2082 Question: Calculate the centre of gravity in % MAC (mean aerodynamic chord) with following data: Distance datum - centre of gravity: 12.53 m Distance datum - leading edge: 9.63 m Length of MAC: 8 m

1. 2. 23.1 % MAC 3. 63.4 % MAC 4. 47.0 % MAC Flag this question

Question 3 of 31
Number: 4475 Question: At reference or see Loading Manual MRJT 1 page 20. For the medium range twin jet the datum

2.

3. 4. on the nose of the aeroplane. Flag this question

Question 4 of 31
Number: 4482

Question: If individual masses are used, the mass of an aircraft must be determined prior to initial entry into

2. at intervals of 9 years. 3.

4. Flag this question

Question 5 of 31
Number: 4487 Question: At reference or see Loading Manual MRJT 1 Figure 4.11. At the maximum landing mass the

2. Forward limit 8.0% MAC aft limit 27.2% MAC 3. Forward limit 8.6% MAC aft limit 27.0% MAC

4. Flag this question

Question 6 of 31
Number: 4488 Question: At a given mass the CG position is at 15% MAC. If the leading edge of MAC is at a position 625.6 inches aft of the datum and the MAC is given as 134.5 inches determine the position of the CG in

2. 605.43 inches aft of datum 3. 228.34 inches aft of datum 4. 20.18 inches aft of datum Flag this question

Question 7 of 31
Number: 4489 Question: At reference or see Loading Manual MRJT 1 Figure 4.11. The aeroplane has a Take Off Mass of 58 000 kg. At this mass the range of safe CG positions, as determined from the appropriate graph in the

2. Forward limit 8.2% MAC aft limit 26.2% MAC 3. Forward limit 9.5% MAC aft limit 26.1% MAC 4. Forward limit 8.5% MAC aft limit 26.1% MAC

Flag this question

Question 8 of 31
Number: 4490 Question: When preparing to carry out the weighing procedure on an aircraft, which of the following is not

2. removable passenger services equipment to be off-loaded. 3.

4. Flag this question

Question 9 of 31
Number: 4491 Question: An aircraft is weighed prior to entry into service. Who is responsible for deriving the Dry

2. The aircraft manufacturer or supplier. 3.

4. Flag this question

Question 10 of 31
Number: 4492

2.

3. 4. in a quiet parking area clear of the normal manoeuvring area. Flag this question

Question 11 of 31
Number: 4493 Question: At reference or see Loading Manual MRJT 1 Figure 4.11. An aeroplane has a landing mass of 53 000kg. The range of safe CG positions, as determined from the appropriate graph in the loading manual, is :

1. 2.

3. 4. Forward limit 7.3% MAC aft limit 26.8% MAC Flag this question

Question 12 of 31
Number: 4494 Question: At reference or see Loading Manual MRJT 1 Figure 4.11. The aeroplane has a mass of 61 000 kg in the cruise. The range of safe CG positions, as determined from the appropriate graph in the loading

2. forward limit 8.0% aft limit 27.2% MAC. 3. forward limit 7.7% aft limit 25.2% MAC 4. forward limit 7.6% aft limit 26.9% MAC. Flag this question

Question 13 of 31
Number: 4495 Question: At reference or see Loading Manual MRJT 1 Figure 4.9. For the transport aeroplane the moment

2. 421.5 inches. 3. 314.5 inches. 4. 257 inches. Flag this question

Question 14 of 31
Number: 4514 Question: An aeroplane must be re-weighed at certain intervals. Where an operator uses 'fleet masses' and

2. 4 years for each aeroplane. 3.

4. Flag this question

Question 15 of 31

Number: 5620 Question: An aeroplane has a mean aerodynamic chord (MAC) of 134.5 inches. The leading edge of this chord is at a distance of 625.6 inches aft of the datum. Define the location of the centre of gravity of the aeroplane in terms of percentage MAC if the mass of the aeroplane is acting vertically through a balance arm located 650 inches aft of the datum.

1. 2. 10,5% 3.

4. Flag this question

Question 16 of 31
Number: 5621 Question: At reference or see Loading Manual MRJT 1 Figure 4.13. Using the load and trim sheet for the MRJT1 aircraft which of the following is the correct value for the index at a Dry Operating Mass (DOM) of 35000 kg with a CG at 14% MAC ?

1. 2. 41.5 3. 33..0 4. 35.5 Flag this question

Question 17 of 31
Number: 5465 Question: The centre of gravity of an aeroplane is at 25% of the Mean Aerodynamic Chord. This means that

2. the mean aerodynamic chord in relation to the trailing edge 3. the aeroplane in relation to the leading edge 4. the mean aerodynamic chord in relation to the datum Flag this question

Question 18 of 31
Number: 5467 Question: The datum used for balance calculations is: 1. chosen on the longitudinal axis of the aircraft and necessarily situated between the leading edge and

3. chosen on the longitudinal axis of the aircraft, and always at the fire-wall level 4. chosen on the longitudinal axis of the aeroplane, and necessarily situated between the nose and the tail of the aircraft Flag this question

Question 19 of 31
Number: 5472

2.

3. 4. 1 point of support Flag this question

Question 20 of 31
Number: 5479 Question: The determination of the centre of gravity in relation to the mean aerodynamic chord: 1. consists of defining the centre of gravity longitudinally in relation to the position of the aerodynamic

2. consists of defining the centre of gravity longitudinally in relation to the length of the mean aerodynamic chord and the trailing edge 3. consists of defining the centre of gravity longitudinally in relation to the position of the aerodynamic convergence point

Flag this question

Question 21 of 31
Number: 14058 Question: The mass and balance information gives: Basic mass: 1 200 kg ; Basic balance arm: 3.00 m Under these conditions the Basic centre of gravity is at 25% of the mean aerodynamic chord (MAC). The length of MAC is 2m. In the mass and balance section of the flight manual the following information is given : Position Arm. front seats : 2.5 m, rear seats : 3.5 m, rear hold : 4.5 m, fuel tanks : 3.0 m. The pilot and one passenger embark; each weighs 80 kg. Fuel tanks contain 140 litres of petrol with a density of 0.714. The rear seats are not occupied.Taxi fuel is negligable. The position of the centre of gravity at take-off

2. 17 % 3. 29 % 4. 34 %

Question 22 of 31
Number: 6174

2. The safe range falls between the front and rear CG limits but does not include them. 3. The safe range falls between the front and rear CG limits but only includes the fwd limit. 4. The safe range falls between the front and rear CG limits but only includes the aft limit. Flag this question

Question 23 of 31
Number: 6175 Question: The C.G. limits are from 5 inches forward to 7 inches aft of the datum. If the MAC is 41 inches

2. Fwd limit 29.3%, Aft limit 36.6% 3.

4. Flag this question

Question 24 of 31
Number: 6176 Question: Given the data below calculate the C of G at TOM as a percentage of the mean aerodynamic chord: Basic Empty Mass: 1095 kg C of G at BEM: 1.98m (25% MAC) Pilot and front seat occupant 80kg

3. 31% 4. 32% Flag this question

Question 25 of 31
Number: 6178

2. Every third year.

3.

4. Flag this question

Question 26 of 31
Number: 6179 Question: When weighing an aircraft certain precautions have to be made. Which of the following is not a

2. Ensure the weighing is accomplished in an enclosed building. 3.

4. Flag this question

Question 27 of 31
Number: 6180 Question: Aircraft must be weighed: A: On initial entry into service. B: If the mass and balance records have not been adjusted for alterations or modification. C: Every four years after initial weigh. D: Whenever the cumulative changes to the dry operating mass exceed plus or minus 0.5% of the maximum landing mass.

3. A, C and E only 4. A, B and C only Flag this question

Question 28 of 31
Number: 6181 Question: An operator has 19 aircraft of the same type and wants to use fleet mass values. Select the

2. Initially 10 thereafter 14. 3. Initially 19 thereafter 14.

4. Flag this question

Question 29 of 31
Number: 6182 Question: The operator must establish the mass of the Traffic Load:

2. By using an appropriate method of calculation as specified in the JAR-OPS subpart J. 3. Prior to initial entry into service. 4. Prior to embarking on the aircraft. Flag this question

Question 30 of 31
Number: 6183

3. By the owner operator before the first flight of the day. 4. By the engineers before commencing service. Flag this question

Question 31 of 31
Number: 7298

2.

3. 4. (i) vertical (ii) aft limit Flag this question

05-DETERMINATION OF CG POSITIONS Question 1 of 49


Number: 298 Question: The mass of an aircraft is 1950 kg. If 450 kg is added to a cargo hold 1.75 metres from the loaded centre of gravity (cg). The loaded cg will move:

1. 2. 40 cm. 3. 30 cm.

4. Flag this question

Question 2 of 49
Number: 400 Question: If 390 Ibs of cargo are moved from compartment B (aft) to compartment A (forward), what is the station number of the new centre of gravity (cg). Given : Gross mass 116.500 Ibs, Present cg station 435.0,

2.

3. 4. 506.3 Flag this question

Question 3 of 49
Number: 1084 Question: Given: Total mass 2900 kg Centre of gravity (cg) location station: 115 Aft cg limit station: 116

2. 14 kg. 3. 317 kg. 4. 140 kg. Flag this question

Question 4 of 49
Number: 1085 Question: Given: Total mass: 7500 kg, Centre of gravity (cg) location station: 80.5, Aft cg limit station: 79.5. How much cargo must be shifted from the aft cargo compartment at station 150 to the forward cargo

2. 73.5 kg. 3. 65.8 kg. 4. 68.9 kg. Flag this question

Question 5 of 49
Number: 1086 Question: A jet aeroplane, with the geometrical characteristics shown in the appendix, has a take-off weight (W) of 460 000 N and a centre of gravity (point G on annex) located at 15.40 m from the zero reference point. At the last moment the station manager has 12 000 N of freight added in the forward compartment at

10 m from the zero reference point. The final location of the centre of gravity, calculated in percentage of

3. 35.5 %. 4. 30.4 %. Flag this question

Question 6 of 49
Number: 1950 Question: Given: Aeroplane mass = 36 000 kg Centre of gravity (cg) is located at station 17 m What is the

2.

3. 4. It moves forward by 0.157 m. Flag this question

Question 7 of 49
Number: 1960

2. a location in the aeroplane identified by a number. 3. the range of moments the centre of gravity (cg) can have without making the aeroplane unsafe to fly.

4. Flag this question

Question 8 of 49
Number: 1963

2. 3. 60.16 cm aft datum.

4. 56.35 cm aft datum. Flag this question

Question 9 of 49
Number: 1964 Question: Given are the following information at take-off. Details at reference Given that the flight time is 2 hours and the estimated fuel flow will be 1050 litres per hour and the average oil consumption will be 2.25 litres per hour. The specific density of fuel is 0.79 and the specific density of oil is 0.96. Calculate the

2. 61.26 cm aft of datum. 3. 61.27 cm aft of datum. 4. 61.29 cm aft of datum. Flag this question

Question 10 of 49
Number: 1965 Question: Given that the total mass of an aeroplane is 112 000 kg with a centre of gravity position at 22.62m aft of the datum. The centre of gravity limits are between 18m and 22m. How much mass must be

3. 16 529 kg 4. 8 680 kg Flag this question

Question 11 of 49
Number: 1642 Question: The total mass of an aeroplane is 9000 kg. The centre of gravity (cg) position is at 2.0 m from the datum line. The aft limit for cg is at 2.1 m from the datum line. What mass of cargo must be shifted from the

3. 196 kg 4. 900 kg Flag this question

Question 12 of 49
Number: 1646 Question: Assume: Aircraft actual mass: 4750 kg Centre of gravity at station: 115.8 What will be the new position of the centre of gravity if 100 kg is moved from the station 30 to station 120?

1. 2.

3. 4. Station 118.33 Flag this question

Question 13 of 49
Number: 1659 Question: An aeroplane with a two wheel nose gear and four main wheels rests on the ground with a single nose wheel load of 500 kg and a single main wheel load of 6000 kg. The distance between the nose wheels

2. 41.6 cm. 3. 25 cm. 4. 4 meter. Flag this question

Question 14 of 49
Number: 3673 Question: Length of the mean aerodynamic chord = 1 m Moment arm of the forward cargo: -0,50 m Moment arm of the aft cargo: + 2,50 m The aircraft mass is 2 200 kg and its centre of gravity is at 25% MAC To move the centre of gravity to 40%, which mass has to be transferred from the forward to the aft

3. 183 kg 4. 165 kg Flag this question

Question 15 of 49
Number: 3386 Question: The planned take-off mass of a turbojet aeroplane is 190 000 kg, with its centre of gravity located at 29 % MAC (Mean Aerodynamic Cord) . Shortly prior to engine start, the local staff informs the flight crew that 4 000 kg must be loaded in cargo 4. After the handling operation, the new centre of gravity

2. 27 % 3. 31 %

4. Flag this question

Question 16 of 49
Number: 3573 Question: At reference or see Loading Manual SEP1 Figure 2.4. With respect to a single-engine piston powered aeroplane, determine the zero fuel moment (lbs.In./100) in the following conditions: Basic Empty Mass: 2415 lbs. Arm at Basic Empty Mass: 77,9 In. Cargo Zone A: 350 lbs. Baggage Zone B: 35 lbs. Pilot

2. 2496,3 3.

4. Flag this question

Question 17 of 49
Number: 3574 Question: Determine the Zero Fuel Mass for the following single engine aeroplane. Given : Basic Empty Mass: 1799 lbs Optional Equipment: 35 lbs Pilot Front seat passenger : 300 lbs Cargo Mass : 350 lbs Ramp

2. 2659 lbs 3.

4. Flag this question

Question 18 of 49
Number: 3575 Question: Determine the Landing Mass for the following single engine aeroplane. Given: Standard Empty Mass :1764 lbs Optional Equipment : 35 lbs Pilot Front seat passenger : 300 lbs Cargo Mass : 350 lbs Ramp Fuel = Block Fuel : 60 Gal. Trip Fuel : 35 Gal. Taxi Fuel 1.7 Gal. Fuel density: 6 lbs/Gal Determine the

2. 3. 2659 lbs 4. 2799 lbs

Flag this question

Question 19 of 49
Number: 5622 Question: Using the data given in the Load & Trim sheet, determine which of the following gives the

2. 51300 Kg and 20,8% 3. 41300 Kg and 17,8% 4. 46130 Kg and 20,8% Flag this question

Question 20 of 49
Number: 5623 Question: Using the data given in the Load & Trim sheet, determine from the following the correct values for the take off mass and the position of the centre of gravity at that mass if the fuel index correction to be

3. 20.1 % 4. 20.3 % Flag this question

Question 21 of 49
Number: 5629 Question: An aeroplane is carrying a traffic load of 10320 kg. Complete the necessary sections of the attached appendix and determine which of the answers given below represents the maximum increase in the

2. 8268 kg 3. 7000 kg 4. 655 kg Flag this question

Question 22 of 49
Number: 5324 Question: A turbojet aeroplane has a planned take-off mass of 190 000 kg. Following cargo loading, the crew is informed that the centre of gravity at take-off is located at 38 % MAC (Mean Aerodynamic Cord) which is beyond limits. The captain decides then to redistribute part of the cargo load between cargo 1 and cargo 4 in order to obtain a new centre of gravity location at 31 % MAC. Given: Distance from reference point to leading edge: 14m. Length of MAC = 4.6m. He asks for a transfer of:

1. 2. It is not possible to obtain the required centre of gravity. 3.

4. Flag this question

Question 23 of 49
Number: 5462 Question: Without the crew, the mass and longitudinal CG position of the aircraft are 6 000 kg and 4,70m. the mass of the pilot is 90 kg - the mass of the copilot is 100 kg - the mass of the flight engineer is 80 kg

2. 6 270 kg and 5.012 m 3. 6 270 kg and 4.796 m 4. 6 270 kg and 4.61 m Flag this question

Question 24 of 49
Number: 5473 Question: At reference. Without the crew, the weight and the CG-position of the aircraft are 7 000 kg and 4,70m. - the mass of the pilot is 90 kg - the mass of the copilot is 75 kg - the mass of the flight engineer is 90

3. 4,783 m 4. 0,217 m Flag this question

Question 25 of 49
Number: 5310 Question: The planned take-off mass of an aeroplane is 180 000 kg, with its centre of gravity located at 31 % MAC (Mean Aerodynamic Cord). Shortly prior to engine start, the local staff informs the flight crew that

3. 34 %

4. 37 % Flag this question

Question 26 of 49
Number: 5311 Question: A turbojet aeroplane is parked with the following data: Corrected Dry Operating Mass: 110 100 kg Basic corrected index: 118.6 Initial cargo distribution: cargo 1 = 4 000 kg; cargo 2 = 2 000 kg; cargo 3 = 2 000 kg; The other cargo compartments are empty. Take-off mass: 200 000 kg Centre of gravity location: 32 % MAC (Mean Aerodynamic Cord) To maximize performance, the captain decides to redistribute part of the cargo load between cargo 1 and cargo 4, in order to take off with a new centre of gravity location at 35 %

2.

3. 4. 1 000 kg in cargo 1; 3 000 kg in cargo 4

Question 27 of 49
Number: 5312 Question: The planned take-off mass of a turbojet aeroplane is 180 000 kg, with its centre of gravity located at 26 % MAC (Mean Aerodynamic Cord). Shortly prior to engine start, the local staff informs the flight crew that 4 000 kg must be unloaded from cargo 4. After the handling operation, the new centre of gravity

2.

3. 4. 20.0 % Flag this question

Question 28 of 49
Number: 5158 Question: Contrary to the forecast given in the LOAD and TRIM sheet, cargo compartment 1 is empty. The

2.

3. 4. 32.5 % Flag this question

Question 29 of 49

Number: 5159 Question: Contrary to the loading sheet forecasts you have : Cargo compartment 1: empty passengers in compartment OA: 20 Cargo compartment 2: 1 000 kg passengers in compartment OB: 20 Cargo compartment 3: 3 000 kg passengers in compartment OC: 30 Cargo compartment 4: 2 000 kg Cargo compartment 5: 1 000 kg The take-off centre of gravity in MAC % (Mean Aerodynamic Chord), will be

2. 35.5 % 3. 32.5 %

4. Flag this question

Question 30 of 49
Number: 5160 Question: Just prior to departure, you accept 10 passengers additional on board who will be seated in "compartment OA" and you have 750 kg unloaded from cargo compartment 5. The take-off centre of gravity

3. 30.5 % 4. 28.5 % Flag this question

Question 31 of 49
Number: 5161 Question: The weight and balance sheet is available and contrary to the forecast, cargo compartment 1 is empty. The zero fuel weight centre of gravity in MAC % (Mean Aerodynamic Chord) is located at:

1. 2. 32 % 3. 26 % 4. 31.5 % Flag this question

Question 32 of 49
Number: 6184 Question: Given the following information, calculate the loaded centre of gravity (cg). STATION MASS(kg) / Balance Arm (cm) / MOMENT (kgcm) Basic Empty Condition: 12045 / +30 / +361350 Crew: 145 / -160 / -23200 Freight1: 5455 / +200 / +1091000 Freight2: 410 / -40 / -16400 Fuel: 6045 / -8 / -48360 Oil: 124 / +40 / +4960

1. 2. 53.35cm aft datum. 3.

4. Flag this question

Question 33 of 49
Number: 6185

2. Dividing the total mass by the total moment.

3. 4. Subtracting the total mass from the total moment. Flag this question

Question 34 of 49
Number: 6186 Question: If an aircraft weight = 2000kg and 400kg of freight is added to a hold 2m aft of the present CG

2. 3. 0.4m forward 4. 0.33 forward Flag this question

Question 35 of 49
Number: 6187 Question: An aircraft has a mass of 7900kg and the CG is located at 81.2 in aft of the datum. If a package of mass 250 kg was loaded in a hold situated 32 in aft of the datum, what would the new CG position be?

1. 2. 88.1 inches

3. 4. 74.4 inches

Flag this question

Question 36 of 49
Number: 6188 Question: Given: C of G is located at STN 15 Aeroplane mass is 3650 lbs. What is the effect on the C of G

3. It moves AFT by 0.31 units 4. It moves FWD by 0.13 units Flag this question

Question 37 of 49
Number: 6189 Question: An aircraft has three holds situated 10 in 100 in and 250 in aft of the datum, identified as holds A,B and C respectively. The total aircraft mass is 3500 kg and the CG is 70 in aft of the datum. The CG limits are from 40 in to 70 in aft of the datum. How much load must be removed from hold C to ensure that

2. 400kg 3.

4. Flag this question

Question 38 of 49
Number: 6190 Question: An aircraft has a mass of 5000 lbs and the CG is located at 80 in aft of the datum. The aft CG limit is at 80.5 in aft of the datum. What is the maximum mass that can be loaded into a hold situated 150 in

3. 23.15 lbs 4. 58.15 lbs Flag this question

Question 39 of 49
Number: 6191

Question: The CG limits of an aircraft are from 83 inches to 93 inches aft of the datum. The CG as loaded is bound to be at 81 inches aft of the datum. The loaded mass is 3240 lbs. How much mass must be moved from the forward hold, 25 inches aft of the datum, to the aft hold, 142 inches aft of the datum, to bring the

2. 82.09 lbs 3. 74.96 lbs 4. 22.49 lbs Flag this question

Question 40 of 49
Number: 6192 Question: The CG limits of an aircraft are from 72 inches to 77 inches aft of the datum. If the mass is 3700 kg and the CG position is 76.5 inches aft of the datum, what will the change to the CG position be if 60 Kgs

2.

3. 4. 3.31 inches Flag this question

Question 41 of 49
Number: 6193 Question: If the CG position is 30m aft of the datum after 3,000 kg was added to a hold 50m aft of the

2. 34.2m 3.

4. Flag this question

Question 42 of 49
Number: 6194 Question: An aircraft has a loaded mass of 5,500 lbs. The CG is 22 inches aft of the datum. A passenger, mass 150 lbs, moves aft from row 1 to row 3 a distance of 70 inches. What will be the new position of the

2. 22.9 inches

3. 4. 26.3 inches Flag this question

Question 43 of 49
Number: 6195 Question: If the C.G. position is 21% MAC, the MAC is 73 inches, and the C.G. datum is 26 inches aft of

3. 41.33 inches aft of datum. 4. 41.33 inches fwd of datum. Flag this question

Question 44 of 49
Number: 6196 Question: "(For this question use EXAM annexes 031-11069A, 031-11248B, and 031-11248C) knowing that: -Dry operating mass: 110,000 kg -Basic index: 119.1 -Number of passengers: 185 distributed as shown in the annex (75kg per PAX) - Cargo load + luggage: 14,000 kg distributed as shown in the annex. Fuel: 72,000 kg Stages (1) to (7) and (11) having already been calculated, the centre of gravity in % MAC (Mean

3. 25.20% 4. 32.50% Flag this question

Question 45 of 49
Number: 6197

2.

3. 4. The documentation is not signed prior to flight. Flag this question

Question 46 of 49
Number: 6198 Question: An aircraft of mass 17,400 kg, has its CG at station 122.2. The CG limits are 118 to 122. How much cargo must be moved from the rear hold at station 162 to the forward hold at station -100 (forward of

2. 55.3 kg 3. 119.9 kg 4. 99.9 kg Flag this question

Question 47 of 49
Number: 6199 Question: The loaded mass of the aircraft is found to be 1850 lbs and the CG moment 154,000 lbs in. How much mass must be moved from the forward hold 40 inches aft of the datum, to the rear hold, 158 inches aft

2.

3. 4. 50.9 lbs Flag this question

Question 48 of 49
Number: 6200 Question: The loaded mass of an aircraft is 12,400 kg. The aft CG limit is 102 inches aft of the datum. If the CG as loaded is 104.5 inches aft of the datum, how many rows forward must two passengers move from the rear seat row (224 inches aft) to bring the CG on to the aft limit, if the seat pitch is 33 inches? Assume a

2. 6 rows 3.

4. Flag this question

Question 49 of 49
Number: 6201 Question: An aeroplane has a zero fuel mass of 47,800kg and a performance limited take-off mass of 62,600kg. The distances of the leading edge and trailing edge of the MAC from the datum are 16m and 19.5m respectively. What quantity of fuel must be taken up to move the CG from 30% MAC to 23% MAC if the tank arm is 16m aft of the datum and the fuel SG is 0.72.

1. 2. 8850 L 3. 4213 US Gallons 4. 3990 Kg Flag this question

05CARGO HANDLING
Question 1 of 14
Number: 806 Question: The maximum load per running metre of an aircraft is 350 kg/m. The width of the floor area is 2 metres. The floor strength limitation is 300 kg per square metre. Which one of the following crates (length x

2. A load of 700 kg in a crate with dimensions 1.8 m x 1.4 m x 0.8 m. 3. A load of 500 kg in a crate with dimensions 1.5 m x 1 m x 1 m. 4. A load of 400 kg in a crate with dimensions 1.4 m x 0.8 m x 0.8 m. Flag this question

Question 2 of 14
Number: 1961

2. 3. allow steep turns. 4. prevent excessive 'g'-loading during the landing flare. Flag this question

Question 3 of 14
Number: 4497 Question: At reference or see Loading Manual MRJT 1 Figure 4.9. Referring to the loading manual for the transport aeroplane, the maximum running load for the aft section of the forward lower deck cargo

2. 7.18 kg per inch. 3. 14.65 kg per inch. 4. 13.15 kg per inch. Flag this question

Question 4 of 14

Number: 4498 Question: At reference or see Loading Manual MRJT 1 Figure 4.9. Referring to the loading manual for the transport aeroplane, the maximum load intensity for the lower forward cargo compartment is:

1. 2. 7288 kg in forward compartment and 9232 kg in aft compartment.

3. 4. 150 kg per square foot. Flag this question

Question 5 of 14
Number: 4499 Question: The maximum floor loading for a cargo compartment in an aeroplane is given as 750 kg per square metre. A package with a mass of 600 kg. is to be loaded. Assuming the pallet base is entirely in contact with the floor, which of the following is the minimum size pallet that can be used ?

1. 2. 30 cm by 300 cm 3.

4. Flag this question

Question 6 of 14
Number: 4500 Question: The maximum intensity floor loading for an aeroplane is given in the Flight Manual as 650 kg per square metre. What is the maximum mass of a package which can be safely supported on a pallet with dimensions of 80 cm by 80 cm?

1. 2. 101.6 kg 3.

4. Flag this question

Question 7 of 14
Number: 4502 Question: At reference or see Loading Manual MRJT 1 Figure 4.9. A pallet having a freight platform which measures 200 cm x 250 cm has a total mass of 300 kg. The pallet is carried on two ground supports each measuring 20 cm x 200 cm. Using the loading manual for the transport aeroplane, calculate how much mass may be added to, or must be off loaded from, the pallet in order for the load intensity to match the maximum permitted distribution load intensity for lower deck forward cargo compartment.

1. 2.

3. 4. 158.3 kg must be off loaded. Flag this question

Question 8 of 14
Number: 4516 Question: At reference or see Loading Manual MRJT 1 Figure 4.9. From the loading manual for the jet

2. 3. 68 kg per square metre. 4. 150 kg per square foot. Flag this question

Question 9 of 14
Number: 4517 Question: At reference or see Loading Manual MRJT 1 Figure 4.9. From the loading manual for the

2. 3062 kg 3. 9232 kg 4. 1568 kg Flag this question

Question 10 of 14
Number: 4518 Question: At reference or see Loading Manual MRJT 1 Figure 4.9. From the Loading Manual for the transport aeroplane, the maximum load that can be carried in that section of the aft cargo compartment

2. 421.5 inches is 2059 Lbs. 3. 835.5 inches is 6752 kg. 4. 421.5 inches is 4541 kg. Flag this question

Question 11 of 14

Number: 5471 Question: The floor limit of an aircraft cargo hold is 5 000 N/m2. It is planned to load-up a cubic container measuring 0,4 m of side. It's maximum gross mass must not exceed: (assume g=10m/s2)

1.

2. 3. 800 kg 4. 32 kg Flag this question

Question 12 of 14
Number: 5481 Question: The floor of the main cargo hold is limited to 4 000 N/m2. It is planned to load a cubic container

2. 1 000 kg 3.

4. Flag this question

Question 13 of 14
Number: 14059 Question: The maximum floor loading for a cargo compartment in an aircraft is given as 750 kg per square metre. A package with a mass of 600 kg. is to be loaded. Assuming the pallet base is entirely in contact with

3. 40 cm by 300 cm 4. 30 cm by 200 cm Flag this question

Question 14 of 14
Number: 6202 Question: Given: Maximum Floor Strength = 300 kg/m Maximum Running Load = 350 kg/m Which of the

2. 500 Kgs - Dimensions 1.5m x 1m x 1m

3.

4. Flag this question

Question 1 of 1
Number: 13036 Question: For the purpose of completing the Mass and Balance documentation, the Dry Operating Mass is defined as:

2. The total mass of the aircraft ready for a specific type of operation excluding crew and crew baggage.

4. The total mass of the aircraft ready for a specific type of operation excluding all traffic load.

Vous aimerez peut-être aussi