Académique Documents
Professionnel Documents
Culture Documents
Pagina 1 din 4
ExpertCore
Where Technology Meets Passion Skip to content
Search Search
Advanced search
Portal Board index Engineering Embedded Processors & Programming Microcontrollers Change font size Print view Arcade Points Medals Register Login
1 post Page 1 of 1
4. Controlling Section
Circuit Diagram :
http://www.expertcore.org/viewtopic.php?f=18&t=4161
31.10.2013
ExpertCore View topic - How to make a Water Level Indicator & Controller usin... Pagina 2 din 4
Level Sensor module is made of with HT12E encoder and ASK (Amplitude Shift Keying) RF transmitter. This circuit can be drive using 9V battery. This circuit is placed near the Water Tank and connected to the tank as show in the figure below.
3. Receiver Section
Circuit Diagram:
http://www.expertcore.org/viewtopic.php?f=18&t=4161
31.10.2013
ExpertCore View topic - How to make a Water Level Indicator & Controller usin... Pagina 3 din 4
Receiver Module is made of with HT12D decoder and ASK RF receiver. The data transmitted by the Sensor module is received by this module and is given to the Controlling Module.
4. Controlling Section
Circuit Diagram :
http://www.expertcore.org/viewtopic.php?f=18&t=4161
31.10.2013
ExpertCore View topic - How to make a Water Level Indicator & Controller usin... Pagina 4 din 4
Water Level Indicator Controller using PIC Microcontroller 5.jpg (91.77 KiB) Viewed 91 times
The soul of the Controlling Section is PIC16F877A. It process the data given by the Receiver Section. LCD Display, LED Indications and Motor status are updated according to the data.
Working
For the transmission and reception of data we have used Holtek encoder-decoder pair of HT12E and HT12D. Both of them are CMOS ICs working voltage ranges from 2.4 to 12v. The oscillator resistances are chosen according to the datasheet. When water level raises, the data pins of the encoder will be grounded corresponding to the level of water, which will be transmitted to the Receiver via ASK RF module. The received data is decoded by the decoder HT12D. LED on the receiver indicates that it is receiving data. Then the data is given to the PIC for processing.
When the water level becomes Very Low, the motor will turned ON, buzzer sounds and the LCD backlight will automatically turned ON for 5 seconds. After this, when the water level reaches Full level, the motor will automatically turned OFF, buzzer sounds and the LCD backlight will automatically turned ON for 5 seconds. During normal operation you can manually turn on LCD backlight by pressing the Push button switch. The LCD indicates the Level of water (Very Low, Low, Medium, High,'Full) and the status of the motor (ON or OFF). The LED bar will also indicate the level of water.
Ashika Posts: 39 Joined: Mon Aug 19, 2013 8:41 am Cash on hand: 7,729.20 Invitations sent: 0 Registered friends: 0 Reputation point: 2
E-mail Ashika
Go
Who is online
Users browsing this forum: No registered users and 1 guest Disclaimer : The views and comments entered in these forums are personal and are not necessarily those of the management of this board. The management of this board is not responsible for contents or external links entered by users.
Portal Board index The team Delete all board cookies All times are UTC
Powered by phpBB 2000, 2002, 2005, 2007 phpBB Group 2009-2011 ExpertCore Labs
http://www.expertcore.org/viewtopic.php?f=18&t=4161
31.10.2013