Académique Documents
Professionnel Documents
Culture Documents
JSS1
TERM WEEK
1
2
3
4
5
6
first
7
8
1
2
Second
3/4
5
6
THIRD
8
1
2
3-4
5
6
7
8
PRACTICAL ACTIVITY
Identification of Drawing Tools
Board practice
Construction and Bisection of Lines
Construction of angles 60o and 90o
Bisection of angle/Construction angle 90o and 60o
Identification of Soft and Hard Wood
Identification of Wood Defects
Identification of ferrous and Non-ferrous metals
Determination of Properties of Metals: Sound, lustre, Hardness, Heat
Conductivity, Electrical conductivity
Free Hand Sketching (circles, arcs and lines)
Board practice
Construction of Circles and Lines
Identification of the Parts of a Circle
Division of a circle into 4 and 8 equal parts
Experiment to identify conductors and insulators
Determination of Magnetic Field of a magnet
Determination of the North pole and South pole of the earth using a Bar
magnet
Identification of Wood Work hand tools
Identification of Metal Work Hand tools
Experiment to show the sound energy travels through a medium
Construction of circles II
Construction of angles II
Geometrical construction I: triangles[Parts and Types]
Free hand sketching (Workshop tools)
Identification of Electrical Measuring instruments and devices
Identification of various Machines
Experiment to show that friction causes heat and wear
JSS2
TERM WEEK
1
2
3
4
First
5
6
7
8
1
2
3/4
Second
5
6
7
8
1
2
3
THIRD
4-5
6
7
8
PRACTICAL ACTIVITY
Construction of angles
Division of Circles into 6 and 12 equal parts
Division of a straight line into equal parts
Development of Shapes: Cube, Cubiod, Cone
Soldering
Cutting Screw Threads
Construction of a Temporal Magnet
Construction of Triangle given three sides
Construction of triangle given two angles and an included side
Construction of Triangle given two sides and an included angle
Circumscribing of a Triangle
Inscribing of a Triangle
Identification of Electricals Devices
Excursion: JIC Electrical Power Generation, Transmission and Distribution
Identification of Major parts of a refrigerator
Division of a straight line into proportion
Locating center of circles
Geometrical construction II: Squares and Rectangles
Geometrical Construction III: polygons
Abrasives: practical Use of Abrasives
Identification of Nails, Screws and Locks
Orthographic projection (introduction)
JSS3
TERM WEEK
1-2
3-4
5
first
6
7
7
8
PRACTICAL ACTIVITY
Orthographic projection
Isometric Drawing
Oblique drawing
Setting Out.
Identification of Building Tools
Link mechanism
Metal/Woodwork Project
15,000:00
4,000:00
# 133,700:00
#260,000;00
NOTE :
The block engine will be cut if it has not been cut before but if it has been cut before then it cannot be cut
again and the mechanic says there will be no 6months guarantee.
RECOMMENDATION
The Admin office therefore, recommends option 2 which is the purchase of a Belguim engine with the
following reasons;
1. Since the body of the bus is still good, Belgium engine will be better as It will serve longer
2. It will reduce frequent repairs in the engine.
Sign:
Mr. Wasinda Mhya ------------------------------------------------- VP. Admin
Mr.Daniel I.Amaefule ---------------------------------------------- Senior Master Admin.
Mr.Bulus Kok -------------------------------------------------------- Admin Asst.