wes 020
M60 OS6RA
8. Use LRT-60-009 to remove nut securing 11. Use a suitable drift to remove both halves of
‘actuator push rod to long arm, spper bush from long arn,
9. Remove nut and bolt securing actuator to short 42. Use suitable adaptors lo press actuator rod end
‘arm and remove actuator. bush from long arm.
a7
1. Restrain torsion bar and remove long arm
‘securing bolt and washer. Remove long arm
from torsion bar.
CAUTION: The short arm and torsion bar
are supplied as an assembly and must not
be separated.
wos coascF
REPAIRS 64-39REAR SUSPENSION
Refit
1. Clean bush locations in long arm,
2. Use suitable adaptors to press new actuator
rod end bush into long arm. Ensure bush is
correctly aligned,
Mea 00278
3. Align slots in new slipper bush halves with
those in long arm. Carefully press both halves
of slipper bush into long arm. Ensure the
sealing rings on the bush faces are not
damaged.
4. Clean long arm and mating face on torsion bar.
5. Fitlong arm to torsion bar. Restrain torsion bar
‘and tighten bot to 180 Nm (133 ib.
6. Ensure actuator and bushes are clean.
7. Fit actuator and tighten nut and bolt securing
‘actuator to short arm to 180 Nm (133 Ib.)
8. Using LRT-60-009 , itand tighten nut securing
‘actuator push rod to long arm to 48 Nm (35
itt)
8. With assistance, position torsion bar and
‘actuator to vehicle and fit torsion bar clamps.
Tighten torsion bar clamp bolts to 45 Nm (33
tot)
10. Connect pipes to actuator with cap nuts and
new sealing washers. Tighten cap nuts to 29
Nm (21 Ibf). Ensure pipes are not under
tension or kinked.
1,
12,
13,
14,
15,
Fit anti-roll bar links to torsion bar and tighten
ruts to 50 Nm (37 Ib.)
Ensure washer is in place on lower ball joint of
‘each anti-roll bar link and connect lower ball
joints to axle. Tighten nuts to 100 Nm (74 Ib.)
= (CE high pressure fiter.
UG FRONT SUSPENSION, REPAIRS,
Filter - high pressure - ACE.
Lower vehicle.
=" "6 hydraulic system,
ES _ FRONT SUSPENSION,
ADJUSTMENTS, ACE hydraulic system
bleeding.
64-40 REPAIRSBRAKES
Brake system control component layout
M70 08058
RH drive shown, LH drive similar
1 Hill descent switch
2 ABS sensor
3 SLABS ECU
DESCRIPTION AND OPERATION 70-1