Académique Documents
Professionnel Documents
Culture Documents
introduction
drywall systems dry linings suspended ceilings acoustic ceilings dry screeds raised floor system attics
17.02.2011
2011.12.01.
17.02.2011
technical performance
drywall systems height: 2,75 - 10,0 + acoustic insulation capacity: 41 - 69 dB fire resistance: 0,2 - 1,5 (3,0) h
17.02.2011
2011.12.01.
technical performance
17.02.2011
technical performance
17.02.2011
2011.12.01.
wall systems
17.02.2011
wall systems
17.02.2011
2011.12.01.
wall systems
d
Vidovszky BUTE/BME-Faculty of Architecture Department of Construction Technology and Management
17.02.2011
wall systems
d
Vidovszky BUTE/BME-Faculty of Architecture Department of Construction Technology and Management
17.02.2011
2011.12.01.
wall systems
17.02.2011
wall systems
d
17.02.2011
2011.12.01.
wall systems
17.02.2011
in every 15 m at the geometrical turns of the partitions at the dilatations of the superstructure
17.02.2011
2011.12.01.
expansion joint
20 20 20 20
plasterboard
CW-studs insulation
17.02.2011
Sliding slab-connection joints if the expectable f value of the slab is more than 15mm recommended in case of over 7.00 meters distance between the supports of the slab fire-protective or normal the figures in the catalogues are valid up to max. 25 mm creep
17.02.2011
2011.12.01.
a 10 20
Uniflott
a = 10-25 mm
a = 10-25 mm
F 30
F 90
dry lining
the board is placed into a CD or a UD stud plasterboard stripe band plasterboard shape
17.02.2011
2011.12.01.
dry lining
Vapour technique differing outer boundary system should be checked (vapour barrier)
17.02.2011
suspended ceiling
Supports
Rapid hanger
Ankerfix support system > 0.25 and 0.40 kN load bearing capacity
Vidovszky BUTE/BME-Faculty of Architecture Department of Construction Technology and Management 17.02.2011
10
2011.12.01.
17.02.2011
17.02.2011
11
2011.12.01.
suspended ceiling
A B D D C B C c
100 ca. 100
suspended ceiling
A B D D C B C c
100 < 1220
17.02.2011
12
2011.12.01.
suspended ceiling
ca. 400
< 1220
1250
1250
2. layer
1. layer
17.02.2011
suspended ceiling
Nonius-support - upper part dry lining separation strip Nonius-fixing bolt Nonius lower part (0.4 kN)
fast-construction screw In case of fire-protection gypsum plaster rendering on the whole surface
17.02.2011
13
2011.12.01.
suspended ceiling
UD-stud 28x27x06 edge trim 23x15 (in case of demand) Do not fasten to the UD-stud!
dowels
17.02.2011
suspended ceiling
corner joint
CD 60 x 27 separation strip
17.02.2011
14
2011.12.01.
suspended ceiling
dowel
direct supports for the CD 60x27 studs LN 3,5x9 mm screw for fixing on the framework
Fireshield
17.02.2011
suspended ceiling
The continuity of the suspended ceiling is ensured by the lining around the lamps.
17.02.2011
15
2011.12.01.
suspended ceiling
17.02.2011
dry srceeds
gypsum fibre boards: gypsum in combination with reinforcing cellulose fibres two factory-glued 10 or 12,5mm thick 1500 x 500 mm Knauf Vidifloor board connect the boards with overlapping (joint staggering) on each sides
17.02.2011
16
2011.12.01.
? dry srceeds
two 10 or 12,5mm thick 1500 x 1000 mm Knauf Vidifloor board are glued together in situ for double-layer lining join the boards with half a board overlapping/joint staggering
17.02.2011
raised floors
17.02.2011
17
2011.12.01.
raised floors
17.02.2011
? raised floors
17.02.2011
18
2011.12.01.
raised floors
17.02.2011
raised floors
1 - pedestal 2 - panel 3 - vent 4 - perforated panel 5 electrical box 6 skirting 7 suction grip tool
17.02.2011
19
2011.12.01.
raised floors
17.02.2011
raised floors
17.02.2011
20
2011.12.01.
pargeting work
decoration work
17.02.2011
17.02.2011
21
2011.12.01.
References
Wiesner Gyrgy: Knauf ltalnos bemutat (presentation) http://www.knauf-gipsfaser.com/knauf/home-gf.nsf/Vidiwall_Vidifloor_en.pdf 2011.11.09. http://www.knauf-gipsfaser.com/knauf/home-gf.nsf/vPagesLookup/home~en 2011.11.09. http://www.knauf-integral.de/english 2011.11.09. http://manual.knaufdrywall.co.uk/ 2011.11.09. http://www.knauf.ae 2011.11.09.
17.02.2011
22