Académique Documents
Professionnel Documents
Culture Documents
User Manual
Thanks for purchasing Robosapiens transistor based dual H-Bridge motor driver. This Circuit is designed to use in multiple applications. This document covers detail features of this product with step by step screen shots of handling procedure.
Features:
1. Small in size. 2. Two TTL based H- Bridge Circuit. 3. Standard pin connections. 4. Power Jack for DC Adapter. 5. WAGO Connector for DC Power Supply 6. Standard operating voltage up to 9V. 7. Power Indicator LED. 8. Motor Enable indicator LED. 9. Motor Enable Switch 10. Back EMF protection diodes. 11. No soldering required. 12. Four Sensor Input Ports 13. Two Motor Output Ports 14. Capable of driving two DC Motors or one Stepper motor. 15. It can be used in multiple robotic models (line follower, light searching, sound operated etc.)
2. There is a switch one for power to the circuit, power supply can be provide by DC Jack or WAGO Connector
Applications
You can use this kit anywhere when two low ampere motor are to be derived
Warranty
The H bridge motor driver kit is intended for personal experimental and amusement use and in no case should be used where the health or safety of persons may depend on its proper operation. Robosapiens provides no warrantee of suitability or performance for any purpose for the product. Use of the product software and or hardware is with the understanding that any outcome whatsoever is at the users own risk. Robosapiens sole guarantee is that the software and hardware perform in compliance with this document at the time it was shipped to the best of our ability given reasonable care in manufacture and testing. All products are tested for their best performance before shipping, and no warranty or guarantee is provided on any of them. Of course the support is available on all of them for no cost.