Académique Documents
Professionnel Documents
Culture Documents
SA-480/SA-480M
three weeks from the date of the notification to the seller of the rejection. In case of dissatisfaction with the results of the test, the seller is permitted to make claim for a rehearing within that time.
25.1.1.4 25.
Packaging, Marking, and Loading
25.1 For Commercial Procurement: 25.1.1 Marking- Unless otherwise specified in the
applicable material specification or the purchase order, marking shall be conducted as follows:
25.1.1.1
on one face, in the location indicated below with the speci fication designation number, type of steel (type or UNS designation), material identification number, and the name or mark of the manufacturer. For sheet, strip, and plate whose length and width dimensions are both less than 24 in., each piece shall be marked with the type of steel and material identification number. The specification and designation number, and name or mark of the manufacturer shall be marked on the piece(s) or attached to the item or bundle. The characters shall be of such size as to be clearly legible. The marking shall be sufficiently stable to with stand normal handling. Unless otherwise specified by the purchaser, the marking, at the producer's option, is permit ted to be done with (a) marking fluid (if a specific maximum impurity limit of designated elements in the marking fluid is required by the purchaser, it shall be so stated on the purchase order), (b) low-stress blunt-nosed continuous or low-stress blunt-nosed-interrupted-dot die stamp, (c) a vibratory tool with a minimum tip radius of 0.005 in. [0.1 mm], or (d) electro-chemical etching.
tag
25.1.1.7 The AIAG primary metals identification (AIAG B-5) is permitted to be used as an auxiliary
method of identification in cases where a bar-coded identi fication tag is desired. Use of this method shall be by agreement between purchaser and supplier.
25.2 For U.S. Government Procurement: 25.2.1 When specified in the contract or order, and
for direct procurement by or direct shipment to the govern ment, marking for shipment shall be in accordance with Fed. Std. No. 123 for civil agencies and MIL-STD-129 for military agencies.
849