Académique Documents
Professionnel Documents
Culture Documents
Your new Frontman 65R amplifier delivers worldclass Fender tone and worldstandard Fender quality: 65W output power into 8 ohms Selectable Normal and Drive channels independent volume and tone controls with Fender touch-sensitive circuit design simulates the feel of tube distortion PRE-AMP OUT and POWER-AMP IN jacks allow you to connect external effects devices, other amplifiers or sound/recording equipment to your FM 65R FOOTSWITCH jack for use with the 1-button Fender footswitch (included). The footswitch provides remote channel selection
'&/%&3.64*$"-*/4536.&/54
MID-CONTOUR button furnishes many different variations in distortionfrom Rock to Blues to Metal to whatever! */1654 Classic Fender spring Reverb
Thank you for choosing FenderThe Worlds most popular instrument amplifierssince 1946
CH SELECT MID CONTOUR
*/1654
VOLUME
TREBLE
BASS
DRIVE
VOLUME
TREBLE
MID
BASS
REVERB
FOOT SWITCH
PRE OUT
PWR IN
'&/%&3.64*$"-*/4536.&/54
A. INPUT - Plug your guitar in here. INPUT 1 is normal sensitivity for most guitars, INPUT 2 is lower sensitivity for guitars with high output (active) pickups. B. VOLUME - Adjusts the loudness of the Normal channel. C. TREBLE/BASS - Adjusts the high- and low-frequency tones of the Normal channel. D. DRIVE - Adjusts the distortion level in the Drive channel. Use together with VOLUME-{F} to adjust the overall loudness of the Drive channel. E. CHANNEL INDICATOR LED OFF n Normal channel is active LED ON n Drive channel is active F. VOLUME - Adjusts the loudness of the Drive channel together with DRIVE {D}. G. CHANNEL SELECT Button OUT selects the Normal channel Button IN selects the Drive channel H. TREBLE/MID/BASS - Adjusts the high-, middle-, and low-frequency tones of the Drive channel. I. MID-CONTOUR - Activates a scooped midrange EQ useful for modern distortion sounds in the Drive channel. J. REVERB - Adjusts the Reverb level for both channels.
K. FOOTSWITCH - Connect the 1-button Fender footswitch (included) at this jack to enable remote channel selection. When plugged in, the footswitch overrides the CH SELECT button. L. PRE OUT/PWR IN - (1) Effects Loop - Connect PRE OUT to an effects device input, then connect the effects device output to PWR IN. (2) Multiple Amps - Connect the primary units PRE OUT to the auxiliary units PWR IN. The primary unit is used to control all auxiliary amps. (3)-Recording or Reinforcement - Connect PRE OUT to sound equipments input. Both jacks use a TS (Tip-Sleeve) standard type plug for connections. PRE OUT includes onboard tone shaping. M. POWER INDICATOR - Lights up when the amplifier is on. N. POWER - Switches the amplifier on and off. O. POWER CORD SOCKET - Connect the included power supply cord in accordance with the voltage and frequency ratings listed on the rear panel of your amplifier.
fe nde r.co m
fe nde r.co m