Vous êtes sur la page 1sur 3

How to Avoid PWHT

Page 1 of 3

HOW TO AVOID PWHT

The above picture is of a new pressure vessel that failed during its hydraulic test. The vessel had been stress relieved, but some parts of it did not reach the required temperature and consequently did not experience adequate tempering. This coupled with a small hydrogen crack, was sufficient to cause catastrophic failure under test conditions. It is therefore important when considering PWHT or its avoidance, to ensure that all possible failure modes and their consequences are carefully considered before any action is taken.

The post weld heat treatment of welded steel fabrications is normally carried out to reduce the risk of brittle fracture by: l

Reducing residual Stresses. These stresses are created when a weld cools and its contraction is restricted by the bulk of the material surrounding it. Weld distortion occurs when these stresses exceed the yield point. Finite element modelling of residual stresses is now possible, so that the complete welding sequence of a joint or repair can be modelled to predict and minimise these stresses.

http://www.gowelding.com/met/pwht.htm

14/12/2013

How to Avoid PWHT

Page 2 of 3

Tempering the weld and HAZ microstructure. The microstructure, particularly in the HAZ, can be hardened by rapid cooling of the weld. This is a major problem for low and medium alloy steels containing chrome and any other constituent that slow the austenite/ferrite transformation down, as this will result in hardening of the micro structure, even at slow cooling rates.

The risk of brittle fracture can be assessed by fracture mechanics. Assuming worst-case scenarios for all the relevant variables. It is then possible to predict if PWHT is required to make the fabrication safe. However, the analysis requires accurate measurement of HAZ toughness, which is not easy because of the HAZs small size and varying properties. Some approximation is possible from impact tests, providing the notch is taken from the point of lowest toughness. If PWHT is to be avoided, stress concentration effects such as: backing bars, partial penetration welds, and internal defects in the weld and poor surface profile, should be avoided. Good surface and volumetric NDT is essential. Preheat may still be required to avoid hydrogen cracking and a post weld hydrogen release may also be beneficial in this respect (holding the fabrication at a temperature of around 250C for at least 2 hours, immediately after welding). Nickel based consumables can often reduce or remove the need for preheat, but their effect on the parent metal HAZ will be no different from that created by any other consumable, except that the HAZ may be slightly narrower. However, nickel based welds, like most austenitic steels, can make ultrasonic inspection very difficult. Further reduction in the risk of brittle fracture can be achieved by refining the HAZ microstructure using special temper bead welding techniques.

http://www.gowelding.com/met/pwht.htm

14/12/2013

How to Avoid PWHT

Page 3 of 3

Further Information On: -

Temper Bead Welding Technique Fracture Mechanics (Link temporarily Disabled) Residual Stresses Metallurgy of Steel

Return To Menu Page

Page last updated 10 June 2002

http://www.gowelding.com/met/pwht.htm

14/12/2013

Vous aimerez peut-être aussi