Académique Documents
Professionnel Documents
Culture Documents
Def initi on
Pur pose
Intramuscular injection is used for the delivery of certain drugs not recommended
for other routes of administration, for instance intravenous, oral, or subcutaneous.
The intramuscular route offers a faster rate of absorption than the subcutaneous
route, and muscle tissue can often hold a larger volume of fluid without discomfort.
In contrast, medication injected into muscle tissues is absorbed less rapidly and
takes effect more slowly that medication that is injected intravenously. This is
favorable for some medications.
Preca ution s
Descri ption
Intramuscular (IM) injections are given directly into the central area of selected
muscles. There are a number of sites on the human body that are suitable for IM
injections; however, there are three sites that are most commonly used in this
procedure.
De lt oid mus cl e
The deltoid muscle located laterally on the upper arm can be used for intramuscular
injections. Originating from the Acromion process of the scapula and inserting
approximately one-third of the way down the humerus, the deltoid muscle can be
used readily for IM injections if there is sufficient muscle mass to justify use of this
site. The deltoid's close proximity to the radial nerve and radial artery means that
careful consideration and palpation of the muscle is required to find a safe site for
penetration of the needle. There are various methods for defining the boundaries of
this muscle.
Vastus la teralis mus cl e
The vastus lateralis muscle forms part of the quadriceps muscle group of the upper
leg and can be found on the anteriolateral aspect of the thigh. This muscle is more
commonly used as the site for IM injections as it is generally thick and well formed
in individuals of all ages and is not located close to any major arteries or nerves. It is
also readily accessed. The middle third of the muscle is used to define the injection
site. This third can be determined by visually dividing the length of the muscle that
originates on the greater trochanter of the femur and inserts on the upper border of
the patella and tibial tuberosity through the patella ligament into thirds. Palpation
of the muscle is required to determine if sufficient body and mass is present to
undertake the procedure.
The gluteus medius muscle, which is also known as the ventrogluteal site, is the
third commonly used site for IM injections. The correct area for injection can be
determined in the following manner. Place the heel of the hand of the greater
trochanter of the femur with fingers pointing towards the patient's head. The left
hand is used for the right hip and vice versa. While keeping the palm of the hand
over the greater trochanter and placing the index finger on the anterior superior iliac
spine, stretch the middle finger dorsally palpating for the iliac crest and then press
lightly below this point. The triangle formed by the iliac crest, the third finger and
index finger forms the area suitable for intramuscular injection.
Determining which site is most appropriate will depend upon the patient's muscle
density at each site, the type and nature of medication you wish to administer, and
of course the patient's preferred site for injections.
Preparation
Before ad mini st ering med ication , a health care practitioner verify the
medication order for accuracy and prepare the medication from the vial or ampule.
• First, ensure you have identified the patient and assist them into a position
which is comfortable and practical for access to the injection site you have
chosen.
• Locate the correct area for injection using the above guidelines or those
taught during medical training. Clean the site with an alcohol swab or other
cleansing agent.
• Prepare the syringe by removing the needle cover, inverting the syringe, and
expelling any excess air. Approximately 0.1–0.2 ml of air should be left in the
syringe so that the air in the top of the syringe chamber, when the syr in ge
and need le are pointing down, forces the entire amount of medication to
be delivered. This also prevents medication residue from being left in the
needle, where it can leak into the subcutaneous and dermal layers when the
syringe and needle are removed from the muscle.
• When ready to inject, spread the skin using the fingers of the non-dominant
hand. Holding the syringe with the thumb and forefinger of the dominant
hand, pierce the skin and enter the muscle. This process should be done
quickly with sufficient control so as to lessen the discomfort of the patient. If
there is little muscle mass, particularly in infants or the elderly, then you may
need to pinch the muscle to provide more volume of tissue in which to inject.
• Aspirate at the injection site (while syringe and needle are within the muscle)
by holding the barrel of the syringe with the non-dominant hand and pulling
back on the syringe plunger with the dominant hand. If blo od appears in the
syringe, it is an indication that a blood vessel may have been punctured. The
needle and syringe should be immediately withdrawn and a new injection
prepared. If no blood is aspirated, continue by slowly injecting the medication
at a constant rate until all medication has been delivered.
• Withdraw the needle and syringe quickly to minimize discomfort. The site
may be briefly massaged, depending on the medication given. Some
medication manufacturers advise against massaging the site after injection,
as it reduces the effect and intention of the medication by dispersing it too
readily or over too large an area. Manufacturers' recommendations should
be checked.
• Discard the used syringe and needle intact as soon as possible in an
appropriate disposal receptacle.
• Check the site at least once more a short time after the injection to ensure
that no bleeding, swelling or any other signs of reaction to the medication
are present. Monitor the patient for other signs of side effects, especially if it
is the first time the patient is receiving the medication.
• Document all injections given and any other relevant information.
Af ter care
Def initi on
Pur pose
Preca ution s
Descri ption
With the subcutaneous route, a small thin needle is inserted beneath the skin and
the drug injected slowly. The drug moves from the small bl oo d ves sel s into the
bloodstream. Subcutaneous injections are usually given in the abdomen, upper
arm, or the upper leg.
Preparation
The hands should be washed, and gloves may be worn during the procedure. A
syr in ge and needle should be prepared. If a sterile, multiple-dose vial is used,
the rubber-capped bottle should be rubbed with an antiseptic swab. The needle is
then inserted through the center of the cap and some air from the syringe inserted
to equalize the pressure in the container. Slightly more of the required amount of
drug is then removed. Holding the syringe vertically at eye level, the syringe piston is
pushed carefully to the exact measurement line.
If a small individual vial containing the correct amount of drug is used, the outside
should be wiped with an antiseptic swab and held in the swab while the top is
removed. The needle is then inserted into the vial, taking care that the tip of the
needle does not scratch against the sides of the vial, thereby becoming blunt.
A syringe and needle containing the drug should be placed on a tray with sterile
cotton swabs, cleaning disinfectant, and adhesive tape. If the patient is unfamiliar
with the procedure, the nurse should explain what he or she is about to do and that
the patient is to receive medication prescribed for them. The dose on the patient's
prescription sheet should be checked prior to administration.
A screen should be drawn around the patient to avoid any personal embarassment.
The injection site is then rubbed vigorously with a swab and disinfectant to cleanse
the area and increase the blo od supply. A small piece of skin and subcutaneous
tissue is pinched between the thumb and forefinger, and the needle inserted quickly
at a 45-degree angle. Certain drugs such as heparin are given at a 90-degree angle
rather than at 45 degrees. It is important to ensure that the needle is not in a vein.
Therefore the syringe should be aspirated a little by pulling back on the piston. If
blood is present, the needle should be re-injected, and the piston withdrawn slightly
once more. The skin is then released and the syringe piston pushed down steadily
and slowly.
A sterile cotton swab should be pressed over the injection site as the needle is
quickly withdrawn, and the swab is taped to the skin for a few minutes, if required.
Af ter care
Monitor the patient's reaction and provide reassurance if required. Dispose of all
waste products carefully, and place the syringe and needle in a puncture-resistant
receptacle. Wash the hands. For patients requiring frequent injections, the site is
changed each time.
Administering an Intradermal Injection
Def initi on
Intradermal injections are injections given to a patient in which the goal is to empty
the contents of the syringe between the layers of the skin.
Pur pose
Intradermal injection is often used for conducting skin aller gy tests and testing
for antibody formation.
Preca ution s
This is a painful procedure and is used only with small amounts of solution. The
nurse should ensure that the needle is inserted into the epidermis, not
subcutaneously, as absorption would be reduced. It is imperative that the following
information is reviewed prior to administration of any medication: the right patient,
the right medicine, the right route, the right dose, the right site, and the right time.
Because this method of injection is often used in allergy testing, it is important that
latex-free syringes are used.
Descri ption
With the intradermal injection, a small thin needle of 25 or 27 gauge and 3/8 to
3/4 inch (1-2 cm) is inserted into the skin parallel with the forearm, with the bevel
facing upward. These injections are normally given in the inner palm-side surface of
the forearm, with the exception of the human diploid cell rabies vaccine, which is
given in the deltoid muscle.
Preparation
After washing his or her hands, the nurse should put on latex-free gloves to
complete the procedure. A sterile syringe and a needle should be prepared. If a
sterile multiple-dose vial is used, the rubber-capped bottle should be rubbed with an
antiseptic swab. The needle is then inserted through the center of the cap, and
some air from the syringe inserted to equalize the pressure in the container. Slightly
more of the required amount of drug is should then be removed. The syringe should
be held vertically at eye level, then the syringe piston should be pushed carefully to
the exact measurement line.
If a small individual vial containing the correct amount of drug is used, the outside
should be wiped with an antiseptic swab and held in the swab while the top is
snapped off. The needle is then inserted into the vial, taking
care that the tip of the needle does not scratch against the sides of the vial, thereby
becoming blunt.
The syr in ge and needle containing the drug should be placed on a tray with
sterile cotton swabs and cleaning disinfectant. If the patient is unfamiliar with the
procedure, the nurse should explain what he or she is about to do, and let the
patient know that the medication was prescribed by the doctor. As with all drugs
prescribed for a patient, the dose on the patient's prescription sheet should be
checked prior to administration.
A screen should be drawn around the patient to ensure privacy. The injection site is
then rubbed vigorously with a swab, and disinfectant applied to cleanse the area
and increase the bl oo d supply. With the bevel of the needle facing upwards, the
needle is inserted into the skin, parallel with the forearm. The syringe piston should
then be pushed in steadily and slowly, releasing the solution into the layers of the
skin. This will cause the layers of the skin to rise slightly.
Af ter care
Monitor the patient's reaction and provide reassurance, if required. Dispose of all
waste products carefully and place the syringe and needle in a puncture-resistant
receptacle.
Administering an Intramuscular Injection
a. Ventrogluteal – Patient may lie on back or side with hip and knee
flexed.
b. Vastus lateralis – Patient may lie on the back or may assume a sitting
position.
c. Deltoid – Patient may sit or lie with arm relaxed.
d. Dorsogluteal – Patient may lie prone with toes pointing inward or on
side with upper leg flexed and placed in front of lower leg.
7. Locate site of choice (outer aspect of upper arm, abdomen, anterior aspect
of thigh, upper back, upper ventral or dorsogluteal area). Ensure that area is
not tender and is free of lumps or nodules.
8. Clean area around injection site with an alcohol swab. Use a firm circular
motion while moving outward from the injection site. Allow antiseptic to dry.
Leave alcohol swab in a clean area for reuse when withdrawing the needle.
10. Grasp and bunch area surrounding injection site or spread skin at site.
11. Hold syringe in dominant hand between thumb and forefinger. Inject needle
quickly at an angle of 45 to 90 degrees, depending on amount and turgor of
tissue and length of needle.
12. After needle is in place, release tissue. If you have a large skin fold pinched
up, ensure that the needle stays in place as the skin is released. Immediately
move your nondominant hand to steady the lower end of the syringe. Slide
your dominant hand to the tip of the barrel.
15. Withdraw needle quickly at the same angle at which it was inserted.
16. Massage area gently with alcohol swab. (Do not massage a subcutaneous
heparin or insulin injection site.) Apply a small bandage if needed.
17. Do not recap used needle. Discard needle and syringe in appropriate
receptacle.
19. Remove gloves, if worm, and dispose of them properly. Perform hand
hygiene.