4-396 Circuit packs description
Enhanced Trunk Switch (ETS) (NTUG90AN)
Overview
OME6500 supports 1+1 Enhanced Trunk Switch (ETS) unidirectional
automatic and user-initiated protection switch capabilities for 10G WT, 10GEL
WT, 10G OTR, 2x10G OTR, 10G OTSC and 40G MUX OCI circuit packs by
using Ciena Optical Metro 5100/5200 Enhanced Trunk Switch (ETS) module
(NTUG9OAN) as shown in Figure 4-173 and Figure 4-174.
Figure 4173
441 ETS protection
Primary Path (working ine)
Cigatpaw aia
Aco oe | ae CSS | ofsmach|s —subtondng
‘Subtending = Re Te ren Fee Equipment
Equipment ry 5 Le
Te Ce
Re ETS reat ETS
| bua we || le |,
Ly Sp} drome phere
‘Swich > tx TR Layer x [Pix ‘Enitter
‘Secondary Path (protection tne)
Legena
CS = Client side
US =Line side
Optical Multiservice Edge 6500 Planning, Part of 5
Release 7.0 NTRN1OBR Standard. sue 2
Copyright Ciena® Corporation September 2010Circuit packs description 4-397
Figure 4-174
141 ETS protection (example for 40G MUX OCI circuit pack)
ETS protection is supported on the following circuit packs:
+ 10G OTR
+ 2x10G OTR
+ 10GOTSC
+ 10G OC-192/STM-64 WT
+ 10GELWT
+ 40G MUX OCI
Figure 4-175 shows an interior view of the four-channel tray.
Optical Multiservice Edge 6500 Planning, Part 2 of 5
Release 7.0 NTRN1OBR Standard. Issue 2
Copyright Ciena® Corporation September 20104-398 Circuit packs description
Figure 4-175
Front view of a Enhanced Trunk Switch
ts of three parts: the ETS shelf, the ETS Comms module, and
the ETS Switch module.
ETS Shelf
‘The ETS Shelf is a two-slot, 1U high, rack-mount shelf that contains the ETS
Switch module and ETS Comms module.
The ETS Comms and ETS Switch modules are both individually field
replaceable. However, only the ETS Comms can be replaced in-service. The
ETS shelf also provides easy front access for fiber connections. The ETS
Shelf also includes a 5-pin power terminal block located on the rear of the unit
for redundant DC power supply connections. The ETS Shelf requires a fan
module to cool the shelf.
The internal backplane connection in the ETS Shelf supplies electrical power
and supports monitoring and configuration for each module (ETS Switch and
ETS Comms module) installed in the unit. You can make a TCP connection to
the ETS Shelf by connecting an Ethemet cable to the 10BASE-T Ethernet
connector (RJ-45) on the backplane of the ETS Shelf.
Attention: Both the RS-232 DB9 serial port on the ETS Comms module and
the RJ-45 Ethernet port on the back panel of the ETS Shelf support the same
set of TL1 commands.
Optical Multiservice Edge 6500 Planning, Part 2 of 5
Release 7.0 NTRN1OBR Standard. Issue 2
Copyright Ciena® Corporation September 2010