Académique Documents
Professionnel Documents
Culture Documents
A few things to keep in mind while completing this activity: 1. Do not use the browser Back button or close or reload any exam windows during the exam. 2. Do not close Packet Tracer when you are done. It will close automatically. 3. Click the Submit Assessment button to submit your work.
Introduction
In this practice Packet Tracer Skills Exam, you will: finish the configuration of a partially configured network establish connectivity to the East Region and the Internet through the use of static and dynamic routing
Addressing Table
Device Interface S0/0/0 S0/0/1 WestHQ S0/1/0 S0/1/1 Lo0 Fa0/0 W-Branch1 Fa0/1 S0/0/0 172.16.100.246 255.255.255.252 n/a 172.16.100.1 255.255.255.128 n/a Address Subnet Mask Default Gateway
Lo0 Fa0/0 Fa0/1 W-Branch2 S0/0/0 Lo0 Fa0/0 ServerFarm Fa0/1 Lo0 WPC1 WPC2 NetAdmin Payroll NIC NIC NIC NIC
172.16.100.130 172.16.100.194
255.255.255.192 255.255.255.224
172.16.100.129 172.16.100.193
Note: The password for user EXEC mode is cisco. The password for privileged EXEC mode is class.
b. Configure the correct IP addresses on WPC2 and W-Branch1. Configure WPC2 with the last IP address in the subnet. Configure the Fa0/1 interface on W-Branch1 with the last IP address in the subnet.
c. Verify connectivity.
East Region Subnets 192.168.0.0/25 192.168.0.128/25 192.168.1.0/26 192.168.1.64/26 192.168.1.128/26 192.168.1.192/27 192.168.1.224/28 192.168.1.240/30 192.168.1.244/30 192.168.1.248/30 192.168.1.252/30
Configure a default route on WestHQ to send to the Internet all other traffic for destinations that are not found in the WestHQ routing table. Use the outbound interface argument.
b. Modify the default OSPF operation. Configure W-Branch1 to always be the DR by using a priority of 100. Configure W-Branch2 to always be the BDR by using a priority of 50. Change the hello interval to 20 seconds on W-Branch1 and W-Branch2 for the LAN that these two routers share with ServerFarm. Verify OSPF neighbor status.
c. Verify that OSPF is fully operational. Verify that the routing tables on W-Branch1, W-Branch2, and WestHQ contain all the expected routes. It may be necessary to shutdown and then reactivate interfaces to force OSPF to converge.
To test the static route to East Region, successfully ping between WestHQ and EPC1. To test the OSPF neighbor establishment with ServerFarm, successfully ping between WPC1 and Payroll. To test end-to-end connectivity between the East and West Regions, successfully ping between WPC2 and EPC3. To test the default route, successfully ping the Cisco Server from NetAdmin.