Vous êtes sur la page 1sur 1

Tubular Heat Exchanger Rating Sheet

Project Item No. Medium Pressure Feed water Heater sizing Service Feed water Heating Project No. By Date/Time
19-Nov-13 12:42

Step 1. Input flows, conditions and properties data for shellside and tubeside. Tube Side Feed Water 4 18 878.0 320 384.8 55.821 0.154 1.041 2 82 45 312 0.396 0.0002 0.98 Fluid Name Flow (M), lb/h Temp. in, oF o Temp. out, F 3 , lb/ft , cP cp, Btu/lb oF Q, Btu/h k, Btu/hft oF R, ft2h oF/Btu cp/k 55.4 47.1
o o

Shell

Step 4. Start configuring the exchanger. Begin with the total calculated transfer coefficients to this point (i.e., not including shellside h): Ustart = 120 On that basis, assumed Uo = Then the required transfer A = Number of tubes required = Reset tubes/pass (Step 3), then no. of passes = Total tube count = Tubeside P (incl. returns) = Actual effective transfer area, A = 275 2 180 448 2 450 1.871 2 189

Btu/hft2 oF Btu/hft2 oF ft2

Av. Density Av. Viscosity Av. Heat Capacity Heat Exchanged Av. Thermal Conductivity Fouling Resistance Prandtl No.

Medium Steam 28 305.0 557.6 329 0.4526 0.017 0.6055 2 82 43 578 0.2103 0.0002 0.12 F F

psi ft2

Step 5. Select tube arrangement and estimate shell diameter

Tube Pitch Pattern

0.94 Tri 27 9.45 30 0.358 1.080 79 032 4 12 851 0.00104 0.108 420.4 485 279.8 1.7% 315.1

in. in. in. ft2 in. lb/hft2

Uncorrected MTD Corrected MTD

Step 2. Input tubing OD, BWG and length (can be trial and error).

Tube OD BWG Tube ID, d =

0.7500 16 0.620 24.78 0.302 4.866

in. in. ft. in.2 ft2

Shell ID from Tube Count Tables Select Baffle Spacing Number of Baffles = Flow Area across Bundle, as = Equivalent Diameter, de (see table) = Mass Velocity, Gs = Shellside Reynolds No., NRe = Shellside Friction Factor = Shellside P = Outside Transfer Factor, jh = Outside Film Coefficient, ho = Calculated Uo = Check: % difference, Ucalc. vs Uassum. = Uclean =

Tube Length, L = Flow area per tube, at = Effective transfer area per tube =

psi

Step 3. Estimate the number of tubes per tube pass.

Tubes/pass = lb/h per tube = Av. velocity, fps = Tubeside Reynolds No., NRe = Tubeside Friction Factor, f = P per pass, psi = Nusselt number, Nr = Inside Film Coefficient, hi =

225 1 862 4.42 1 23 423 0.006 0.35 11.74 900

Step 6. Check tubeside velocity and P, shellside P. If too high or too low, adjust tube length, number of tubes per pass, number of passes, and/or shell baffle spacing. Remember to reset shell diameter from tube count tables, as required.

Vous aimerez peut-être aussi