Académique Documents
Professionnel Documents
Culture Documents
Page 1 of 2
Service Information
Document Title: Function Group: Information Type: Service Information Date: 01/09/2009
EMS power shut off relay, RE3701 ON Battery relay, RE3101 ON Start switch signal is transferred to E-ECU.
Engine speed is set to the value which corresponds to I2 mode. Engine speed is set to the value which corresponds to the mode selected by engine speed control switch, if operation of operating lever, travel pedal, rotator button or engine speed control switch occurs.
Start switch signal is transferred to E-ECU. Important data are stored in ECUs. EMS power shut off relay, RE3701 OFF. Battery relay, RE3101 OFF.
http://localhost/Prosis/Pages/Print.aspx?PrintType=4&ObjectID=241144&infotype=1,2,5,8,... 9/1/2009
Prosis - Print
Page 2 of 2
Figure 2 Emergency engine speed control switch (I-ECU equipped) The function is for emergency operation of engine when malfunction of data bus or V-ECU occurs. If malfunction of data bus or V-ECU occurs, engine speed will set to the value which corresponds to I2 mode regardless of emergency switch position 1 or 2. Emergency switch position Position 0 (Engine stop) Position 1 (Idle speed) Position 2 (High speed) Out functions Engine will shut down, if the switch is at this position for more than three seconds.[1] Engine speed is set to I2 mode. Engine speed is set to H mode.[2]
[1] This function is used when the engine is not OFF, even though the start switch is turned to OFF position. [2] G1 mode to North America
http://localhost/Prosis/Pages/Print.aspx?PrintType=4&ObjectID=241144&infotype=1,2,5,8,... 9/1/2009