Académique Documents
Professionnel Documents
Culture Documents
DL 40
SA
Major subassemblies
T T T
Diaphragm Seats Balls
Wetted piston Centre block Steel Stainless steel AISI 321 (1.4541) Steel Steel Cast aluminium Cast aluminium Cast aluminium Cast bronze Cast aluminium AA FA
Internals
NRS NBR (Buna N) EPDM (Nordel) EPDM (High press.) EPDM (grey) FKM (Viton) PTFE (Teon) Ceramic 1) EPDM grey for Type DH PTFE for Type DH Stainless steel NBR, steel core EPDM, steel core EPDM, grey with steel core PTFE, steel core Conical valve, EPDM
CA CX SA
B N E D G F T U P
B N E F T E
B N E G T K R Y W X Z I
Cast stainless Stainless steel steel AISI 316 AISI 321 (1.4408) (1.4541)
1)
Cast stainless Stainless steel Cast bronze steel AISI 316 AISI 321 (1.4408) (1.4541)
SX
15 3.5 3.5 9
25 4 5.5 8.7
40 6 5.8 9
50 8 5.8 9
80 10 6 9
Metal pumps with internal components of NRS NBR, EPDM FKM PTFE
For pumps equipped with valve seats and valve balls of PTFE and those with cone valves, a decrease in suction lift must be expected.
FA 3 7 13 30 55
CA 11 21 46 96
2
SA 12 21 46 96
SX 12 23 49 100
Example: To help you select the correct pump size Required pumping rate is 17 m3/h and required total discharge head is 20m. The correct selection is DL 50, the required air pressure is 3.8 bar and the air consumption is 1.5 Nm3/min.
Example: During the conveyance of a product with a viscosity of 6000 mPa s, the pumping rate decreses to 60 percent of the rated value, based on water.
4,000
6,000
8,000
10,000
12,000
14,000
16,000
18,000
20,000
22,000
Viscosity of the transported medium mPa s/cP % Decrease in pumping rate 80 60 40 20 0 0 Suction head 2 4 6 8 Example: With a suction lift of 4 mWC, the pumping rate decreases by about 20%. This figure varies with different pump configurations. 10 mWC
Extremely rugged construction reduces downtime to a minimum. DEPA pumps have been designed in such a way that all components in contact with the product can be disassembled and reassembled within a few minutes. This means that servicing work is reduced to the absolute minimum. DEPA air driven diaphragm pumps have been developed as a modular system. Consequently, many componentssome of which are common to all versionsare mutually compatible and interchangeable. This exible construction allows quick and simple changing of the internals for all Type DL models, to full different applications.
Air connection
A B C D E F
Suction
G H I
in.
in.
in.
in.
There is a DEPA diaphragm pump for practically every liquid that ows. DEPA air driven diaphragm pumps are available in three different basic con4/00
structions: cast metal, solid plastic and highly polished stainless steel (CIP compatible). Special purpose designed models are available for powders, high pressures up to 21 bar
and drum pumping of hard-to-handle drum contents. For more information please contact your local supplier.
Leaet No 6421
All information published here is subject to change without notice.