Vous êtes sur la page 1sur 2

Interlock list for CCM 1.

Turret When rotating, both arms must be at up position; When arm going up, relevant cover must be at up position 2. Tundish car Both Tundish cars can only move to casting position when turret arm is at up position. 3. Assistant withdrawal: When casting stopped, assistant withdrawal can move forward and backward manually; During casting, assistant withdrawal will synchronize with withdrawal at same speed. 4. Main hydraulic station Main pump can only be started with any one circulation pump is running; When oil level is lower than 5cm, main pump will stop automatically; When oil temperature is higher than 55 , main pump will stop automatically. 5. TCM For first cutting after casting start (billet head cutting), select semi-auto for TCM, and manually control clamp to clamp, then switch TCM to auto, then TCM can receive order of camera cut-to-length or encoder cut-to-length. 6. Transportation roller table: in total 3 groups of roller table. On auto mode, after cutting is over, roller table 1,2 will start, after 5 seconds, roller table 3 will start, roller table 1 will stop after 40s, 2 and 3 will stop after 45s; if there is billet on discharge roller table, and at same time there is biller on roller table 3, roller table 2,3 will stop automatically, after billet on discharge roller table was tilted up, tilter at down position, stopper will move down, and roller table 2 and 3 will automatically start and send billet to discharge roller table. 7. Stopper On auto mode, when there is billet on discharge roller table, stopper will go up automatically, after billet on discharge roller table was tilted up, and tilter is at down position, stopper will go down automatically. 8. Discharge roller table On auto mode, 5s after transportation roller table 3 is started, discharge roller table will start, and will stop after 40s, or when billet touch the end spring switch; after billet is tilted up, and tilter is at down position, stopper will go down, if there is billet on transportation roller table 3, discharge roller table will start automatically. 9. Tilter On auto mode, when there is billet on discharge roller table, tilter will go up automatically, and go down 2s after reach the upper limit; When transfer car is moving billet, tilter is forbidden to go up, when transfer car is moving backward, tilter is allowed to go up; When stamping machine is stamping billet, tilter of this strand is forbidden to go up, after stamping finished, tilter is allowed to go up. 10. Transfer car On auto, if stamping machine is normal, when detecting 3 times stamping finished order, transfer car will start to move, until slow down and stop, 2s after transfer car stop, it will go back to home position;

If stamping machine is abnormal, when detecting 3 times tilter movement, transfer car start to move billets, until slow down and stop, 2s after transfer car stop, it will go back to home position; 11. Billet splitter On auto mode, billet splitter is at horizontal position (upper limit), when transfer car move to front limit, meanwhile cooling bed is at lower and back limit, billet splitter will go down automatically, when cooling bed move billet away (after 3 circles), billet splitter will go up automatically, and wait for following billets. 12. Cooling bed On auto mode, cooing bed will move in circle, when transfer car move billets to splitter, cooling bed will stop at back and lower limit, after splitter go to lower limit, cooling bed will start automatically to move billets

Vous aimerez peut-être aussi